NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
507 reportsMileage unknown · Dec 16, 2025
Air BagsInjury
Side airbag deployed for no reason while driving straight at the speed limit of 75 mph. The local VW dealer determined the side impact sensor is defective. This is a very interesting situation because a fail safe exists in these systems in that the supplemental restraint control module in the center of the car must simultaneousl…
Read full complaint
Side airbag deployed for no reason while driving straight at the speed limit of 75 mph. The local VW dealer determined the side impact sensor is defective. This is a very interesting situation because a fail safe exists in these systems in that the supplemental restraint control module in the center of the car must simultaneously "see" a side impact g force in order to deploy the side air bag. In other words even with a defective side impact sensor The side air bag should not have deployed. At the time of the incident the vehicle was travelling straight ahead next to a semi truck. No such impact occurred and the VW dealer confirmed the vehicle has no evidence of such an impact. I had this investigated by Volkswagen AG and my local dealer. Suffered broken teeth, bruised ribs, hearing loss in left ear.
NHTSA ODI #11705331
45,000 miles · Dec 21, 2020
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE AFTER BEING PARKED OVERNIGHT, HE NOTICED A FUEL ODOR. THE CONTACT STATED THAT THE FUEL TANK WAS HALF EMPTY AFTER BEING REFILLED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AND WAS INFORMED THAT THE SEAM IN THE F…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE AFTER BEING PARKED OVERNIGHT, HE NOTICED A FUEL ODOR. THE CONTACT STATED THAT THE FUEL TANK WAS HALF EMPTY AFTER BEING REFILLED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AND WAS INFORMED THAT THE SEAM IN THE FUEL TANK WAS FRACTURED WHICH CAUSED THE FUEL LEAK. THE FUEL TANK WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
NHTSA ODI #11384369
Mileage unknown · Jul 10, 2019
EngineFuel/propulsion SystemFire
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, SMOKE BILLOWED FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY LEAVE THE ROADWAY, THE HOOD WAS RAISED AND FLAMES APPEARED IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, SMOKE BILLOWED FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY LEAVE THE ROADWAY, THE HOOD WAS RAISED AND FLAMES APPEARED IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS NOT TOWED AND REMAINED AT THE SCENE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FIRE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT CONTACTED. THE INSURANCE COMPANY WAS NOT MADE AWARE OF THE FIRE. THE CONTACT WAS UNSURE IF THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #11230809
185,000 miles · May 15, 2018
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD OVERHEAT AND CAUSE THE ENGINE TO FAIL. THE CONTACT STATED THAT THE FAILURE WAS RECURRING AND THE "EMISSIONS WORK" INDICATOR ILLUMINATED SOMETIMES DURING THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD OVERHEAT AND CAUSE THE ENGINE TO FAIL. THE CONTACT STATED THAT THE FAILURE WAS RECURRING AND THE "EMISSIONS WORK" INDICATOR ILLUMINATED SOMETIMES DURING THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COOLING SYSTEM FAILED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE CONTACT BELIEVED THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 185,000. THE VIN WAS NOT PROVIDED.
NHTSA ODI #11093885
16,301 miles · Feb 27, 2017
Electrical SystemUnknown Or Other
PROBLEMAS ELCTRICOS
NHTSA ODI #10957424
10 miles · Jan 6, 2017
Fuel/propulsion System
WHILE DRIVING ON THE HIGHWAY, WE STARTED SMELLING GASOLINE IN THE CABIN. WE PULLED OVER AND CHECKED UNDER THE HOOD. A FUEL LINE ATTACHED TO THE FIREWALL HAD A LEAK DIRECTLY ABOVE THE EXHAUST SYSTEM, AND WAS SPRAYING GASOLINE EVERYWHERE IN THE ENGINE BAY, INCLUDING THE CATALYTIC CONVERTER AND EXHAUST SYSTEM. WE WERE INFORMED B…
Read full complaint
WHILE DRIVING ON THE HIGHWAY, WE STARTED SMELLING GASOLINE IN THE CABIN. WE PULLED OVER AND CHECKED UNDER THE HOOD. A FUEL LINE ATTACHED TO THE FIREWALL HAD A LEAK DIRECTLY ABOVE THE EXHAUST SYSTEM, AND WAS SPRAYING GASOLINE EVERYWHERE IN THE ENGINE BAY, INCLUDING THE CATALYTIC CONVERTER AND EXHAUST SYSTEM. WE WERE INFORMED BY TOW TRUCK DRIVER THAT WE WERE INCREDIBLY LUCKY NO FIRE GOT STARTED IN THE ENGINE BAY WHILE WE WERE DRIVING DOWN THE HIGHWAY.
NHTSA ODI #10940191
49,000 miles · Aug 19, 2016
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED FUEL LEAKING UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPA…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED FUEL LEAKING UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 49,000. UPDATED 11/01/16*LJ
NHTSA ODI #10897203
149,000 miles · Sep 21, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE TRANSMISSION WAS FRACTURED AND THERE WAS FUEL LEAKING. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE APPROXIMATE FAILURE MILEAGE WAS 149,000.
