IllustrationI NEED TO KNOW WERE I CAN FIND OUT WHO I TEX TO RECALL THIS VAN THERE ARE TO MANY THINGS THATS GOING WRONG WITH IT I FIX ONE THING AND SOMETHING ELSE GO WRONG WITH IT LOOK I HAVE CANCER AND NEED A GOOD CAR TO GO TO STANFORD CANCER PLEASE CAN U HELP ME.
1999 Chevrolet Venture
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Venture do not stand out strongly from the model-year median of 220.
About this comparison →How this year compares
Owner complaints by model year
Compare all Venture years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3225–50K
5250–75K
3275–100K
17100–150K
2150K+
143 reports with mileage · 206 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports27 injury reports
What owners actually said
349 reportsTL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT WOULD FLASH 7 TIMES THEN REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED A FAILURE CODE FOR THE AIR BAGS. THE VEHICLE WAS NOT TAKEN TO A …
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT WOULD FLASH 7 TIMES THEN REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED A FAILURE CODE FOR THE AIR BAGS. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,500.
CPSC: I1480097A. 1999 CHEVY VENTURE. CONSUMER STATED THAT SHE HAS A DEFECTIVE VEHICLE. *LN
IN SEPTEMBER OF 2013 I NOTICED OIL IN COOLANT RESERVOIR. TOOK TO THE MECHANIC. CLOSER INSPECTION SHOWED HEAD GASKETS WERE DESTROYED. HAD THE HEAD GASKET REPLACED AND THE COOLANT FLUSHED OUT AS WELL AS CHANGED ALL COOLANT HOSES, WATER PUMP, AND THERMOSTAT TO THE TUNE OF $900.00 DOLLARS. VEHICLE ONLY HAS 84000 MILES ON IT. PURCHA…
Read full complaint
IN SEPTEMBER OF 2013 I NOTICED OIL IN COOLANT RESERVOIR. TOOK TO THE MECHANIC. CLOSER INSPECTION SHOWED HEAD GASKETS WERE DESTROYED. HAD THE HEAD GASKET REPLACED AND THE COOLANT FLUSHED OUT AS WELL AS CHANGED ALL COOLANT HOSES, WATER PUMP, AND THERMOSTAT TO THE TUNE OF $900.00 DOLLARS. VEHICLE ONLY HAS 84000 MILES ON IT. PURCHASED NEW IN 1999. USED THE VEHICLE DAILY FOR FOUR MONTHS WHEN THE TEMPERATURE GAGE STARTED FLUCTUATING FROM HOT TO COLD AND FOUND THERE WAS VERY LITTLE HEAT. VEHICLE WOULD THEN IDLE ROUGH. BROUGHT BACK TO THE MECHANIC AND IT APPEARS THE SAME ISSUE IS OCCURRING. YOU'VE GOT TO BE KIDDING ME. ANOTHER $800-$1000 NO WAY. MECHANIC ADVISES THIS IS COMMON FOR VENTURES. THANKS CHEVY LOOKS LIKE I'LL BE SHOPPING FOR A HONDA. *TR
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED WHILE DRIVING 40 MPH AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. A MECHANIC DIAGNOSED THAT THE FUEL LINE AND FUEL TANK MELTED DUE TO THE EXHAUST. THE CONTACT PATCHED UP THE FUEL TANK AND THE FUEL LINE SINCE IT WAS DEFECTIVE. THE MECHANIC S…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED WHILE DRIVING 40 MPH AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. A MECHANIC DIAGNOSED THAT THE FUEL LINE AND FUEL TANK MELTED DUE TO THE EXHAUST. THE CONTACT PATCHED UP THE FUEL TANK AND THE FUEL LINE SINCE IT WAS DEFECTIVE. THE MECHANIC STATED THE FUEL TANK AND THE FUEL LINES NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 140,000.
MY WIFE SMELLED GASOLINE UPON ENTERING THE CAR ON OCTOBER 7, 2012. I CHECKED UNDER THE CAR FROM WHERE THE SMELL WAS COMING FROM, AND SAW GASOLINE DRIPPING FROM A PIPE NEAR THE GAS TANK. I BROUGHT THE CAR TO THE LOCAL CHEVY DEALERSHIP. I HAD TO REPLACE FOUR FUEL AND EVAPORATION LINES DUE TO CORROSION. IT COST ME OVER $1,000 TO R…
Read full complaint
MY WIFE SMELLED GASOLINE UPON ENTERING THE CAR ON OCTOBER 7, 2012. I CHECKED UNDER THE CAR FROM WHERE THE SMELL WAS COMING FROM, AND SAW GASOLINE DRIPPING FROM A PIPE NEAR THE GAS TANK. I BROUGHT THE CAR TO THE LOCAL CHEVY DEALERSHIP. I HAD TO REPLACE FOUR FUEL AND EVAPORATION LINES DUE TO CORROSION. IT COST ME OVER $1,000 TO REPLACE THESE LINES. I FEEL VERY FORTUNATE THAT I WAS ABLE TO CORRECT THIS PROBLEM BEFORE A DISASTER COULD HAVE OCCURRED. I COULD HAVE BEEN DRIVING ON THE HIGHWAY WITH GASOLINE LEAKING ONTO MY EXHAUST PIPE. I THINK THAT THESE VANS SHOULD BE RECALLED IMMEDIATELY BEFORE SOMEONE IS SERIOUSLY INJURED. IT IS AN ABSOLUTE DISGRACE THAT CHEVY WOULD PUT IN FUEL LINES THAT HAD ANY POSSIBILITY OF CORRODING. THEY SHOULD BE MADE AWARE OF THIS SERIOUS PROBLEM AND CORRECT IT IMMEDIATELY. *TR
PURCHASED VEHICLE BRAND NEW. MANIFOLD GASKET LEAK AT 35,000 MILES REPAIRED BY GM. FAILED AGAIN AT 70,000 MILES BUT GM WOULDN'T COVER THE COST, PAID $900 OUT OF POCKET. NOW AT 112,000 MILES AND SUSPECT THAT IT IS IN NEED OF REPLACEMENT AGAIN. THE LIFTERS ARE ALSO MAKING NOISE. THE MECHANICS ARE TELLING ME THAT THIS IS A VERY COMM…
Read full complaint
PURCHASED VEHICLE BRAND NEW. MANIFOLD GASKET LEAK AT 35,000 MILES REPAIRED BY GM. FAILED AGAIN AT 70,000 MILES BUT GM WOULDN'T COVER THE COST, PAID $900 OUT OF POCKET. NOW AT 112,000 MILES AND SUSPECT THAT IT IS IN NEED OF REPLACEMENT AGAIN. THE LIFTERS ARE ALSO MAKING NOISE. THE MECHANICS ARE TELLING ME THAT THIS IS A VERY COMMON PROBLEM. GM NEEDS TO TAKE RESPONSIBILITY FOR THIS DESIGN FLAW IN THEIR ENGINE. THE GOVERNMENT NEEDS TO STEP IN AND ORDER A RECALL. *LN
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN SHE SMELLED A BURNING ODOR. SHE THEN NOTICED WHITE SMOKE EMITTING FROM THE FRONT DRIVER SIDE DOOR. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. THE CONTACT AND PASSENGERS IMMEDIATELY EXITED THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN SHE SMELLED A BURNING ODOR. SHE THEN NOTICED WHITE SMOKE EMITTING FROM THE FRONT DRIVER SIDE DOOR. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. THE CONTACT AND PASSENGERS IMMEDIATELY EXITED THE VEHICLE. THE CONTACT WAITED FIFTEEN MINUTES TO ALLOW THE DOOR TO COOL DOWN BEFORE ACCESSING. THE INNER DOOR PANEL WAS DETACHED. THE PLASTIC PARTS INSIDE OF THE DOOR PANEL WERE MELTED AND OTHER INNER COMPONENTS WERE SEVERELY DAMAGED. THE VEHICLE RESUMED NORMAL OPERATION AND WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER REGARDING THE SAFETY HAZARD. THE FAILURE MILEAGE WAS UNKNOWN.
TL*THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT THE PASSENGER SLIDING DOOR WOULD OPEN INVOLUNTARILY. HE HAD TO PULL OVER, TURN OFF THE VEHICLE, OPEN AND CLOSE THE DOOR AND LOCK IT IN ORDER TO KEEP IT CLOSED. THE CONTACT PREVIOUSLY HAD THE DOOR REPAIRED ACCORDING TO RECALLS 01V067000 & 01V264000 (LATCHES/LOC…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT THE PASSENGER SLIDING DOOR WOULD OPEN INVOLUNTARILY. HE HAD TO PULL OVER, TURN OFF THE VEHICLE, OPEN AND CLOSE THE DOOR AND LOCK IT IN ORDER TO KEEP IT CLOSED. THE CONTACT PREVIOUSLY HAD THE DOOR REPAIRED ACCORDING TO RECALLS 01V067000 & 01V264000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) BUT THE DEALER REFUSED TO REPAIR IT AGAIN. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT HE WOULD HAD TO PAY FOR A DIAGNOSTIC TEST. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 80,000.
1999 CHEVROLET VENTURE, WHILE TRAVELING A FIRE ERUPTED IN THE ENGINE COMPARTMENT. *BF (OHIO TRAFFIC CRASH REPORT # 10-0260-91) UPDATED 07/22/10 *BF
Official recalls
404V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
99V071000 · Steering:gear Box:shaft Sector
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available