Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports70 fire reports76 injury reports

What owners actually said

455 reports

145,000 miles · Jun 18, 2014

Electrical SystemLatches/locks/linkages

THE REAR DOOR LOCKS DO NOT WORK WITH THE KEY FOB OR THE ELECTRICAL SWITCH ION THE DRIVER'S DOOR. THIS IS A SERIOUS ISSUE WHEN YOU HAVE CHILDREN IN THE REAR SEAT. *TR

NHTSA ODI #10599208

116,898 miles · Jun 17, 2014

Electrical System

Read full complaint

THE DAY BEFORE THE CAR QUIT, IT WOULD NOT START AFTER BEING PARKED IN THE MALL PARKING LOT. A BATTERY PACK GOT IT STARTED, AND IT WAS DRIVEN HOME, WITH THE THOUGHT THAT IT NEEDED A NEW BATTERY. THE FOLLOWING DAY, IT WAS BEING DRIVEN TO THE LOCAL SEARS, FOR A REPLACEMENT BATTERY, WHEN THE ABS AND AIRBAG LIGHTS CAME ON. 30 SECONDS LATER LOTS OF WARNING LIGHTS CAME ON, AND THE CAR SPUTTERED AND STOPPED DEAD IN THE LANE OF TRAVEL. IT WOULD NOT TURN OVER, AND POWER ACCESSORIES WOULD NOT WORK. I WAS STOPPED ON A VERY BUSY 2 LANE BACK ROAD, WITH NO SHOULDERS OR SIDE STREETS, UPHILL, ON A BLIND HILL. AFTER 1 1/2 HOURS OF WHITE-KNUCKLE DIRECTING TRAFFIC, AND CALLS TO: MY AUTO CLUB, AND THE LOCAL POLICE; A LOCAL POLICE OFFICER, AND A LOCAL TOW TRUCK SHOWED UP AND GAVE ME A LIFT TO MY REPAIR SHOP. THE MECHANIC'S DIAGNOSIS OF THE PROBLEM WAS A PARTIALLY MELTED FUSE PACK, THAT SITS ON TOP OF THE BATTERY, AND AN OVERLY RESISTIVE CABLE BETWEEN THE FUSE PACK AND THE ALTERNATOR. THE SOLUTION WAS: THE CABLE END LINKED TO THE FUSE PACK WAS RE-TERMINATED, AND THE MELTED FUSE PACK WAS REPLACED. BETWEEN THE TOW AND THE REPAIR, IT SET ME BACK ABOUT $300.00. I ALSO FOUND A BLOG THAT LISTED MANY OTHER VW OWNERS WITH THE SAME PROBLEM: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4986219-FUSE-BOX-ABOVE-BATTERY-MELTING . I ALSO DISCOVERED A CLASS ACTION LAW SUIT THAT WAS FILED IN 2012, THAT WAS BASED ON THIS PROBLEM: HTTP://GOTACLASSACTION.COM/VOLKSWAGEN-NAMED-IN-CLASS-ACTION-OVER-FUSE-BOXALTERNATOR-CABLE-ASSEMBLY/ . I HOPE THAT THE CURRENT REPAIR HOLDS FOR THE NEAR FUTURE. CLEARLY, A FUSE SHOULD BLOW BEFORE THE OVERALL FUSE PACK MELTS. *TR

NHTSA ODI #10598985

36,000 miles · May 27, 2014

Service BrakesCrash

Read full complaint

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL SANK TO THE FLOORBOARD WHEN DEPRESSED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT MENTIONED THAT THE FAILURE CAUSED FOUR OTHER VEHICLES TO CRASH. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT WHERE IT WAS SCHEDULED TO BE INSPECTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

NHTSA ODI #10594350

180,000 miles · May 4, 2014

Visibility

Read full complaint

THE SUNROOF DRAIN IN MY CAR IS APPARENTLY MADE OF 2 TUBES THAT CONNECT AND WERE NOT SECURED TOGETHER SO THEY BECOME DETACHED AND POUR WATER INTO THE CAR. THIS HAPPENED TO ME THIS YEAR, I LOOKED IT UP AND FOUND THERE WAS A RECALL ON THIS THAT I NEVER RECEIVED. I CALLED ROGER JOBS(MY LOCAL VW DEALERSHIP) IN BELLINGHAM, WA AND THEY TOLD ME THE RECALL EXPIRED AND I WOULD HAVE TO PAY TO FIX THIS FACTORY DEFECT! I AM A COLLEGE STUDENT WHO CANNOT AFFORD TO FIX THIS PROBLEM AND REALLY MAKES ME MAD ESPECIALLY SINCE I RECEIVED NO NOTICE OF THIS RECALL. NOW I HAVE WATER FLOWING INTO MY CAR EVERY TIME IT RAINS, IT IS STARTING TO CAUSE RUSTING UNDER MY SEATS AND MOLD. NOT HAPPY! *TR

NHTSA ODI #10586394

67,000 miles · Apr 17, 2014

Suspension

Read full complaint

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE REAR OF THE VEHICLE BEGAN SWAYING INDEPENDENTLY. THE CONTACT, WHO WAS A LICENSED MECHANIC, INSPECTED THE VEHICLE AND DISCOVERED THAT THE REAR DRIVER'S SIDE AXLE BRACKET WAS RUSTED AND BECAME FRACTURED. THE DEALER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DECLINED TO PROVIDE THE CONTACT AN ALTERNATIVE REMEDY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 67,000. UPDATED 06/10/14*LJ UPDATED 06/13/2014 *JS

NHTSA ODI #10583330

83,000 miles · Mar 21, 2014

Electrical System

I HAVE A JETTA THAT CONTINUALLY BURNS OUT THE FUSE BOX, WHICH JUST HAPPENED AGAIN. THE FUSE BOX TO REPLACE COSTS AROUND $100. EVERYTIME. DUE TO THIS PROBLEM I AM ENCOUNTERING ADDITIONAL REPAIRS. IGNITION COIL ETC. I EVEN WENT AND PURCHASE A NEW BATTERY FOR 160.00. CAR WILL NOT RUN? HELP. *TR

NHTSA ODI #10574021

175,000 miles · Feb 23, 2014

Electrical System

CAR HAD A BURNING SMELL COMING FROM THE ENGINE. THE ENGINE LIGHT CAME ON. WHILE ON THE HIGHWAY THE CAR STOPPED MOVING FORWARD AND STALLED IN TRAFFIC, THE BATTERY LIGHT THEN CAME ON. I TURNED THE CAR OFF AND RESTARTED IT. IN A 30 MILE ROUND TRIP, THIS HAPPENED 3 TIMES. UPON FURTHER INSPECTION, THE BATTERY MOUNTED FUSE BLOCK …

Read full complaint

NHTSA ODI #10565482

138,000 miles · Feb 10, 2014

Electrical SystemFire

THE ALTERNATOR CABLE GOT SO HOT IT STARTED A SMALL FIRE IN THE FUSE BOX ON TOP OF MY BATTERY. COMPLETELY MELTED/BURNT THE FUSE BOX. I SEE THERE IS A GOOD PATTERN OF THIS HAPPENING WITH THESE JETTA AND BEETLES. *TR

NHTSA ODI #10563793

125,000 miles · Feb 10, 2014

Electrical SystemSeatsFireInjury

Read full complaint

TL- THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH A BURNING PLASTIC ODOR WAS PRESENT INSIDE THE VEHICLE BEFORE THE PASSENGER SUDDENLY EXPERIENCED A BURNING SENSATION COMING FROM THE SEATED AREA OF THE PASSENGER SEAT. THE CONTACT INDICATED THAT THE PASSENGER SIDE SEAT HEATER ELEMENT HAD OVER HEATED CAUSING A BURN HOLE IN THE SEAT AND CAUSING A MINOR BURN TO THE PASSENGER. THE CONTACT STATED THAT A SMALL FLAMED TO THE PASSENGERS RIGHT PANT LEG HAD TO BE EXTINGUISHED DURING THE INCIDENT AND THE PASSENGER SEAT BURN HOLE MEASURED APPROXIMATELY 1 INCH IN DIAMETER. THE VEHICLE WAS DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE DEFECT WAS CAUSED BY A FAULTY HEAT ELEMENT INSIDE THE SEAT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 125,000. JFT

NHTSA ODI #10563691

109,000 miles · Feb 1, 2014

Air Bags

PASSENGER SIDE CURTAIN AIRBAG DEPLOYED AFTER GOING INTO THE SHOULDER. THERE WAS NO DAMAGE TO TIRES, WHEELS, OR BODY OF CAR. INSURANCE COMPANY DECLARED A TOTAL LOSS. *TR

NHTSA ODI #10562471

Official recalls

18V406000 · Air Bags:frontal:driver Side:inflator Module

Jun 13, 2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.

07V063000 · Exterior Lighting:brake Lights:switch

Feb 20, 2007

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence & remedy

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP05004 · Engine Stalling

Opened Aug 11, 2005 · Closed Dec 8, 2005

Status: closed (inferred from source dates) · Electrical System:ignition:module

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

PE04081 · Inadvertent SIDE-AIRBAG Deployment

Opened Dec 16, 2004 · Closed Apr 1, 2005

Status: closed (inferred from source dates) · Air Bags:side/window

THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

EA04010 · Driver Side Front Seat Overheats

Opened Mar 30, 2004 · Closed Oct 21, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.

PE03052 · Driver Seat Overheats/burns

Opened Nov 19, 2003 · Closed Mar 30, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.