IllustrationTHE ALTERNATOR CABLE MELTED THE FUSE BLOCK AND THE CAR ALMOST CAUGHT ON FIRE. *TR
2003 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2003 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
9225–50K
7650–75K
4875–100K
46100–150K
33150K+
374 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports70 fire reports76 injury reports
What owners actually said
455 reports2003 JETTA'S CLEARCOAT IS PEELING OFF, IT STARTED ON FRONT HOOD AND NOW IT IS PEELING ALL OVER THE CAR. CALLED VOLKSWAGEN THEY SAID IT WASN'T THEIR PROBLEM. I THINK IT IS!!! *TR
DRIVER SIDE AIR BAG DEPLOYMENT, NO APPARENT REASON. DRIVER SIDE CURTAIN AIR BAGS DEPLOYED AT 35 MPH NO APPARENT REASON. INJURED DRIVER WITH BURNS AND RINGING IN EAR. *TR
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A BURNING SMELL COMING FROM THE FRONT OF THE VEHICLE AS THE BATTERY LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT THE FUSE PANEL CAUGHT ON FIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR, THE HARNESS, AND THE FU…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS A BURNING SMELL COMING FROM THE FRONT OF THE VEHICLE AS THE BATTERY LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT THE FUSE PANEL CAUGHT ON FIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR, THE HARNESS, AND THE FUSE PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT FAILED TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 43,000.
MY WATER PUMP FAILED SUDDENLY WHILE DRIVING, THE ENGINE OVERHEAT SIGN LIT UP. I WAS IN THE MIDDLE OF NOWHERE. AFTER A PAINFULLY LONG DRAWN OUT TOW, TAXI, RENTAL CAR, AND RETURN TO PICK UP THE CAR 1 WEEK LATER (DRIVE 200 MILES THERE AND THEN BACK TO DO SO), THE GARAGE WHICH REPAIRED MY CAR INDICATED THAT THERE WAS A BAD "DESIGN…
Read full complaint
MY WATER PUMP FAILED SUDDENLY WHILE DRIVING, THE ENGINE OVERHEAT SIGN LIT UP. I WAS IN THE MIDDLE OF NOWHERE. AFTER A PAINFULLY LONG DRAWN OUT TOW, TAXI, RENTAL CAR, AND RETURN TO PICK UP THE CAR 1 WEEK LATER (DRIVE 200 MILES THERE AND THEN BACK TO DO SO), THE GARAGE WHICH REPAIRED MY CAR INDICATED THAT THERE WAS A BAD "DESIGN FLAW" TO THE WATER PUMP WHERE IT HAD A PLASTIC PART THAT WOULD COMMONLY FAIL DURING THE LIFE OF THE CAR. THEY TOLD ME THAT THIS WAS A "WELL-KNOW" PROBLEM IN THE JETTA, MANY PEOPLE HAD EXPERIENCED & WRITTEN ONLINE ABOUT IT. THEY RECOMMENDED THAT I INSTALL AN "AFTER-MARKET" PUMP WITH ALL METAL PARTS SO THAT IT WOULD NOT OCCUR AGAIN, WHICH I DID. MY CO-WORKER WHO OWNED A JETTA A FEW YEARS OLDER THAN MINE (2001?) FOR 10 YEARS AND LATER TRADED IT IN, INFORMED ME THAT SHE HAD THE EXACT SAME PROBLEM AND IN FACT HAD TO REPLACE THE WATER PUMP 3 TIMES DURING THE PERIOD SHE OWNED THE CAR. I WOULD LIKE TO MAKE A COMPLAINT ABOUT THE WATER PUMP DESIGN IN THE VOLKSWAGEN JETTA. IF IT HAD BEEN RECALLED & FIXED PRIOR TO MY BREAKDOWN, I WOULD NOT HAVE HAD TO ENDURE THE WHOLE ORDEAL I WENT THROUGH. *TR
