2008 Volvo XC70

I have noticed water leaking into the inside of my windshield and also noticed that the front and rear carpets are damp and the car is developing a musty smell. Upon closer inspection it appears that the top of the windshield is unbonded from the frame and moves outward when pressure is applied against it. This is a serious safety concern as the windshield is a structural component of the vehicle and the integrity of the vehicle with an unbonded windshield compromises the vehicle safety. Beyond that structural concern, the inside windshield fogs us consistently causing impaired visibility while driving, especially in the rain.

The contact owns a 2008 Volvo XC70. The contact stated that while her husband was leaving a restaurant drive-thru, the vehicle lost motive power without warning while entering the main street. The driver was waiting for a tow truck to tow the vehicle from the scene. The dealer was made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 09V218000 (Engine and Engine Cooling). The failure mileage was approximately 120,000. The VIN was unavailable.

1. Low beam headlights failed - both at the same time, resulting in high beam only driving at night. Units available for inspection. 2. Yes. No low beam headlights. Upon inspection of wiring, during replacement of low beams, headlight wiring insulation found to be flaking off, exposing bare wiring. 3. Unknown. Found no information in Google search. Plenty of information on others having same issue, in Volvo forums online. Last search regarding this problem brought me to NHTSA website, to look on a recall about this issue, then to this form submission. 4. No. This is the first time I've been exposed to the problem. This is the first case personally, where a vehicle has suffered a loss of both low beam headlights simultaneously. The wiring issue was found when I pulled out the old bulbs for replacement. 5. No. My wife informed me that the low beams stopped working on her car. There was an indicator on the instrument panel indicating "low beam failure." Strangely, I found both low beams to be burned out.

THE PROBLEMS INCLUDE DOOR LATCHES QUIT WORKING AND UNABLE TO SECURE DOORS WHEN VEHICLE WAS STATIONARY, DOORS COULD LATCH BUT UPON STARTING THE VEHICLE THE LOCKS WOULD NOT ENGAGE AND UNABLE TO DRIVE OR LEAVE THE VEHICLE IF THE DOORS ARE UNABLE TO ENGAGE. THE PASSENGER AND DRIVER SIDE MIRRORS FALLING/FLYING OFF THE MOUNT WHILE IN MOTION AND THEN SHATTERING ON THE ROAD WAY. WHEN VEHICLE IS STATIONARY THE REAR DOOR NOT CATCHING WHEN FULLY OPEN AND AUTOMATICALLY CLOSES IN RAPID MOTION. THE AM RADIO TRANSMISSION/RECEPTION MOTOR STOPPING,

HAVE HAD MULTIPLE OVERHEATING INCIDENTS WHILE DRIVING, WHICH COINCIDED WITH THE AIR CONDITIONER STOPPING WORKING. I THINK LEARNED OF VOLVO RECALL #09V218000 WHICH DESCRIBES EXACTLY THE FAILURE I'VE BEEN EXPERIENCING. I CONTACTED VOLVO CUSTOMER SERVICE, BUT THEY CLAIM THAT MY VIN DOES NOT FALL UNDER THE VEHICLES RECALLED. THE REFERENCED ABOVE WAS FOR 17,614 2008-2009 XC70, S80, AND V70 VEHICLES. EVIDENTLY WAS RELATED TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE, AND THE DEFECT CORRECTIVE ACTION WAS SUPPOSED TO BE REPLACING THE FCM. VOLVO TOLD ME THAT THEY WILL NOT ASSIST WITH THIS EFFORT, EVEN THOUGH IT'S A MAJOR SAFETY ISSUE EFFECTED BY THE RECALL, BUT APPARENTLY NOT MY SPECIFIC VIN. ANY ASSISTANCE IN GETTING ADDITIONAL VINS ADDED TO THIS RECALL WOULD BE GREATLY APPRECIATED.

TL* THE CONTACT OWNS A 2008 VOLVO CROSS COUNTRY WAGON. WHILE DRIVING 70 MPH, THE SUN ROOF EXPLODED. THE GLASS PARTICLES PROJECTED UPWARD BECAUSE THE HEADLINER WAS CLOSED AND STRUCK THE WINDSHIELD OF THE VEHICLE TRAVELING BEHIND THE CONTACT. THERE WERE NO INJURIES. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED A FOOTBALL-SIZED HOLE IN THE MIDDLE OF THE SUN ROOF AND TOOK PICTURES. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED HIS INSURANCE COMPANY AND WAS INFORMED THAT THEY WOULD COVER THE DAMAGES. THE FAILURE MILEAGE WAS 162,000. THE VIN WAS UNKNOWN. *TT*JB

PRIOR TO A 165 MILE ROAD TRIP THE FUEL GAUGE READ 1/4 TANK - 120 MILES TO EMPTY. I FILLED THE TANK TO FULL BEFORE HEADING OUT. AFTER REFUELING, I CLOSED THE GAS CAP BUT FORGOT TO SHUT THE FUEL DOOR. THE FUEL DOOR OPEN ERROR LIGHT CAME ON AND THE FUEL GAUGE STILL READ 1/4 TANK - 120 MILES TO EMPTY. I PULLED TO THE SIDE OF ROAD AND WITH THE VEHICLE RUNNING SHUT THE FUEL DOOR. THE FUEL DOOR OPEN ERROR LIGHT WAS STILL LIT AND THE FUEL GAUGE DID NOT CHANGE. I DROVE TOWARDS HOME ON WINDING MOUNTAIN ROADS IN HIGH SPEED L.A. TRAFFIC. THE INDICATOR READ 50 MILES TO EMPTY AND THE LOW FUEL INDICATOR CAME ON EVEN THOUGH THERE WAS STILL 3/4 OF A TANK OF GAS. AT THE APPROXIMATELY 120 MILE MARK WHILE DRIVING 65 MPH IN 5 LANES OF FAST-MOVING L.A. TRAFFIC THE VEHICLE STOPPED. I WAS ABLE TO SAFELY PULL OVER THROUGH 3 LANES OF TRAFFIC AND STOP SAFELY ON THE FREEWAY SHOULDER. THE VEHICLE FUEL GAUGE INDICATED THE TANK WAS EMPTY AND THE FUEL DOOR OPEN INDICATOR REMAINED ON EVEN THOUGH I HAD CLOSED THE DOOR. THE VEHICLE WOULD NOT RESTART AND I HAD IT TOWED TO THE MECHANIC WHO ROUTINELY SERVICES IT. I AM WAITING TO HEAR THE RESULT OF THE DIAGNOSTIC TESTS. I COULD HAVE BEEN KILLED IF THE VEHICLE HAD STOPPED ON THE WINDING MOUNTAIN ROADS WITH NO SHOULDERS AND NO WAY FOR ME TO SAFELY EXIT THE FREEWAY. AT NO TIME DID ANY OTHER VEHICLE WARNINGS DISPLAY OTHER THAN FUEL DOOR OPEN. I PURCHASED A VOLVO FOR ITS IMPECCABLE SAFETY RECORD. THIS INCIDENT CERTAINLY DOES NOT LIVE UP TO THE STELLAR VOLVO REPUTATION. I HAD NO IDEA THAT DRIVING WITH THE FUEL DOOR OPEN ERROR DISPLAYED COULD RESULT IN THE VEHICLE STOPPING ON THE HIGHWAY EVEN THOUGH THE GAS TANK REALLY WAS 3/4 FULL AND NOT EMPTY AS THE FUEL GAUGE INDICATED. THIS SHOULD DEFINITELY BE RECALLED AND OTHER DRIVERS MADE AWARE OF THE SAFETY ISSUE ASSOCIATED WITH WHAT APPEARS TO BE A MINOR NUISANCE BUT IS A MAJOR SAFETY CONCERN ULTIMATELY.