NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
331 reports135,500 miles · Mar 14, 2006
SuspensionCrash
HAD A CREAKING SOUND IN THE FRONT END OF MY 1998 VW PASSAT 1.8T. TOOK IT IN TO THE DEALER AND WAS TOLD THE LEFT FRONT UPPER CONTROL ARM TIE RODS WERE BAD (AND DANGEROUS) AND HAD TO BE REPLACED AT MY COST. DID THIS AND 6 WEEKS LATER THE UPPER CONTROL ARM ON THE RIGHT FRONT SIDE FAILED WHILE DRIVING AND CAUSED ME TO HAVE AN ACCI…
Read full complaint
HAD A CREAKING SOUND IN THE FRONT END OF MY 1998 VW PASSAT 1.8T. TOOK IT IN TO THE DEALER AND WAS TOLD THE LEFT FRONT UPPER CONTROL ARM TIE RODS WERE BAD (AND DANGEROUS) AND HAD TO BE REPLACED AT MY COST. DID THIS AND 6 WEEKS LATER THE UPPER CONTROL ARM ON THE RIGHT FRONT SIDE FAILED WHILE DRIVING AND CAUSED ME TO HAVE AN ACCIDENT. DEALER "FIXED" THIS PROBLEM AT NO CHARGE AND NOW 4 MONTHS LATER THE SAME SOUND IS BACK AND NOW THE DEALER TELLS ME THAT THE MAJORITY OF THE FRONT SUSPENSION MUST BE REPLACED AND EXPECTS ME TO PAY FOR IT. *JB
NHTSA ODI #10152692
100,175 miles · Feb 15, 2006
Service Brakes, Hydraulic
ABS FAILED, FLASHING LIGHTS CONTINUALLY. SPOKE WITH DEALER IN SEASIDE, CA SAID COMMON EVENT AND NOT WORTH REPLACING. *JB
NHTSA ODI #10150305
Mileage unknown · Jan 25, 2006
Engine And Engine Cooling
1998 PASSAT TIMING BELT PREMATURELY FAILED CAUSING VEHICLE TO DIE. *TS ***NO ANS REQUIRED*** *JB
NHTSA ODI #10149748
99,500 miles · Jan 23, 2006
Service Brakes, Hydraulic
I HAVE A 1998 VW PASSAT THAT HAS HAD IT ABS SYSTEM GO OUT. FROM WHAT I UNDERSTAND THIS IS A COMMON OCCURRENCE WITH THIS CAR. THE ONLY PROBLEM IS WHEN THE ABS MODULE GOES ON THE CAR IT HAS A HARD TIME MODULATING THE BRAKES CORRECTLY CAUSING A DANGEROUS SITUATION. I WILL HAVE TO EITHER BUY A NEW UNIT OR SEND IT OUT AND HAVE IT RE…
Read full complaint
I HAVE A 1998 VW PASSAT THAT HAS HAD IT ABS SYSTEM GO OUT. FROM WHAT I UNDERSTAND THIS IS A COMMON OCCURRENCE WITH THIS CAR. THE ONLY PROBLEM IS WHEN THE ABS MODULE GOES ON THE CAR IT HAS A HARD TIME MODULATING THE BRAKES CORRECTLY CAUSING A DANGEROUS SITUATION. I WILL HAVE TO EITHER BUY A NEW UNIT OR SEND IT OUT AND HAVE IT REPAIRED. *JB
NHTSA ODI #10148421
103,000 miles · Jan 3, 2006
EquipmentExterior LightingLatches/locks/linkages
1998 VW PASSAT WAGON 2 WHEEL DRIVE 4 CYL. 1.8 L ENGINE. MANUAL TRANSMISSION VIN: [XXX] THINGS BROKEN ON THIS VW. BLINKING ABS LIGHT ON DASH INDICATING ABS MALFUNCTION. IT INTERMITTENTLY GOES OFF ONCE OR TWICE A YEAR FOR A COUPLE OF MINUTES, INDICATING FUNCTION PROPERLY. TEMP. GAUGE ON DASH READS NO TEMPERATURE OR 0. IT INTER…
Read full complaint
1998 VW PASSAT WAGON 2 WHEEL DRIVE 4 CYL. 1.8 L ENGINE. MANUAL TRANSMISSION VIN: [XXX] THINGS BROKEN ON THIS VW. BLINKING ABS LIGHT ON DASH INDICATING ABS MALFUNCTION. IT INTERMITTENTLY GOES OFF ONCE OR TWICE A YEAR FOR A COUPLE OF MINUTES, INDICATING FUNCTION PROPERLY. TEMP. GAUGE ON DASH READS NO TEMPERATURE OR 0. IT INTERMITTENTLY COMES BACK ON AND FUNCTIONS PROPERLY. I NEED TO PULL SENDING UNIT WIRE AND CLEAN CONNECTOR. DRIVER'S AUTO DOOR LOCK BUTTON MALFUNCTIONS. WINDOW SWITCHES ON DRIVERS DOOR DOESN'T WORK WELL. STEREO PLAYS CD WITHOUT PUSHING THE BUTTON. (GOES ON BUY ITS SELF) LEFT REAR PASSENGER DOOR DOES NOT OPEN FROM INSIDE.. MOON ROOF MALFUNCTIONS. MAYBE WON'T CLOSE AFTER OPENING. BRAKE LIGHT'S DON'T LIGHT UP RIGHT AWAY WHEN YOU STEP ON THE BRAKES. OUTSIDE DOOR LOCKS STICK. WHEN IT RAINS, WATER GETS INTO THE LOCK AND MAKES IT DIFFICULT TO TURN THE KEY INSIDE THE LOCK. PLASTIC DIP STICK GUIDE IS PRONE TO CRUMBLING DUE TO HEAT. (THIS IS THE ORANGE PIECE OF PLASTIC THAT EXTENDS THE LENGTH OF THE DIPSTICK TUBE. ANTENNA GOT SCREWED UP IN RAIN AND WIND. DEC. -05. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10146738
92,000 miles · Jan 1, 2006
Engine And Engine CoolingFire
WHILE CRUISING AT HIGHWAY SPEED IN MY 1998 VOLKSWAGEN PASSAT, 3 EVENTS OCCURRED SIMULTANEOUSLY: A 'POP' SOUND FROM THE ENGINE AREA, COPIOUS WHITE SMOKE (NOT STEAM) FROM UNDER THE HOOD, AND THE ENGINE CHECK LIGHT ACTIVATION. IMMEDIATELY PULLED OVER, AND WHITE SMOKE INCREASED SUBSTANTIALLY FROM (CLOSED) HOOD, FOLLOWED WITHIN 5 MI…
Read full complaint
WHILE CRUISING AT HIGHWAY SPEED IN MY 1998 VOLKSWAGEN PASSAT, 3 EVENTS OCCURRED SIMULTANEOUSLY: A 'POP' SOUND FROM THE ENGINE AREA, COPIOUS WHITE SMOKE (NOT STEAM) FROM UNDER THE HOOD, AND THE ENGINE CHECK LIGHT ACTIVATION. IMMEDIATELY PULLED OVER, AND WHITE SMOKE INCREASED SUBSTANTIALLY FROM (CLOSED) HOOD, FOLLOWED WITHIN 5 MINUTES BY OPEN FLAMES FROM THE PASSENGER FRONT WHEEL WELL. FIRE CREWS WERE ON SCENE WITHIN 10 MINUTES, BUT THE ENTIRE VEHICLE WAS ENGULFED AND A TOTAL LOSS. *NM
NHTSA ODI #10146655
106,000 miles · Dec 14, 2005
Service Brakes, Hydraulic
98 PASSAT, ABS PUMP IS NOT WORKING ANYMORE AT 106000 MILES. I WANTED TO REPLACE THE PART BUT THE DEALER TOLD ME I HAVE TO PAY $1200.00 JUST FOR THE PART. IS VW USA CONSIDERING A RECALL BECAUSE IN MY OPINION A $1200.00 PART SHOULD NOT FAIL TO WORK SO FAST. *JB
NHTSA ODI #10145152
92,000 miles · Dec 2, 2005
Service Brakes, Hydraulic
ABS UNIT FAILURE ON MY 1998 1.8 TURBO PASSAT GLS SEDAN AT 92,000 MILES. SENDING UNIT TO BE REFURBISHED BECAUSE VW OF AMERICA WON'T REPLACE IT UNDER A RECALL. *JB
NHTSA ODI #10144208
51,000 miles · Oct 21, 2005
Service Brakes, Hydraulic
ABS ELECTRONIC CONTROL MODULE FAILURE. *JB
NHTSA ODI #10140452
92,621 miles · Oct 10, 2005
Visibility
I HAD THE SUNROOF OF MY 1998 PASSAT SPONTANEOUSLY SHATTER. I WAS DRIVING 60-65 MPH WHEN THIS HAPPEN. THE WEATHER WAS OVERCAST WITH LIGHT RAIN. THE TEMPERATURE WAS 37 F. THE GLASS APPEARS TO BE BLOWN OUTWARD. LUCKILY I HAD THE SUNROOF SHADE CLOSED WHICH PREVENTED ME FROM BEING SHOWERED WITH GLASS. *NM
NHTSA ODI #10139231
NHTSA investigations
6EA04017 · STUCK-OPEN Throttle
Opened Jun 30, 2004 · Closed Feb 10, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
RQ99008 · Power Brake Booster Vacuum BY-PASS
Opened Jun 1, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration