NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
42 reports116,000 miles · Mar 6, 2026
Fuel System, GasolineFire
The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further insp…
Read full complaint
The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further inspection, white/blue smoke was seen coming from under the vehicle, and the vehicle later caught on fire from the fuel pump/tank. The fire had leaked onto the floor; however, it had extinguished on its own. A police report was not filed; however, Law Enforcement arrived on scene to direct traffic. The local fire department did not arrive on scene. No injuries were sustained, nor medical attention was sought. The vehicle failed to restart. The vehicle was towed to a local tow yard, where it was deemed a total loss by the insurance provider. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,000.
NHTSA ODI #11722553
236,000 miles · Oct 26, 2022
SteeringSuspension
The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assem…
Read full complaint
The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passenger’s side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the failure. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 236,000.
NHTSA ODI #11490992
130,000 miles · May 23, 2017
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THA…
Read full complaint
TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP AND DEEMED DESTROYED BY THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10991158
49,357 miles · Aug 11, 2015
Exterior LightingStructureCrashInjury
MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES TH…
Read full complaint
MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.
NHTSA ODI #10747955
225,000 miles · Feb 15, 2015
Fuel/propulsion System
WE HAVE BEEN SMELLING GASOLINE FUMES IN AND OUTSIDE OUR VAN. SOMETIMES IT IS VERY POTENT AND OTHER TIMES FAINT. WHEN WE WALK INTO OUR GARAGE, WE CAN SMELL IT ALSO. IT OCCURS OFTEN WHEN MAKING A LEFT-HAND TURN. WHEN WE INSPECT IT, WE CAN'T FIND ANY LEAK. WE SMELL THIS FROM A HALF TANK TO EMPTY. *TR
NHTSA ODI #10683516
Mileage unknown · Nov 10, 2014
Air BagsCrashInjury
2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A R…
Read full complaint
2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, HIS FATHER HIT THE STEERING WHEEL WITH HIS CHEST CAUSING DAMAGE TO HIS LUNGS, SPLEEN, KIDNEYS AND RIBS. HIS STEP-MOTHER HIT THE DASH AND CENTER CONSOLE WITH HER HEAD, CUTTING HER ACROSS THE FOREHEAD. *JB
NHTSA ODI #10651206
90,000 miles · Aug 7, 2014
Seat Belts
TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/…
Read full complaint
TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/2014*LJ UPDATED 7/14/2015*JS
NHTSA ODI #10619552
85,000 miles · Jul 3, 2014
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED FUEL WITHIN THE CABIN OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FUEL ODOR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10608071
85,000 miles · Jul 2, 2014
Fuel System, Gasoline
THE VAN FILLS WITH FUEL FUMES. THE FUMES CAN BE SMELLED INSIDE AND OUTSIDE THE VEHICLE. GM HAS RECALLED CHEVY VENTURE 2001-2004 FOR SPECIFIC VIN#'S BUT NO 2005'S AND MY SPECIFIC VIN# IS NOT INCLUDED. I HAVE TALKED WITH GM BUT THEIR RESPONSE IS JUST YOUR VIN# IS NOT INCLUDED. YOU CAN GO TO THE DEALERSHIP AND PAY FOR IT TO GE…
Read full complaint
THE VAN FILLS WITH FUEL FUMES. THE FUMES CAN BE SMELLED INSIDE AND OUTSIDE THE VEHICLE. GM HAS RECALLED CHEVY VENTURE 2001-2004 FOR SPECIFIC VIN#'S BUT NO 2005'S AND MY SPECIFIC VIN# IS NOT INCLUDED. I HAVE TALKED WITH GM BUT THEIR RESPONSE IS JUST YOUR VIN# IS NOT INCLUDED. YOU CAN GO TO THE DEALERSHIP AND PAY FOR IT TO GET FIXED. THIS IS A SPECIFIC FIRE HAZARD ACCORDING TO THEIR REPORTS. I HAVE HAD TO PARK MY VEHICLE FOR SAFETY REASONS. I CAN NOT ALLOW MY CHILDREN TO BE SUBJECTED TO THE FUEL FUMES OR THE POTENTIAL OF A FIRE. I AM NOT IN A POSITION AT THIS TIME TO PAY FOR THE WORK OR TRADE DUE TO THE ECONOMY. IF GM KNOWS THAT HAVE THIS PROBLEM THEN WHY WOULD THEY LET A POTENTIAL HAZARD TO LOYAL CUSTOMERS CONTINUE. REGARDLESS OF THE VIN# IF THE PROBLEM IS PRESENT THEN GM SHOULD BE RESPONSIBLE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10607740
Mileage unknown · Jun 8, 2014
Air BagsSteeringCrash
THE DRIVER WAS SLOWING OR STOPPED WHEN SHE WAS REAR ENDED. THE FRONT DRIVER SEAT AIRBAG DEPLOYED. IT IS UNCLEAR WHETHER THE AIRBAG DEPLOYED PREMATURELY OR WHETHER IT DEPLOYED AFTER THE VEHICLE WAS REAR ENDED. *TR
NHTSA ODI #10596950
NHTSA investigations
2EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Illustration