NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
35 reportsMileage unknown · Oct 23, 2024
Electrical SystemEngineService Brakes
I am encountering persistent issues with my 2005 BMW 525i. Despite having replaced several critical components, including the ignition coils, spark plugs, mass air flow sensor, and throttle body sensors, the vehicle continues to experience performance problems, specifically failing to advance beyond the fourth cylinder when driv…
Read full complaint
I am encountering persistent issues with my 2005 BMW 525i. Despite having replaced several critical components, including the ignition coils, spark plugs, mass air flow sensor, and throttle body sensors, the vehicle continues to experience performance problems, specifically failing to advance beyond the fourth cylinder when driving uphill. After conducting numerous diagnostic tests, I have concluded that there may be an air leak in the intake manifold. Additionally, after prolonged use under these conditions, the positive battery cable from the trunk has shown signs of overheating, evidenced by smoke, which I suspect is related to repeated uphill driving. While the vehicle performs adequately on flat surfaces, it exhibits hesitation and jerking once it surpasses the fourth cylinder.
NHTSA ODI #11621558
Mileage unknown · May 15, 2024
Exterior Lighting
The tail-lights have gone out creating safty issue and number of warning lights to come up on the dashboard. Dealership stated that the wiring harness around ground wire has melted. They stated that this is same issue that is mentioned under NHTSA Campaign Number: 13V407000. The service advisor said that his issue would be fix…
Read full complaint
The tail-lights have gone out creating safty issue and number of warning lights to come up on the dashboard. Dealership stated that the wiring harness around ground wire has melted. They stated that this is same issue that is mentioned under NHTSA Campaign Number: 13V407000. The service advisor said that his issue would be fixed by same service bulletin SIB 630613, however my date range is not included in the recall. I would like to report an issue to open a case and extend the recall to include all E60 models from 2004 to 2010. Would you please open an investigation into this matter and contact me for additional information and photos.
NHTSA ODI #11588889
112,000 miles · Feb 6, 2019
Power Train
I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COL…
Read full complaint
I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COLD TEMPERATURES HERE IN WISCONSIN. A COUPLE OF DAYS LATER WHILE JUST FINISHING GOING UP A SLIGHT STRAIGHT INCLINE AT AROUND 45MPH THE TRANSMISSION DROPPED DOWN INTO LIMP DOWN MODE AND A TEMPORARY NOTICE CAME UP ON THE COMPUTER SCREEN INDICATING A TRANSMISSION PROBLEM. STOPPING AND RESTARTING THE ENGINE CLEARED THE PROBLEM, THE NEXT DAY NEAR THE SAME SPOT IT OCCURRED AGAIN. I ASSUMED THE TRANSMISSION MIGHT BE LOW ON FLUID BUT LOOKING ONLINE BMW INDICATED THIS IS A NO SERVICE TRANSMISSION BUT THAT IT IS POSSIBLE TO CHECK THE FLUID LEVEL BY ACCESSING A PLUG UNDER THE CAR. WHEN A SERVICE TECH CHECKED HE SAID THE FLUID LEVEL WAS NORMAL BUT SMELLED BURNT. HE RECOMMENDED AGAINST ANY SERVICE IN THAT IT LIKELY WOULD RESULT IN FASTER COMPLETE FAILURE. THE PROBLEM HAS NOT REOCCURRED AND NO CODES SHOW IN THE SYSTEM FILE, IN THAT BMW INSISTED ON NO PROVIDING A METHOD TO CHECK THE TRANSMISSION FLUID, THEY ASSUMED THE LIABILITY FOR FAILURE IF REGULAR MAINTAINANCE (TRANSMISSION FLUSH) COULD HAVE PREVENTED THIS FAILURE.
NHTSA ODI #11174764
Mileage unknown · Nov 15, 2018
Fuel/propulsion System
MY CAR HAS A GAS SMELL EVEN IN THE INSIDE SMELLS LIKE GAS
NHTSA ODI #11151790
82,000 miles · Jan 9, 2018
Air BagsSeats
AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENG…
Read full complaint
AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENGER SEAT, THE ERROR CODE CAME BACK WITH THE SAME FAULT CODE.
NHTSA ODI #11061337
140,000 miles · Apr 3, 2017
Air BagsElectrical System
FRONT PASSENGER SEAT OCCUPANCY SENSOR HAS FAILED. REAR LEFT HAND BRAKE/BACKUP LIGHT IS PROBLEMATIC AND INTERMITTENTLY WORKS, USUALLY ONLY SHOWS UP ON CAR'S DASHBOARD WHILE IN REVERSE, BUT SOMETIMES WILL STAY ON-SCREEN DURING DRIVING. FRONT ASHTRAY OUTLET/CIGARETTE LIGHTER DOESN'T WORK.
NHTSA ODI #10970386
Mileage unknown · Mar 23, 2017
Air BagsSeat Belts
PASSENGER RESTRAINT SYSTEM FAULT.
NHTSA ODI #10968236
114,000 miles · Jan 27, 2017
Electrical SystemUnknown Or OtherFire
SUNROOF DRAIN CLOGGED INTO TRUNK CAUSING FIRE IN BATTERY COMPARTMENT AND SPARE TIRE AREA. VEHICLE WAS STATIONARY IN SHOP AFTER NOT BEING RUN FOR HOURS.
NHTSA ODI #10948007
130,000 miles · Oct 21, 2016
Air BagsPower Train
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE VEHICLE DECELERATED INDEPENDENTLY WHILE BEING OPERATED AT LOW SPEEDS. THE AIR BAG WARNING INDICATOR AND SERVICE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE VEHICLE DECELERATED INDEPENDENTLY WHILE BEING OPERATED AT LOW SPEEDS. THE AIR BAG WARNING INDICATOR AND SERVICE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. UPDATED 02/16/17*LJ
NHTSA ODI #10917934
115,712 miles · Feb 22, 2016
Air Bags
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FAULT IN PASSENGER RESTRAINT SYSTEM DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE AIR BAG SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FAULT IN PASSENGER RESTRAINT SYSTEM DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE AIR BAG SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V384000 (AIR BAGS). THE FAILURE MILEAGE WAS 115,712. UPDATED 04/22/16*LJ *JS
NHTSA ODI #10837430
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration