Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
525–50K
950–75K
775–100K
4100–150K
1150K+
49 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports4 injury reports
What owners actually said
74 reports
Mileage unknown · Jun 5, 2003
Steering
I PURCHASED MY VEHICLE IN JANUARY 2003, FIRST PROBLEM WAS THAT WHILE DRIVING WITH MY 4 MONTH OLD DAUGHTER THE STEERING WHHEL WENT OUT ON ME. I TRIED TO TURN THE CAR WHILE GETTING ON THE EXPRESSWAY AND THE STEERING WHEEL KEPT SPINNING BUT I DID NOT TURN AND ALMOST HIT A CEMENT VIDUCT. NEXT ABOUT 1 MONTH LATER MY CAR BEGAN TO NO…
Read full complaint
I PURCHASED MY VEHICLE IN JANUARY 2003, FIRST PROBLEM WAS THAT WHILE DRIVING WITH MY 4 MONTH OLD DAUGHTER THE STEERING WHHEL WENT OUT ON ME. I TRIED TO TURN THE CAR WHILE GETTING ON THE EXPRESSWAY AND THE STEERING WHEEL KEPT SPINNING BUT I DID NOT TURN AND ALMOST HIT A CEMENT VIDUCT. NEXT ABOUT 1 MONTH LATER MY CAR BEGAN TO NOT START OR CUT OFF ON ME WHEN I WOULD FIRST START DRIVING AND THE CHIME WILLNOT GO OFF. THE DEALER TOLD ME THAT THEY HAVE BEEN HAVING THIS PROBLEM WITH THEM AND HE WILL CONTACT ME WHEN THE MANUFACTURER TELLS THEM HOW TO FIX THE PROBLEM.
NHTSA ODI #10021092
4,000 miles · Jun 1, 2003
Electrical System
2003 KIA RIO. POSSIBLE MALFUNCTION WITH THE ELECTRICAL SYSTEM. *TT
NHTSA ODI #10020839
400 miles · May 19, 2003
Electrical System
I HOPE THAT I AM WRITING THE CORRECT PEOPLE ABOUT THIS HUGE PROBLEM. ABOUT THREE WEEKS AGO I PURCHASED A 2003 KIA RIO IN MILWAUKEE WISCONSIN. ABOUT TWO WEEKS AFTER I OWNED THE CAR I RAN INTO PROBLEMS WITH IT. IT SEEMED LIKE EVERY MORNING OR ANY TIME THE CAR WAS NOT RUNNING FOR MORE THEN FOUR HOURS IT WOULD NOT START UP. IT WAS …
Read full complaint
I HOPE THAT I AM WRITING THE CORRECT PEOPLE ABOUT THIS HUGE PROBLEM. ABOUT THREE WEEKS AGO I PURCHASED A 2003 KIA RIO IN MILWAUKEE WISCONSIN. ABOUT TWO WEEKS AFTER I OWNED THE CAR I RAN INTO PROBLEMS WITH IT. IT SEEMED LIKE EVERY MORNING OR ANY TIME THE CAR WAS NOT RUNNING FOR MORE THEN FOUR HOURS IT WOULD NOT START UP. IT WAS LIKE IT WAS OUT OF GAS WHEN I HAD A FULL TANK. IT WOULD TAKE ME ABOUT TWO TO FOUR TRIES BEFORE IT WOULD START. ALSO IT WAS GOING THROUGH MORE GAS THEN WHAT WAS DISCLOSED AS FAR AS MPG. AT THAT POINT I TOOK IT IN TO THE DEALER SERVICE DEPARTMENT TO HAVE IT CHECKED OUT. AT FIRST THEY TOLD ME THAT THEY HAD MANY PROBLEMS WITH THAT BRAND AND MODEL OF CAR AND IT WOULD BE REPAIRED THE NEXT DAY. THE NEXT DAY I GOT A PHONE CALL FROM THE SERVICE DEPARTMENT TELLING ME THAT THE CAR'S COMPUTER WAS NOT WORKING CORRECTLY AND THEY NEEDED TO ORDER A REPLACEMENT THAT WOULD TAKE ABOUT SEVEN BUSINESS DAYS. THEY TOLD ME THAT I COULD PICK UP THE CAR BUT IT WILL START HARD AND GIVE ME POOR FUEL ECONOMY UNTIL IT WAS REPAIRED. I WAS UNHAPPY ABOUT THE LONG WAIT SO I CALLED KIA, THEY TOLD ME THAT THEY WOULD CALL THE DEALERSHIP AND FIND OUT WHY THIS COMPUTER WOULD TAKE SO LONG. TWO DAYS LATER I GOT A CALL FROM THE SERVICE MANGER WHO TOLD ME THAT THEY CAN NOT REPAIR THE CAR'S COMPUTER AT THIS TIME BECAUSE KIA DOES NOT HAVE A FIX FOR IT YET. HE TOLD ME THAT BECAUSE I LIVE IN MILWAUKEE I USE REFORMULATED GAS AND THE COMPUTER CAN NOT UNDERSTAND THAT KIND OF FUEL AND UNTIL KIA HAS A FIX FOR THAT THERE IS NOTHING HE CAN DO. I THEN ASKED HIM IS THE CAR SAFE, HE TOLD ME THAT IT WOULD BE FINE TO DRIVE I JUST HAVE TO START THE CAR AND WAIT 5 TO 10 SEC AND TRY AGAIN TILL IT STARTS. *JB
NHTSA ODI #10018897
Mileage unknown · Nov 8, 2002
Seat Belts
THE SEAT BELTS WAS DESIGNED POORLY, THEY CUT ACROSS THE NECK AND THROAT OF THE DRIVER/PASSENGER. CONSUMER CONTACTED MANUFACTURER AND DEALERSHIP FOR SEAT BELT EXTENSIONS AND WAS INFORMED THAT THEY WERE NOT OBLIGATED TO INSTALL BELT EXTENSIONS. TS *JB
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.
Consequence & remedy
Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT
2003 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration