Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
790–25K
9225–50K
7650–75K
4875–100K
46100–150K
33150K+
374 reports with mileage · 81 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seats. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports70 fire reports76 injury reports
What owners actually said
455 reports
Mileage unknown · Nov 16, 2015
Electrical System
I'VE HAD MULTIPLE ISSUES WITH MY VW JETTA 2003 AND HAVE PUT THOUSANDS OF DOLLARS INTO THE VEHICLE. MY LIMIT WAS THAT ALTERNATOR CABLE MELTING THE FUSE BOX AND THE BATTERY. THE VEHICLE IS UNSAFE AND COULD HAVE CAUGHT ON FIRE AND POTENTIALLY INJURED INDIVIDUALS OR CAUSED GREAT HARM. THE SAD PART ABLE THE ENTIRE SCENARIO IS THE F…
Read full complaint
I'VE HAD MULTIPLE ISSUES WITH MY VW JETTA 2003 AND HAVE PUT THOUSANDS OF DOLLARS INTO THE VEHICLE. MY LIMIT WAS THAT ALTERNATOR CABLE MELTING THE FUSE BOX AND THE BATTERY. THE VEHICLE IS UNSAFE AND COULD HAVE CAUGHT ON FIRE AND POTENTIALLY INJURED INDIVIDUALS OR CAUSED GREAT HARM. THE SAD PART ABLE THE ENTIRE SCENARIO IS THE FACT THAT I CONTACTED VOLKSWAGEN CUSTOMER CARE THAT SPOKE WITH BREA S. WHICH MAY NOT BE AN ACTUAL NAME BECAUSE SHE COULD NOT PROVIDE IT AND SHE SAID THAT SHE HAD SPOKEN TO HER LEADERSHIP ASHLEY AND THAT THEY DID NOT SEE THIS AS A SAFETY CONCERNS AND JUST BECAUSE LOTS OF OTHER PEOPLE HAD THE SAME ISSUE AND MENTIONED IT ON A BLOG THEY WERE NOT ABLE TO HELP ME. NOW FOR ME SOMETHING THAT CAN CAUSE A POTENTIAL ELECTRICAL FIRE FOR MOST PEOPLE IS A SAFETY CONCERN AND THE FACT THAT THIS IS A KNOWN ISSUE WITH THE VOLKSWAGEN JETTA AND BEETLE MODELS, IT AMAZES ME THAT VW CUSTOMER CARE DOES NOT SEE IT AS THERE ISSUE, BREA WAS OUT OF THE AUBURN HILLS LOCATION IN MICHIGAN. THIS REALLY NEEDS FURTHER ATTENTION.
NHTSA ODI #10790767
193,000 miles · Oct 26, 2015
Electrical System
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED FOR A FEW DAYS, THE BATTERY FAILED TO MAKE CONNECTION WHEN STARTING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT N…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED FOR A FEW DAYS, THE BATTERY FAILED TO MAKE CONNECTION WHEN STARTING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 193,000.
NHTSA ODI #10786157
86,000 miles · Sep 11, 2015
Electrical System
THE FUSE BOX IN THESE OLDER JETTAS MELTS BECAUSE IT IS ON TOP OF THE BATTERY, WHICH CAN CAUSE THE CAR TO SHUT OFF WHILE DRIVING. ITS VERY DANGEROUS.
NHTSA ODI #10763228
150,489 miles · Sep 10, 2015
Electronic Stability Control (esc)EngineSteering
THE JETTA IS DEFECTIVE IN THE CAR WILL START BUT NEEDS TO BE ENGAGED IN IGNITION AND THE SIT FOR 12-15 MINUTES BEFORE IT IS ABLE TO GET IN DRIVE GEAR. CURRENTLY IT WILL NOT ENGAGE IN REVERSE GEAR. THE TEMPERATURE IS MILD 74-78DEGREES F AND THE CAR NEEDS TO BE CONSTANTLY SERVICED. UPON THE INCIDENT THIS JETTA WAS DRIVING AND THER…
Read full complaint
THE JETTA IS DEFECTIVE IN THE CAR WILL START BUT NEEDS TO BE ENGAGED IN IGNITION AND THE SIT FOR 12-15 MINUTES BEFORE IT IS ABLE TO GET IN DRIVE GEAR. CURRENTLY IT WILL NOT ENGAGE IN REVERSE GEAR. THE TEMPERATURE IS MILD 74-78DEGREES F AND THE CAR NEEDS TO BE CONSTANTLY SERVICED. UPON THE INCIDENT THIS JETTA WAS DRIVING AND THERE WAS A VISIBILITY PROBELM THROUGH THE WINDSHIELD . THE WINDSHIELF WAS REPLACED. THE ENGINE LIGHTS ARE ON THE ENGINE WAS SERVICED, IT WAS LEAKING FLUIDS, IT WAS SERVICED BY A REPUTABLE SERVICE CENTER 9 MILE EASTPOINTE A SPECIALIST IS FOREIGN CARS. THEN THE JETTA WHILE DRIVING IN A RESIDENTIAL AREA THE STEERING LOCKED UP AND WAS STIFF , STIFFER STILL AND UNABLE TO ENGAGE THE DRIVING RHYTHM I AM AN EXPERIENCED DRIVER AND ACCUSTOMED TO PRE POWER STEERING AND THIS WAS A MECHANICAL FAILURE IN THE STEERING, WHEELS?? CURRENTLY THE CAR IS UNABLE TO BE USED AS IT WONT GO IN GEAR OF REVERSE, IT MOVES ON THE CONSUL AND THERE IS NO MOTION. THE BATTERY AND THE FLUIDS AND THE CELANOIDS,BELTS, EVERYTHING HAS BEEN CHECKED AND LOOKED OVER. I HAD TO GET A TOW TO GET IT SERVICED IN OCT. 2014 AND WILL HAVE TO GET A TOW NOW TOO FOR THE ESTIMATE OF WHY THE FLAT FUSE ON THE BATTERY IS NOT ABLE TO GIVE THE ENGINE ENOUGH POWER TO DRIVE OR REVERSE. THE JETTA WAS BOUGHT USED FROM ANOTHER PARTY, AND HAD AN ACCIDENT FROM THAT OWNER, IT WAS SOLD TO ME AND SINCE THEN THE LEAKING FLUIDS, CHECK ENGINE LIGHT HAVE BEEN SERVICED. I SEE 0 RECALLS. I REALIZE YOU HAVE OVER 40,000 CONSUMER COMPLAINTS BUT THIS IS A SAFETY CONCERN AS I TRANSPORT HUMAN PASSENGERS OF MINOR AGE AND HAVE HAD DIFFICULTY SEVERAL TIMES IN JUST DRIVING DOWN THE STREET TO MANOUVER A SMALL CAR. THIS JETTA IS AGED AND HAS HIGH MILEAGE BUT THIS IS A GERMAN ENGINE? THE PRECISION AND TUNING I HAVE PREVIOUSLY EXPERIENCED FROM AN AUTOMOBILE IS LACKING IN THE COMPONENTS OF THE ENGINE PIECES PUT INTO ACTION TO DRIV.
NHTSA ODI #10762811
Mileage unknown · Aug 31, 2015
Electrical System
ALTERNATOR HARNESS WIRING AND FUSE BOX ARE UNDER-ENGINEERED FOR ELECTRICAL CONDITIONS AND OUTPUT GIVEN BY ALTERNATOR. THIS IS THE SECOND TIME IN ONE YEAR I HAVE TO REPLACE THE FUSE BOX AND ALTERNATOR HARNESS WIRING DUE TO RISK OF ENGINE BAY FIRE. MANY OTHER VW OWNERS IN THIS GENERATION AND DIFFERENT MODELS ALSO HAVE THIS PROBLEM…
Read full complaint
ALTERNATOR HARNESS WIRING AND FUSE BOX ARE UNDER-ENGINEERED FOR ELECTRICAL CONDITIONS AND OUTPUT GIVEN BY ALTERNATOR. THIS IS THE SECOND TIME IN ONE YEAR I HAVE TO REPLACE THE FUSE BOX AND ALTERNATOR HARNESS WIRING DUE TO RISK OF ENGINE BAY FIRE. MANY OTHER VW OWNERS IN THIS GENERATION AND DIFFERENT MODELS ALSO HAVE THIS PROBLEM WITH THEIR VEHICLES. I BELIEVE THIS SHOULD BE RECALLED AND IT IS EXTREMELY DANGEROUS TO GO UNNOTICED.
NHTSA ODI #10760319
159,000 miles · Jun 15, 2015
Fuel/propulsion System
WHILE DRIVING ON THE FREEWAY MY VEHICLE BEGAN TO LOOSE POWER AND THEN JUST SHUT OFF. LOOKING AT THE FUEL GAUGE I HAD A QUARTER OF A TANK LEFT IN FUEL. PULLING TO THE SHOULDER OF THE FREEWAY I ATTEMPTED TO RESTART MY VEHICLE. AFTER 5-10 MINUTES OF TRYING TO RESTART MY VEHICLE, IT STARTED. I THEN DROVE TO THE NEAREST GAS STATION A…
Read full complaint
WHILE DRIVING ON THE FREEWAY MY VEHICLE BEGAN TO LOOSE POWER AND THEN JUST SHUT OFF. LOOKING AT THE FUEL GAUGE I HAD A QUARTER OF A TANK LEFT IN FUEL. PULLING TO THE SHOULDER OF THE FREEWAY I ATTEMPTED TO RESTART MY VEHICLE. AFTER 5-10 MINUTES OF TRYING TO RESTART MY VEHICLE, IT STARTED. I THEN DROVE TO THE NEAREST GAS STATION AND FILLED UP MY TANK. A COUPLE OF DAYS LATER I WAS DRIVING ON THE FREEWAY AGAIN AND THE SAME THING HAPPENED. THE FUEL GAUGE READ A QUARTER OF A TANK LEFT AND HAD TO PULL OVER AGAIN TO ATTEMPT TO RESTART MY CAR. THIS NOW HAPPENS EVERY TIME THE VEHICLES FUEL LEVEL GETS TO A QUARTER OF A TANK. I'M LEFT HAVING TO FILL UP MY TANK AT THAT POINT, QUARTER OF A TANK, TO AVOID BREAKING DOWN ON THE FREEWAY OR ANYTIME WHILE DRIVING.
NHTSA ODI #10725356
96,000 miles · Jun 3, 2015
Electrical SystemFire
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE CONTACT NOTICED SMOKE UNDER THE HOOD THAT ENTERED THE CABIN OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND OPENED THE BATTERY FUSE BOX WHERE HE FOUND THAT THERE WERE OVERHEATED WIRES AND OVERWHELMING SMOKE. THE CONTACT STATED THAT THE FAILURE WAS RECURR…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE CONTACT NOTICED SMOKE UNDER THE HOOD THAT ENTERED THE CABIN OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND OPENED THE BATTERY FUSE BOX WHERE HE FOUND THAT THERE WERE OVERHEATED WIRES AND OVERWHELMING SMOKE. THE CONTACT STATED THAT THE FAILURE WAS RECURRING AND THE SMOKE WAS EMITTING FROM THE BATTERY FUSE BOX. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10723278
64,000 miles · Jun 2, 2015
Power Train
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SLOWED DOWN AND WOULD NOT ACCELERATE. THE FAILURE OCCURRED WITHOUT WARNING ON FOUR OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SLOWED DOWN AND WOULD NOT ACCELERATE. THE FAILURE OCCURRED WITHOUT WARNING ON FOUR OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.
NHTSA ODI #10722931
200,000 miles · Dec 26, 2014
Suspension
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED, THE TECHNICIAN DISCOVERED THAT THE NOISE BARRIER WAS RUSTING FROM THE INSIDE OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10668278
145,000 miles · Dec 1, 2014
Engine
FORTUNATELY, MY SON WAS AT A RED LIGHT AND WENT TO TAKE OFF AND IT WOULD NOT CHANGE GEARS..HE ROLLED INTO THE PARKING LOT AHEAD OF HIM. HE TOLD THE WRECKER DRIVER THAT IT FELT LIKE SOMETHING FELL - WE OPENED THE HOOD AND SAW THAT THE MOTOR WAS ACTUALLY SITTING CROOKED. THE MOTOR MOUNTS WERE BROKEN, ON ONE SIDE BROKEN OFF ON THE …
Read full complaint
FORTUNATELY, MY SON WAS AT A RED LIGHT AND WENT TO TAKE OFF AND IT WOULD NOT CHANGE GEARS..HE ROLLED INTO THE PARKING LOT AHEAD OF HIM. HE TOLD THE WRECKER DRIVER THAT IT FELT LIKE SOMETHING FELL - WE OPENED THE HOOD AND SAW THAT THE MOTOR WAS ACTUALLY SITTING CROOKED. THE MOTOR MOUNTS WERE BROKEN, ON ONE SIDE BROKEN OFF ON THE OTHER STRIPPED.THIS COULD HAVE BEEN A VERY BAD OUTCOME. SEVERAL MECHANICS HAVE TRIED TO REPAIR IT (UNREPAIRABLE). WE HAVE BEEN TOLD THAT THE BLOCK AND/OR ENGINE WILL HAVE TO BE REPLACED. THE COST FOR THE PART IS BETWEEN $ 3100-3700 - PLUS LABOR. KEEP IN MIND THAT THE MOTOR RUNS GREAT! I HAVE CONTACTED VW - WITH NO LUCK.. BUT ADMITTING THAT THERE HAVE BEEN OTHERS. I FEEL THAT THIS IS NOT ONLY POORLY DESIGNED..MAYBE NOT STRONG ENOUGH MATERIAL, BUT IT IS OR COULD BE DANGEROUS. AS I STATED FORTUNATELY MY SON WAS A T A RED LIGHT..NOT GOING DOWN THE HWY AND COME TO A SUDDEN STOP. *JS
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.
2003 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration