2006 Volvo XC70

The contact owns a 2006 Volvo XC70. The contact stated while attempting to start the vehicle, the front suspension springs fractured. The contact heard a loud clicking sound. There were no warning lights illuminated. The vehicle was taken to the local dealer who confirmed the fracture of the suspension springs. The passenger’s side suspension springs were replaced. The manufacturer was notified of the failure. The approximate failure mileage was 95,000.

When rear seats are folded to make more room for cargo, the seat belts retract more inwards due to the retractable hardware that retracts the belts. The button clips that are clamped into the belt that stops them from happening break apart easily due to the retracting force of the belt and when trying to fold back the seats the belts get locked and are unable to fold back to the original position, the only way to fix this is to unbolt the belts and fold back the seats and bolt back the seat belts. When this is done, passengers are not able to buckle in the rear seats due to the belt retractable hardware being locked. Is a safety issue because the passenger can not buckle and, when the belt works and are able to buckle, sometimes when braking hard the belt retrieves a little to keep the passenger in place and when this happens the belts lock back again having the passenger being tightened by the belt and unable to move freely and having difficulty trying to unbuckle in case of an emergency.

Takata Recall. The contact owns a 2006 Volvo XC70. The contact received notification of NHTSA Campaign Number: 21V800000 (Air Bags) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Volvo XC70. The contact received notification of NHTSA Campaign Number: 21V800000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and informed the contact that parts were arriving sporadically. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

ORIGINAL KEYFOB ERASED ITSELF AFTER BATTERY WAS DISCONNECTED FOR TWO WEEKS WHILE REPLACING A FAILED ENGINE. I WORKED WITH VISTEON AUTOMOTIVE SYSTEMS AS AN ELECTRICAL ENGINEER, MANUFACTURING THEIR REMOTE KEYLESS ENTRY SYSTEMS. I KNOW VERY WELL THAT THE KEYFOB SHOULD BE PROGRAMMED IN NON-VOLATILE MEMORY CHIPS. VOLVO DOES NOT SEEM TO BE DOING THAT. THIS COULD BE A PUBLIC HAZARD ISSUE WHEN HAVING TO JUMP-START SUCH A VEHICLE TO GET AWAY FROM A NATURAL DISASTER. THE CAR MAY NOT START UNTIL YOU TOW IT TO VOLVO TO RE-PROGRAM IT. IN MY CASE, COURTESY VOLVO OF SCOTTSDALE, ARIZONA SENT ME A BILL FOR 10 HOURS OF LABOR FOR KEYFOB RE-PROGRAMMING. ATA RATE OF $68/HOUR. VISTEON'S PROGRAMMING PROCEDURE TAKES MINUTES. VOLVO'S TAKES MANY HOURS. THIS IS ANOTHER HAZARD ISSUE IN ITSELF.

MILEAGE ON THIS VEHICLE WAS 115K WHEN THIS HAPPENED: MY WIFE STARTED TO BACK THE CAR STRAIGHT OUT OF OUR DRIVEWAY (FROM A STOPPED POSITION, IN REVERSE GEAR) WHEN SHE HEARD A LOUD BANG WHICH CAME FROM THE DRIVERS SIDE FRONT OF THE VEHICLE. SHE STOPPED THE VEHICLE AND PLACED IT IN PARK. AFTER REMOVING THE LEFT FRONT WHEEL, I DISCOVERED THAT THE SUSPENSION COIL (OR SPRING) AS PART OF THE MACPHERSON STRUT ASSEMBLY, HAD SNAPPED IN TWO AT THE LOWER END. THE BROKEN OFF PART OF THE SPRING WAS SITTING ON THE LOWER CONTROL ARM, WHILE THE OTHER PART WAS STILL SURROUNDING THE STRUT. THAT PART OF THE SPRING WAS RESPONSIBLE FOR SLASHING THE TIRE WHEN IT FAILED. WE WERE THANKFUL THAT THIS HAPPENED ON OUR DRIVEWAY AND NOT GOING DOWN THE HIGHWAY AT A HIGH RATE OF SPEED. BUT WE WERE ALSO ASTOUNDED THAT SUCH A CATASTROPHIC FAILURE OF A SUSPENSION PART LIKE THIS WOULD OCCUR IN THE FIRST PLACE. THERE WERE NO RECALLS THAT WE WERE AWARE OF AND NOTHING IN THE SERVICE SCHEDULE ABOUT REPLACING THESE SPRINGS AT THE GIVEN MILEAGE.

TRANSMISSION ISSUES, FIRST NOTED IN REPORTS FROM VOLVO DEALERSHIP FROM ORIGINAL OWNER AT 107K MILES. HARD SHIFTING, REVVING INTO THE NEXT GEAR. NEEDS A NEW TRANSMISSION ACCORDING TO THE SHOP I TOOK THE VEHICLE TO LOOK AT IT 2 DAYS AFTER BUYING THE CAR. I HAVE ALL THE DOCUMENTS FROM THE ORIGINAL OWNER WHICH I FOUND IN THE GLOVE BOX, IN WHICH HE SPENT OVER $15K IN REPAIRS FOR THIS CAR OVER THE 8 YEARS HE OWNED IT SINCE NEW. *TR

TRAVELING NORTH ON 495 IN MASSACHUSETTS ON MY WAY HOME FROM WORK AT APPROXIMATELY 70 MPH IN HEAVY TRAFFIC, MY CAR STARTED LOSING SPEED. I PUSHED HARDER ON THE GAS PEDAL, BUT IT KEPT SLOWING DOWN. I IMMEDIATELY TURNED MY BLINKER ON AND PULLED TO THE SLOW LANE, THINKING I MAY BE ABLE TO GET OFF THE HIGHWAY AT THE NEXT EXIT. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD ALMOST INTO THE BREAKDOWN LANE. MY CAR STALLED. I WAS AT THE TURN OFF FOR THE EXIT - IN HEAVY TRAFFIC. I CALLED AAA FOR ASSISTANCE. A STATE POLICE OFFICER STOPPED AND SET UP FLARES TO HELP AVOID A COLLISION. FIRST LOOK FROM MY MECHANIC INDICATES A FUEL PUMP MODULE PROBLEM. THERE HAS BEEN A RECALL IN OTHER 2006 VOLVO MODELS FOR THIS ISSUE BUT NOT FOR THE XC 70. I LIVE IN NH SO THE CAR IS EXPOSED TO SALT/WATER. THERE WAS FLOODING ON THE WAY IN TO WORK THAT MORNING. THIS IS A VERY CONCERNING SAFETY ISSUE, AS MY CAR LITERALLY QUIT IN HEAVY TRAFFIC ON 495. *TR