SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 BMW 525I

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.

About this comparison →
35Owner complaints

Model-year median: 11

0Recall campaigns

View recall details →

2Investigations

View investigation details →

Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.

Inspection summary

2005 BMW 525I

NHTSA snapshot: September 18, 2026. 35 owner complaints · 0 recall campaigns · 2 investigations.

Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.

Top reported categories (up to 5)

  • Air Bags: 22 reports
  • Seat Belts: 7 reports
  • Seats: 6 reports
  • Electrical System: 4 reports
  • Power Train: 4 reports

Full reported-category list and vehicle report

Recall links

    No recall campaigns in this snapshot.

    Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.

    Print the top reported categories, recall links, snapshot date and comparison limits.

    How this year compares

    Owner complaints by model year

    Other model years Selected year
    28
    2002    32
    2003    84
    2004    35
    2005    77
    2006    72
    2007    1
    2008
    Compare all 525I years →

    Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.

    What owners reported most

    Air Bags
    22    Seat Belts
    7    Seats
    6    Electrical System
    4    Power Train
    4
    All reported categories
    Unknown Or Other
    3    Engine
    1    Exterior Lighting
    1    Fuel/propulsion System
    1    Service Brakes
    1    Steering
    1

    Tap a category to read its complaints. One report may name several components.

    When problems were reported

    Mileage at the reported incident

    30 reports with mileage · 5 unknown

    NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

    What to inspect

    Issues worth paying extra attention to based on owner reports.

    • Air Bags. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
    • Seat Belts. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
    • Seats. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

    NHTSA owner reports · September 18, 2026 snapshot.

    0 crash reports4 fire reports1 injury reports

    Seats complaints

    6 reports
    Clear category filter
    82,000 miles · Jan 9, 2018
    Air BagsSeats

    AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENG…

    Read full complaint

    AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENGER SEAT, THE ERROR CODE CAME BACK WITH THE SAME FAULT CODE.

    NHTSA ODI #11061337

    16 miles · Jan 23, 2015
    Air BagsSeat BeltsSeats

    THE FIRST DAY I GOT MY BRAND NEW 2005 BMW 525I WAS IN DECEMBER OF 2004 AND I WAS DRIVING IT AND A EMERGENCY WARNING LIGHT CAME ON TELLING ME THAT SOMETHING WAS WRONG WITH THE TRANSMISSION, TO PULL OVER AND HAVE IT TOWED TO THE NEAREST BMW DEALERSHIP. I HAD TO GET MY BRAND NEW CAR TOWED BACK TO THE DEALERSHIP WHERE THEY REPLACED…

    Read full complaint

    THE FIRST DAY I GOT MY BRAND NEW 2005 BMW 525I WAS IN DECEMBER OF 2004 AND I WAS DRIVING IT AND A EMERGENCY WARNING LIGHT CAME ON TELLING ME THAT SOMETHING WAS WRONG WITH THE TRANSMISSION, TO PULL OVER AND HAVE IT TOWED TO THE NEAREST BMW DEALERSHIP. I HAD TO GET MY BRAND NEW CAR TOWED BACK TO THE DEALERSHIP WHERE THEY REPLACED THE TRANSMISSION. THIS WAS ONLY THE BEGINNING OF A CYCLE OF EVENTS THAT NEVER HAPPENED WITH MY HONDA ACCORD, MERCEDES, ACURA, BLAZER OR SATURN. MY SCREEN LIGHTS UP LIKE A CHRISTMAS TREE ALL THE TIME WITH ALL KINDS OF STRANGE WARNINGS THAT UNLESS YOU ARE AN ENGINEER MIGHT AS WELL BE IN SWAHILI. I HAVE HAD A PROBLEM WITH THE PASSENGER RESTRAINT SYSTEM FAILURE LIGHT STAYING ON AND NO ONE CAN FIGURE THAT ONE OUT. I HAVE HAD A FLAT TIRE LIGHT COME ON (IT'S ON RIGHT NOW) WHEN THERE IS NO FLAT TIRE. THE WOOD PANELING ON THE PASSENGER'S SIDE ABOVE THE GLOVE COMPARTMENT HAS 3 HUGE CRACKS THAT GO ALL THE WAY THROUGH IT. MY GLOVE COMPARTMENT WON'T OPEN BECAUSE THE HANDLE BROKE OFF. MY SUNROOF COVER FLIES BACK INTO THE BACK OF THE TOP OF THE CAR AND GETS LOST BACK THERE AND THERE IS NO WAY TO REACH IT. THE LIGHTER (WHICH I NEED FOR A CHARGER FOR MY PHONE) MALFUNCTIONS AND THE WOODEN PANEL COVER DISAPPEARED INTO THE INTERIOR COMPONENT OF THE CAR AS I WATCHED HELPLESS LEAVING A BIG UGLY GAPING HOLE. I AM SO CAREFUL WITH MY CAR AND CAN'T BELIEVE THIS IS WHAT I GOT FOR $50,000. THESE ARE PROBLEMS THAT A 1972 VOLVO MIGHT DEAL WITH BUT MY 2005 BMW? THE REPAIRS AND SERVICE ARE OUTLANDISHLY EXPENSIVE AND TO HAVE THESE PROBLEMS IS SIMPLY UNACCEPTABLE. THE FRONT DRIVER FLOOR MAT GETS STUCK UNDER THE PEDALS ALMOST MAKING ME WRECK! I'M EMBARRASSED WITH HOW MY BRAND NEW BMW HAS TURNED INTO A "GHETTO" RIDE. *TR

    NHTSA ODI #10678628

    90,000 miles · Mar 1, 2014
    Air BagsSeats

    A PASSENGER ENTERED MY CAR AND SAT IN THE FRONT PASSENGER SEAT. APPROXIMATELY 30 SECONDS LATER, A WARNING CAME UP ON MY DASHBOARD ABOUT A PASSENGER RESTRAINT MALFUNCTION. THE SEATBELT SIGNAL AND AIRBAG SIGNAL REMAINED ILLUMINATED ON MY DASHBOARD THEREAFTER...EACH TIME I DRIVE MY VEHICLE. I READ AN ONLINE NOTICE FROM 2008 SAYING …

    Read full complaint

    A PASSENGER ENTERED MY CAR AND SAT IN THE FRONT PASSENGER SEAT. APPROXIMATELY 30 SECONDS LATER, A WARNING CAME UP ON MY DASHBOARD ABOUT A PASSENGER RESTRAINT MALFUNCTION. THE SEATBELT SIGNAL AND AIRBAG SIGNAL REMAINED ILLUMINATED ON MY DASHBOARD THEREAFTER...EACH TIME I DRIVE MY VEHICLE. I READ AN ONLINE NOTICE FROM 2008 SAYING THAT BMW ISSUED A RECALL FOR THIS ISSUE, HOWEVER, UPON ENTERING MY VIN NUMBER ON THEIR WEBSITE, THEY SAID THERE ARE NO KNOWN RECALLS FOR MY VEHICLE. *TR

    NHTSA ODI #10566581

    157,000 miles · Nov 27, 2012
    SeatsFire

    TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE DRIVER SEAT HEATING SYSTEM FAILED. THE CONTACT SMELLED SMOKE WHILE THE HEATING SYSTEM WAS ACTIVATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE FAILURE WAS LOCATED AT THE BACK REST HEATING SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THAT THE VEHIC…

    Read full complaint

    TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE DRIVER SEAT HEATING SYSTEM FAILED. THE CONTACT SMELLED SMOKE WHILE THE HEATING SYSTEM WAS ACTIVATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE FAILURE WAS LOCATED AT THE BACK REST HEATING SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V575000 (SEATS: FRONT ASSEMBLY: SEAT HEATER/COOLER). THE APPROXIMATE FAILURE MILEAGE WAS 157,000 AND THE CURRENT MILEAGE WAS 158,000.

    NHTSA ODI #10486225

    100,850 miles · Apr 21, 2010
    Seats

    TL* THE CONTACT OWNS A 2005 BMW 525I. WHILE IN THE IDLE POSITION, THE CONTACT NOTICED THAT THE ELECTRIC SEAT WAS NOT FUNCTIONING PROPERLY. HE CALLED THE DEALER AND WAS ADVISED THAT HE WOULD BE RESPONSIBLE FOR REPAIR EXPENSES. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE VIN WAS UNAVAILABLE AT THE TIME OF T…

    Read full complaint

    TL* THE CONTACT OWNS A 2005 BMW 525I. WHILE IN THE IDLE POSITION, THE CONTACT NOTICED THAT THE ELECTRIC SEAT WAS NOT FUNCTIONING PROPERLY. HE CALLED THE DEALER AND WAS ADVISED THAT HE WOULD BE RESPONSIBLE FOR REPAIR EXPENSES. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE VIN WAS UNAVAILABLE AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 101,000. THE FAILURE MILEAGE WAS APPROXIMATELY 100,850.

    NHTSA ODI #10326783

    Mileage unknown · Jan 23, 2007
    SeatsFireInjury

    I GOT A SECOND DEGREE BURN FROM MY CAR SEAT HEAT MALFUNCTION FROM MY 2005 BMW 525I. THE CAR SEAT WENT ON FIRE AND BURNED MY CLOTH AND MY SKIN. *JB

    NHTSA ODI #10179500

    Recall campaigns

    0

    No recalls in this snapshot.

    Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

    Defect investigations

    2

    EA08001 · BMW Airbag Light Illumination

    Opened Jan 4, 2008 · Closed Dec 31, 2008

    Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

    BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

    Additional source detail variants (3)

    Air Bags

    BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

    Air Bags:frontal

    BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

    Air Bags:frontal:sensor/control MODULE-INACTIVE

    BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

    PE07045 · BMW Airbag Light Illumination

    Opened Sep 4, 2007 · Closed Jan 4, 2008

    Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

    IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

    Additional source detail variants (3)

    Air Bags

    IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

    Air Bags:frontal

    IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

    Air Bags:frontal:sensor/control MODULE-INACTIVE

    IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).

    An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.