2006 BMW 525I

The contact owns a 2006 BMW 525I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated while driving approximately 30 MPH, she noticed the odor of burning plastic. The contact stated that the check radiator light was illuminated. The contact stated that she drove the vehicle to a dealer. The dealer diagnosed that the failure was with the PCV valve and replaced the PCV valve. The vehicle was repaired; however, the contact was billed by the dealer for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 235,641. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

I received a notice in the mail stating that my vehicle with the matching Vin had a recall for the pc value heater. And that it causes the vehicle to over heat and catch fire I contacted the dealership and manufacturer and I was told that there was no remedy available as I started experiencing issue's with my vehicle. It worries me because I constantly have my grandchildren with me and don't want them in a unsafe vehicle.

The contact owns a 2006 BMW 525i. The contact stated while driving 60-65 MPH, the vehicle started to overheat. The coolant temperature warning light was illuminated. The contact veered to the side of the road and added coolant in the vehicle. The contact then continued to drive. The contact stated that the failure reoccurred while driving. The contact stated that he replaced the thermostat himself. However, the failure persisted and the vehicle failed to start. The vehicle was towed to the residence. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 135,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 525I. The contact stated that there was a strong fuel odor coming from the vehicle. The vehicle was taken to an independent mechanic and the dealer where it was both diagnosed that the vehicle was leaking fuel. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 188,318.

TL* THE CONTACT OWNS A 2006 BMW 525I. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER PASSPORT BMW (4730 AUTH PL, SUITLAND-SILVER HILL, MD 20746, (301) 423-2700) WHERE IT WAS DIAGNOSED WITH NEEDING A BOLT TIGHTENED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 17V428000 (AIR BAGS). THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000.

I WAS ON MY WAY TO WORK AND HAD DRIVEN ONLY 4 1/2 MILES AT 6:55AM ON THURSDAY, AUGUST 15, 2019. I WAS ABOUT 1/2 FROM WORK ON A CITY STREET WHEN SMOKE BEGAN COMING OUT THE AIR VENTS AND STEERING COLUMN. A SMELL OF PLASTIC, ELECTRICAL FILLED THE CAR AND I PULLED INTO THE NEAREST PLACE WHEN THE SMOKE WAS QUICKLY INCREASING. MY SON AND I JUMPED OUT OF THE CAR AND CALLED 911. THE FIRE DEPARTMENT ARRIVED ALMOST IMMEDIATELY, AND UPON PULLING UP, BEFORE THEY COULD GET OUT OF THE TRUCK, THE DRIVER'S SIDE CURTAIN AIRBAG EXPLODED, THE FIREMEN HEARD THE EXPLOSION. BY THE TIME THEY PULLED THEIR HOSES AND LIFTED THE HOOD, SMOKE WAS HEAVILY COMING FROM THE CAR. WHEN THE AIRBAG EXPLODED, A LARGE PIECE OF PLASTIC SHRAPNEL WAS BLOWN TO THE PASSENGER SIDE OF THE CAR AND STUCK BETWEEN THE WINDSHIELD AND THE WINDOW AND STUCK INTO THE EDGE WINDSHIELD FRAME. THE FIREFIGHTERS TRIED FOR SEVERAL MINUTES TO GET THE SOURCE UNDER CONTROL AND FINALLY WAS ABLE TO WHEN THEY DISCONNECTED THE BATTERY. I HAD MY CAR TOWED TO BMW COLUMBUS, THEY "REPAIRED THE RECALL" AND SAID THAT THE FIRE WAS NOT A RESULT OF THE RECALL. I BELIEVE THAT IF THE FIREFIGHTERS DID NOT RESPOND AS QUICKLY AS THEY DID BECAUSE THEY WERE NEARBY, THEN MY CAR WOULD HAVE GONE UP IN FLAMES.