BLOWN INTAKE MANIFOLD GASKET. VEHICLE DID NOT HAVE AN OVERHEATING ISSUE, AND HAS BEEN WELL MAINTAINED SINCE I'VE OWNED IT. DROVE ACROSS A STEEP 7 MILE HILL, TEMP GAUGE STARTED MOVING ABOVE NORMAL. I STOPPED AND LET IT COOL DOWN, MOTOR GOT TO ABOUT 245 DEGREES WELL BEFORE ANY WARNING LIGHTS WERE ABLE TO COME ON. STARTED THE MOTOR…
Read full complaint
BLOWN INTAKE MANIFOLD GASKET. VEHICLE DID NOT HAVE AN OVERHEATING ISSUE, AND HAS BEEN WELL MAINTAINED SINCE I'VE OWNED IT. DROVE ACROSS A STEEP 7 MILE HILL, TEMP GAUGE STARTED MOVING ABOVE NORMAL. I STOPPED AND LET IT COOL DOWN, MOTOR GOT TO ABOUT 245 DEGREES WELL BEFORE ANY WARNING LIGHTS WERE ABLE TO COME ON. STARTED THE MOTOR AND IT SOUNDED DIFFERENT SO I POPPED THE HOOD AND THE COOLANT OVERFLOW WAS BUBBLING. NOTICED THE WINDSHIELD STARTED STEAMING UP, AND A VERY ROUGH IDLE. SHUT THE MOTOR OFF AND STARTED IT AGAIN. WHITE SMOKE COMING FROM THE TAILPIPE. TURN IT OFF AGAIN AND OPENED THE OIL CAP AND IT HAD THE MAYO LOOK AND SMELLED OF ANTIFREEZE. PULLED THE DIPSTICK AND THE OIL WAS BROWN AND SEPARATED. GOT IT HAULED HOME. DID AN INSPECTION AND ANTIFREEZE WAS ALL DOWN THE BLOCK. TOOK THE MOTOR APART AND THE LOWER INTAKE MANIFOLD GASKET WAS JUST DETROYED. CHEVROLET HAS HAD NOTHING BUT PROBLEMS OUT OF THESE 3.4 GEN 3 MOTORS. THEY ALL NEED TO BE RECALLED AND THE PROBLEM CORRECTED. DOESN'T MATTER IF YOU KEEP THE COOLANT FLUSHED AND OIL CHANGED. HEAD GASKETS WERE IN THE SAME SHAPE I CHANGED THEM TOO. ALL TOGETHER COST ME OVER $1000 BETWEEN GASKET KITS, HEAD BOLTS, INTAKE BOLTS, COOLANT, OIL, FILTER, FLUSH, AND THAT WAS CHANGING THE HEAD GASKET, LOWER AND UPPER INTAKE MANIFOLD GASKET COMPLETELY BY MYSELF. THESE MOTORS ARE SO HARD TO WORK ON, I JUST COULDN'T AFFORD TO HAVE SOMEONE DO IT FOR ME. IT'S JUST BAD TO BUY A VEHICLE AND HAVE THIS PROBLEM. MOST VENTURE OWNERS HAVE CHANGED HEAD GASKETS OR INTAKE GASKETS MORE THAN ONCE. TOYOTA RECALLED THEIR 3.0 MOTORS FOR THIS PROBLEM, WHY IS GM NOT MADE TO RECTIFY THIS CONTINUOUS PROBLEM. THE VAN HAS ALOT OF OTHER PROBLEMS AS WELL, BODY RUST, HEADLIGHTS YOU CANNOT SEE WITH, OIL SEAL LEAKS, STEERING KNUCKLE PROBLEMS, SLIDING DOOR ISSUES, RADIO PROBLEMS, ELECTRICAL PROBLEMS, SIGNAL LIGHTS, ABS PROBLEMS. FUEL PUMP PROBLEMS. IT'S A LEMON
NHTSA ODI #11378031
159,000 miles · Aug 2, 2015
Electrical SystemEngineFuel/propulsion System
TEMP GAUGE TRYS GO HOT HAD CHECK NOTHING ENGENE MISFIRE HAD CHECK 7 TIMES NOW. REPLACE MASS AIR TEMP SENSORE TWICE THROTTLE POSITION SENSORS. PLUGS AND WIRES TWICE IN ONE MONTH HAS WIRE SHORTAGE FOR AC AND WE HAVE PAID OUT ALOT OF MONEY FROM DAY 2 OF OWNING THIS WAS GOING SELL BUT I WOULD SELL THIS CRAP TO NO ONE.. NOW SAY…
Read full complaint
TEMP GAUGE TRYS GO HOT HAD CHECK NOTHING ENGENE MISFIRE HAD CHECK 7 TIMES NOW. REPLACE MASS AIR TEMP SENSORE TWICE THROTTLE POSITION SENSORS. PLUGS AND WIRES TWICE IN ONE MONTH HAS WIRE SHORTAGE FOR AC AND WE HAVE PAID OUT ALOT OF MONEY FROM DAY 2 OF OWNING THIS WAS GOING SELL BUT I WOULD SELL THIS CRAP TO NO ONE.. NOW SAYS O2 SENSORE LEFT WHEEL SENSOR AND MUCH MORE CODES JUNK LIKE THIS DONT NEED TO BE SOLD..
NHTSA ODI #10745619
145,000 miles · Dec 1, 2012
Engine
VEHICLE WAS SHOWING 'HOT COOLANT TEMPERATURE' AND WAS TAKEN TO THE MECHANIC FOR REPAIRS. AFTER JUST MONTHS THE SAME PROBLEM RETURNED. *TR
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2002 Chevrolet Venture Problems, Complaints & Recalls | Skip That Year
Illustration