NHTSA ODI #10766704
Mileage unknown · Jul 1, 2015
Electrical SystemEngineFuel/propulsion System
IN APPROXIMATELY JULY OF 2014 MY VOLKSWAGEN PASSAT STARTED EXPERIENCING ON AND OFF AGAIN PROBLEMS WITH THE ENGINE FIRING. I HAD RECENTLY RETIRED AND WAS NOT DRIVING THE CAR DAILY, AND SO I WAS UNABLE TO ASSOCIATE THE PROBLEM WITH ANY RECENT DRIVING EVENT. HOWEVER, ONE MORNING WHEN THE HESITATION WAS VERY PRONOUNCED I POPPED TH…
Read full complaint
IN APPROXIMATELY JULY OF 2014 MY VOLKSWAGEN PASSAT STARTED EXPERIENCING ON AND OFF AGAIN PROBLEMS WITH THE ENGINE FIRING. I HAD RECENTLY RETIRED AND WAS NOT DRIVING THE CAR DAILY, AND SO I WAS UNABLE TO ASSOCIATE THE PROBLEM WITH ANY RECENT DRIVING EVENT. HOWEVER, ONE MORNING WHEN THE HESITATION WAS VERY PRONOUNCED I POPPED THE HOOD TO HAVE A LOOK. WATER WAS STANDING ALMOST LEVEL WITH THE TOP OF THE BATTERY IN THE AREA HOUSING THAT PART. I USED MY INDOOR/OUTDOOR VACUUM TO PUMP OUT AS MUCH WATER AS POSSIBLE. WHEN I THOUGHT THE AREA WAS THOROUGHLY DRIED OUT I TOOK THE CAR TO MY LOCAL VOLKSWAGEN CERTIFIED MECHANIC FOR FURTHER INVESTIGATION. HE DIDN'T TAKE LONG TO DETERMINE THAT DRAINAGE HOLES ON BOTH SIDES UNDER THE HOOD WERE CLOGGED. HE WAS ABLE TO UNCLOG THE HOLE ON THE PASSENGER SIDE IMMEDIATELY, BUT THE HOLE ON THE DRIVER SIDE IS LOCATED BENEATH PARTS THAT HAVE TO BE MOVED FOR ACCESS. I RECALLED NUMEROUS TIMES OVER THE YEARS WHEN I WAS CERTAIN I WAS HEARING THE SOUND OF WATER SLOSHING AROUND UNDER THE HOOD. I HAD ASKED ON MORE THAN ONE OCCASION AT TIME OF SERVICE FOR THE SOUND TO BE INVESTIGATED FURTHER. I WAS ALWAYS TOLD THE SAME THING: THERE WAS NOTHING TO EXPLAIN THE SOUND I WAS HEARING. I NOW BELIEVE THIS HAS BEEN A RECURRING PROBLEM OVER THE YEARS I'VE OWNED THE CAR, AND MIGHT HAVE IMPACTED MORE THAN JUST THE BATTERY AT ANY TIME. I THOUGHT THERE SHOULD BE MORE THAN ONE REPORT OF THIS PROBLEM ON FILE.
NHTSA ODI #10731607
138,179 miles · Jun 10, 2015
Electrical SystemStructureUnknown Or Other
MY HUSBAND PICKUP WOULD NOT START, SO I LIFT MY HOOD OF MY PASSAT TO GIVE HIM A JUMP AND THE WHOLE SECTION ALL THE WAY ACROSS THAT HOLDS THE BATTERY HAVE AT LEAST 6 INCHES OF WATER JUST STANDING IN THERE. WE HAVE HAD SOME DOWN POURS OF RAIN,BUT RAIN WATER SHOULD NEVER BE STANDING ON THE INSIDE OF MY HOOD. THIS COULD HAVE POTE…
Read full complaint
MY HUSBAND PICKUP WOULD NOT START, SO I LIFT MY HOOD OF MY PASSAT TO GIVE HIM A JUMP AND THE WHOLE SECTION ALL THE WAY ACROSS THAT HOLDS THE BATTERY HAVE AT LEAST 6 INCHES OF WATER JUST STANDING IN THERE. WE HAVE HAD SOME DOWN POURS OF RAIN,BUT RAIN WATER SHOULD NEVER BE STANDING ON THE INSIDE OF MY HOOD. THIS COULD HAVE POTENTIALLY KILLED ME IF I NEVER HAD TO LIFT MY HOOD AND TRY TO DRIVE THIS WITH WATER STANDING AROUND ALL OF MY ELECTRICAL WIRES AND BATTERY. I HAVE TAKEN TWO PICTURES FOR VISIBILITY, BUT I DO NOT KNOW HOW I AM GOING TO GET THAT WATER OUT WITHOUT ELECTROCUTING MYSELF. SOMEBODY PLEASE HELP ME.
NHTSA ODI #10724634
NHTSA investigations
7EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration