Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports70 fire reports76 injury reports

Latches/locks/linkages complaints

7 reports

Clear category filter

145,000 miles · Jun 18, 2014

Electrical SystemLatches/locks/linkages

THE REAR DOOR LOCKS DO NOT WORK WITH THE KEY FOB OR THE ELECTRICAL SWITCH ION THE DRIVER'S DOOR. THIS IS A SERIOUS ISSUE WHEN YOU HAVE CHILDREN IN THE REAR SEAT. *TR

NHTSA ODI #10599208

90,000 miles · Sep 28, 2013

Engine And Engine CoolingFuel System, GasolineLatches/locks/linkages

Read full complaint

I STARTED EXPERIENCING A HOT SPOT IN THE DRIVER'S HEATED SEAT IN THE FALL OF 2012. I HAVE TO PUT A CUSHION BETWEEN MY RIGHT LEG AND THE SEAT OR IT WILL NEARLY BURN. I HAVE ALSO BEEN HAVING AN ISSUE WITH EITHER THE O2 SENSOR OR CATALYTIC CONVERTER WHENEVER IT RAINS AND IT'S COOL WEATHER. THE CAR WILL LOSE POWER, SPUTTER AND LURCH UNTIL IT HAS BEEN RUNNING FOR A WHILE THEN IT ACTS NORMALLY. FINALLY, FOR THE PAST TWO MONTHS THE REAR DOOR LOCKS WILL NOT OPEN WITH THE KEYLESS ENTRY OR BY HITTING THE LOCK/UNLOCK BUTTON ON THE DOOR. I JUST REACHED THE 100K MARK AND KEEP UP REGULAR MAINTENANCE ON MY CAR SO I'M A LITTLE UPSET THAT THINGS LIKE THIS ARE HAPPENING SO EARLY. *TR

NHTSA ODI #10546042

64,000 miles · Apr 15, 2013

Latches/locks/linkages

Read full complaint

I OWN A 2003 VOLKSWAGEN GL 1.8 T, WHEN I PRESS THE LOCK BUTTON, THE CAR DOORS DO NOT ALL LOCK, OR WILL WORK SOMETIMES, I ALSO AM NOT ABLE TO GET INTO THE TRUNK. UPON FURTHER RESEARCH I DISCOVERED THAT THIS IS MORE THEN A COMMON PROBLEM WITH THIS VEHICLE, IN ORDER TO GET THE TRUNK OPEN I HAVE TO CRAWL THROUGH SPACE AND PULL THE EMERGENCY LEVER INSIDE THE TRUNK, IN ORDER TO LOCK THE CAR I HAVE TO MANUALLY PUSH DOWN THE LOCKS WHEN THE KEY DOESN'T WORK AND 40 % OF THE TIME I OR A PASSENGER GETS LOCKED IN THE CAR, UNTIL IT DECIDES TO GIVE. *TR

NHTSA ODI #10508337

70,000 miles · Sep 29, 2009

Latches/locks/linkages

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN NEW JETTA. WHILE DRIVING IN WINDY CONDITIONS, THE HINGE ON THE TRUNK FRACTURED AND THE TRUNK OPENED. WHEN THE TRUNK OPENED, IT SLAMMED INTO THE WINDSHIELD, AND CAUSED IT TO SHATTER. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 70,000.

NHTSA ODI #10285627

40,000 miles · Feb 12, 2009

Latches/locks/linkages

Read full complaint

I HAVE A 2003 VW JETTA. ON NUMEROUS OCCASIONS, WHEN I START THE CAR AND GET OUT TO SCRAPE THE SNOW & ICE OFF OF THE WINDOWS, THE DOOR LOCKS ENGAGE AND LOCK ME OUT OF THE RUNNING CAR. SINCE I HAVE JUST LEFT MY CAR TO REMOVE SNOW, OF COURSE MY PURSE AND CELL PHONE ARE IN THE CAR, SO I HAVE TO LEAVE THE LOCKED CAR RUNNING WHILE I KNOCK ON NEIGHBORS DOORS TO CALL SOMEONE TO BRING ME A SPARE KEY TO MY HOUSE, SO I CAN GET THE SPARE KEY TO MY CAR. I HAVE NOT HAD THE LOCKS REPAIRED, BUT WHEN I TOOK MY CAR TO GEBHARDT VW IN BOULDER FOR OTHER REPAIRS, I WAS TOLD THE PROBLEM IS SO COMMON THAT THE MECHANICS ROLL THE WINDOWS DOWN WHENEVER A CAR COMES IN FOR SERVICE, TO MAKE SURE THEY WON'T GET LOCKED OUT. THE MECHANIC ACTUALLY HAD A BROKEN LOCK SITTING ON HIS DESK, AND SHOWED ME HOW THE LOCK WAS SUPPOSED TO WORK, BUT WHAT IT DOES INSTEAD. *TR

NHTSA ODI #10258503

45,000 miles · Feb 10, 2008

Latches/locks/linkages

INTERMITTENT MALFUNCTION OF REAR DOOR LOCKS. CAN'T OPEN. REPORTER TO DEALER WHILE UNDER WARRANTY. DEALER COULD NOT REMEDY. AFTER WARRANTY EXPIRED, DEALER RECOMMENDER SERVICE. DEALER CHECKED AND VERIFIED THAT THE PROBLEM HAD BEEN REPORTED PREVIOUSLY WHEN SERVICED(FROM THEIR RECORDS).NEFTIN VOLKSWAGEN, THOUSAND OAKS CA. *TR

NHTSA ODI #10217602

40 miles · Dec 27, 2002

Latches/locks/linkagesStructure

Read full complaint

VEHICLE DESCRIPTION - 2003 VOLKSWAGEN JETTA GLI. VR6 WITH 6 SPEED MANUAL TRANSMISSION. VIN 3 V W V H 6 9 M 1 3 M 0 5 4 8 0 3. DATE OF PURCHASE - 17-OCT-2002. MILEAGE AT TIME OF NHTSA COMPLAINT - 1550. PROBLEM: DOOR "RATTLE" UNDER ANY DRIVING CONDITION. THE "RATTLING" WAS FIRST THOUGHT TO BE THE PANELING. TEFLON TAPE WAS PLACED BETWEEN THE METAL PART AND THE PLASTIC PANELING. THIS PROCEDURE STOPPED THE PANELING FROM MAKING ANY NOISE. BUT THE PROBLEM CONTINUED. THE NOISE "RATTLING" IS COMING FROM THE UPPER FRAME OF THE DOOR. MEANING THE DOOR IS NOT CLOSING OR MEETING THE ROOF/PILLAR SECTION OF THE ROOF. WATER PASSED THROUGH THE DOOR. THE OTHER DAY WE HAD RAIN FOR SEVERAL DAYS, AND WATER WAS COMING IN WHILE THE CAR WAS DRIVEN. THE DEALERSHIP HAS TRIED SEVERAL APPROACHES INCLUDING THE ONE MENTIONED ABOVE. ALSO, VW TECH SUPPORT HAS BEEN CONTATED AND SUGGESTED TO REPLACE THE DOOR STRIKERS. DOOR STRIKERS (ALL 4) HAVE BEEN REPLACED AND NO IMPROVEMENT. DEALERSHIP IS WAITING FOR "VW ENGINEERING DEPARTMENT TO GET BACK FROM THE HOLIDAYS" TO SEE WHAT STEPS TO BE TAKEN. I FEEL THIS IS A SAFETY ISSUE AS THE DOOR ARE NOT CLOSING PROPERLY. IN CASE OF AN ACCIDENT WILL THE DOOR HOLD IN PLACE? WHAT HAPPENS IF I INSTALL A ROOF RACK AND PLACE A LOAD IN THE ROOF? IS THE ROOF GOING TO GIVE IN SINCE IT IS MISSING THE ADDITIONAL SUPPORT FROM THE DOORS? MY MAIN CONCERN IS IN CASE OF AN ACCIDENT ARE THE DOOR GOING TO HOLD IN PLACE OR ARE THEY GOING TO FLY OF SINCE THE VIBRATION "OPENING AND CLOSING" THE DOORS? TS

NHTSA ODI #10000403

Official recalls

18V406000 · Air Bags:frontal:driver Side:inflator Module

Jun 13, 2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.

07V063000 · Exterior Lighting:brake Lights:switch

Feb 20, 2007

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence & remedy

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP05004 · Engine Stalling

Opened Aug 11, 2005 · Closed Dec 8, 2005

Status: closed (inferred from source dates) · Electrical System:ignition:module

BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

PE04081 · Inadvertent SIDE-AIRBAG Deployment

Opened Dec 16, 2004 · Closed Apr 1, 2005

Status: closed (inferred from source dates) · Air Bags:side/window

THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

EA04010 · Driver Side Front Seat Overheats

Opened Mar 30, 2004 · Closed Oct 21, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.

PE03052 · Driver Seat Overheats/burns

Opened Nov 19, 2003 · Closed Mar 30, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.