THERE IS A FUSE BOX ON THE TOP OF MY BATTERY AS THERE WAS FOR ALL MK4 JETTAS, GOLF IN ALL MOTOR TRIMS. THE FUSE BOX ON TOP OF THE BATTERY MELTED. WHEN OPENED THERE WAS A BLACK WIRE SEVERED FROM THE BOX. WHEN TURNING THE BATTERY OVER THE CABLE WIRE WAS ARCHING. THE WIRE WAS ACTUALLY SPARKING. THERE ARE FUSES IN THE ORIGINAL BOX B…
Read full complaint
THERE IS A FUSE BOX ON THE TOP OF MY BATTERY AS THERE WAS FOR ALL MK4 JETTAS, GOLF IN ALL MOTOR TRIMS. THE FUSE BOX ON TOP OF THE BATTERY MELTED. WHEN OPENED THERE WAS A BLACK WIRE SEVERED FROM THE BOX. WHEN TURNING THE BATTERY OVER THE CABLE WIRE WAS ARCHING. THE WIRE WAS ACTUALLY SPARKING. THERE ARE FUSES IN THE ORIGINAL BOX BUT THEY NEVER BROKE, TRIPPED. *TR
CAR STALLS AT HIGHWAY SPEEDS WHEN AT QUARTER TANK OR LESS. PARTS REPLACED, STILL OCCURS. THERE IS NO KNOWN FIX FOR THIS PROBLEM, IT ALWAYS COMES BACK, AND IS MOST LIKELY A MANUFACTURERS DEFECT WITH THE FUEL PUMP SYSTEM THAT IS BEING IGNORED BY VW OF AMERICA. THIS IS HAPPENING TO HUNDREDS AND MOST LIKELY THOUSANDS OF VOLKSWAGEN …
Read full complaint
CAR STALLS AT HIGHWAY SPEEDS WHEN AT QUARTER TANK OR LESS. PARTS REPLACED, STILL OCCURS. THERE IS NO KNOWN FIX FOR THIS PROBLEM, IT ALWAYS COMES BACK, AND IS MOST LIKELY A MANUFACTURERS DEFECT WITH THE FUEL PUMP SYSTEM THAT IS BEING IGNORED BY VW OF AMERICA. THIS IS HAPPENING TO HUNDREDS AND MOST LIKELY THOUSANDS OF VOLKSWAGEN JETTA, GOLF, BEETLE AND GTI OWNERS. WE HAVE BEEN CONNECTING THE DOTS THROUGH ONLINE VW FORUMS AND ARE FRUSTRATED! THERE HAVE BEEN ACCIDENTS REPORTED DUE TO SUDDEN POWER LOSS AND THEREFORE DECELERATION DUE TO THIS ISSUE. JUST THIS MORNING MY JETTA STALLED IN FRONT OF A SEMI TRUCK DOING 65MPH ON THE HIGHWAY. THIS IS A VERY DANGEROUS PROBLEM, IT'S HAPPENING TO A LOT OF OWNERS OF VW'S MANUFACTURED BETWEEN 1999 AND 2005, AND IT NEEDS YOUR ATTENTION BEFORE SOMEONE GETS SERIOUSLY INJURED. THANK YOU. *TR
BATTERY FUSE BOX MELTED. ENGINE OVERHEATED AND CUT OFF. *TR
TL* THE CONTACT OWNS A 2003 VW JETTA. THE CONTACT STATED THAT WHILE DRIVING OVER A POTHOLE, THE VEHICLE EMITTED SMOKE AND STALLED. THE AIR BAGS ALSO INADVERTENTLY DEPLOYED AND THERE WAS SMOKE INSIDE AND OUTSIDE OF THE VEHICLE. THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DE…
Read full complaint
TL* THE CONTACT OWNS A 2003 VW JETTA. THE CONTACT STATED THAT WHILE DRIVING OVER A POTHOLE, THE VEHICLE EMITTED SMOKE AND STALLED. THE AIR BAGS ALSO INADVERTENTLY DEPLOYED AND THERE WAS SMOKE INSIDE AND OUTSIDE OF THE VEHICLE. THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DECLARED DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. UPDATED 11/12/14*LJ UPDATED 7/27/2015 *JS
AIR CONDITIONER STOPPED WORKING . FOUND LEFT FUSE ON FUSE BOX ON TOP OF BATTERY IS BLACK AND MELTED. *TR
Official recalls
218V406000 · Air Bags:frontal:driver Side:inflator Module
Jun 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.