IllustrationDOOR LOCKS ON BOTH FRONT DOORS STUCK IN THE LOCKED POSITION.
2001 Kia Rio
Owner reports · Recalls · Investigations
More warning signs than most Rio years
Owner complaints for the 2001 Kia Rio are substantially higher than the model-year median of 38.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rio years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2125–50K
2450–75K
475–100K
9100–150K
0150K+
75 reports with mileage · 148 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports14 fire reports8 injury reports
What owners actually said
223 reportsPARKED CAR AT WORK CAME BACK OUT AND THE DOOR LOCK WAS DOWN TRIED TO PULL UP BUT IS STUCK OR CAUGHT ON SOMETHING. THE WAY THE SCREWS ARE IN THE DOOR 2 OF THEM CANNOT BE TAKEN OUT WITHOUT HAVING THE DOOR OPEN. WITH LONG LEGS ITS VERY DIFFICULT TO GET IN AND OUT OF VEHICLE!!! ALSO TROUBLE WITH THE ENGINE MISFIRING OF SPARKPLUG WIT…
Read full complaint
PARKED CAR AT WORK CAME BACK OUT AND THE DOOR LOCK WAS DOWN TRIED TO PULL UP BUT IS STUCK OR CAUGHT ON SOMETHING. THE WAY THE SCREWS ARE IN THE DOOR 2 OF THEM CANNOT BE TAKEN OUT WITHOUT HAVING THE DOOR OPEN. WITH LONG LEGS ITS VERY DIFFICULT TO GET IN AND OUT OF VEHICLE!!! ALSO TROUBLE WITH THE ENGINE MISFIRING OF SPARKPLUG WITH SOME LOSS OF POWER. *TR
IT IS DIFFICULT TO ENTER THE CAR WITH THE KEY AND WHEN I PULL THE DOOR HANDLE THE LOCK DROPS DOWN TO THE CLOSE POSITION AND I CAN'T GET OUT THIS HAPPENS ON THE DRIVER'S SIDE AND THE FRONT PASSENGER SIDE,I HAVE TO HOLD THE LOCK ON THE UP POSITION WITH A PIECE OF METAL OR LEAVE THE REAR DOORS UNLOCKED IN CASE I HAVE TO JUMP OUT..…
Read full complaint
IT IS DIFFICULT TO ENTER THE CAR WITH THE KEY AND WHEN I PULL THE DOOR HANDLE THE LOCK DROPS DOWN TO THE CLOSE POSITION AND I CAN'T GET OUT THIS HAPPENS ON THE DRIVER'S SIDE AND THE FRONT PASSENGER SIDE,I HAVE TO HOLD THE LOCK ON THE UP POSITION WITH A PIECE OF METAL OR LEAVE THE REAR DOORS UNLOCKED IN CASE I HAVE TO JUMP OUT..THIS CAR IS A LEMON I HAVE REPLACED SENSORS ALTERNATOR, STARTER, AC PARTS AND MANY OTHER PARTS THE ONLY THING GOOD IS THE TRANSMISSION AND THE ENGINE... *JS
CONSUMER COMPLAINT: ODI CASE NUMBER: 10136024 COMPONENT: WHEELS GAS IGNITION? YOU TELL ME? WHEN ARE THESE PEOPLE GOING TO BE COMPENSATED FOR THEIR LEMONS KIA-2001 DETAILS: DT: THE CONSUMER WAS INVOLVED IN AN ACCIDENT AND A TIRE BLEW OUT. AFTER THE VEHICLE STOPPED SPINNING, THE CONSUMER GOT OUT OF THE VEHICLE AND IT BURST…
Read full complaint
CONSUMER COMPLAINT: ODI CASE NUMBER: 10136024 COMPONENT: WHEELS GAS IGNITION? YOU TELL ME? WHEN ARE THESE PEOPLE GOING TO BE COMPENSATED FOR THEIR LEMONS KIA-2001 DETAILS: DT: THE CONSUMER WAS INVOLVED IN AN ACCIDENT AND A TIRE BLEW OUT. AFTER THE VEHICLE STOPPED SPINNING, THE CONSUMER GOT OUT OF THE VEHICLE AND IT BURST INTO FLAMES, THE FIRE DEPARTMENT CAME AND THEY SAID FIRE STARTED FROM HEAT OF POWER EQUIPMENT AND THE IGNITION BURNED. THIS HAPPENED ON AUGUST 6, 2005. *AK THE CONSUMER STATED SHE WAS NOT INFORMED ABOUT THE RECALL REGARDING THE WHEELS. THE CONSUMERS DAUGHTER COMPLAINED THAT THE STEERING WHEEL VIBRATED FROM THE TIME THE VEHICLE WAS PURCHASED. THE SAME TIRE THAT THE BLEW OUT WAS THE SAME ONE THAT HAD BEEN REPLACED NUMEROUS TIMES. *JB OCCURRENCES: 1 INJURIES: 0 FAIL DATE: 08/06/2005 DEATHS: 0 DATE ADDED TO DATABASE: 9/9/2005 [FILE] YOUR OWN COMPLAINT ON THIS MODEL CAR. *TR
I WAS ON A MAJOR INTERSTATE DOING THE SPEED LIMIT OF 65 MPH WHEN I HEARD A LOUD POP SOUND. THE CAR STARTED TO SHAKE AND I THOUGHT I HAD A FLAT TIRE. I IMMEDIATELY PUT ON MY HAZARD LIGHTS AND SLOWED DOWN TO REACH THE NEAREST EXIT RAMP. I WAS ALONE IN THE CAR AND THANK GOD I HAD NO CHILDREN IN THE CAR AND AS SOON AS I REACHED T…
Read full complaint
I WAS ON A MAJOR INTERSTATE DOING THE SPEED LIMIT OF 65 MPH WHEN I HEARD A LOUD POP SOUND. THE CAR STARTED TO SHAKE AND I THOUGHT I HAD A FLAT TIRE. I IMMEDIATELY PUT ON MY HAZARD LIGHTS AND SLOWED DOWN TO REACH THE NEAREST EXIT RAMP. I WAS ALONE IN THE CAR AND THANK GOD I HAD NO CHILDREN IN THE CAR AND AS SOON AS I REACHED THE EXIT RAMP I GOT OFF THE EXIT AND CALLED AAA. THEY SENT A TOW TRUCK BUT WHEN THE DRIVER WENT TO PUT THE CAR UP HE NOTICED THE RIGHT BACK WHEEL WAS EXTREMELY LOOSE AND THEN CALLED FOR A FLAT BED. WHILE BEING TOWED TO MY MECHANIC WITH THE CAR ON THE FLAT BED THE WHEEL CAME COMPLETELY OFF. I LOOKED ONLINE FOR RECALLS ON MY CAR AND THERE WAS ONE ISSUED IN 4/20/2005 AND I WAS NEVER NOTIFIED BY KIA OR THE DEALER WHERE I PURCHASED THE CAR ABOUT THIS ISSUE WHEN THE RECALL BEGAN ON 6/22/2005. I AM WORRIED NOW THAT I MAY HAVE TO PAY OUT OF POCKET FOR THIS REPAIR WHICH KIA MOTORS SHOULD HAVE NOTIFIED ME ON. *JS
BOTH DOOR LOCKS GET STUCK ON BOTH THE PASSENGER SIDE AND DRIVERS SIDE. WE HAVE HAD TO CLIMB IN THE BACK SEAT TO EXIT THE CAR. THIS IS VERY DANGEROUS AND COULD CAUSE DEATH OR INJURY IF A FIRE AND COULD NOT EXIT THE CAR. *TR
I BOUGHT A 2001 KIA RIO IN 2007 AND WITHIN 8 MONTHS MY FUEL PUMP HAD TO BE REPLACED. A YEAR LATER MY CAR STARTED SPUTTERING AND SHUTTING OFF RANDOMLY WHILE I DROVE IT. I ENDED UP HAVING TO REPLACE THE FUEL PUMP TWO MORE TIMES. I RECENTLY TOOK IT TO THE DEALERSHIP WERE THEY INFORMED ME I NEEDED ANOTHER FUEL PUMP. IM SORRY BUT THE…
Read full complaint
I BOUGHT A 2001 KIA RIO IN 2007 AND WITHIN 8 MONTHS MY FUEL PUMP HAD TO BE REPLACED. A YEAR LATER MY CAR STARTED SPUTTERING AND SHUTTING OFF RANDOMLY WHILE I DROVE IT. I ENDED UP HAVING TO REPLACE THE FUEL PUMP TWO MORE TIMES. I RECENTLY TOOK IT TO THE DEALERSHIP WERE THEY INFORMED ME I NEEDED ANOTHER FUEL PUMP. IM SORRY BUT THERE IS SOMETHING WRONG IF I HAVE TO REPLACE THE FUEL PUMP AND FILTER 4 TIMES IN A 2 YEAR TIME SPAN. NOW MY CAR DOES NOT EVEN RUN, AND I REFUSE TO REPLACE THE FUEL PUMP AGAIN WHEN I KNOW IT WONT DO ANYTHING. *TR
REF 2001 KIA RIO. PERPETUAL INTERMITTENT FAILURE OF FUEL PUMP TO OPERATE. FUEL PUMP REPLACED, RELAY REPLACED, AND ECM REPLACED. PUMP WON'T TURN ON AT START UP AND PERIODICALLY, THE PUMP STOPS OPERATING AFTER IT DOES COME ON WHILE DRIVING. NO WARNING. CAUSES SAFETY PROBLEM ON ROAD BY NOT HAVING ANY POWER TO MOVE CAR OFF ROAD…
Read full complaint
REF 2001 KIA RIO. PERPETUAL INTERMITTENT FAILURE OF FUEL PUMP TO OPERATE. FUEL PUMP REPLACED, RELAY REPLACED, AND ECM REPLACED. PUMP WON'T TURN ON AT START UP AND PERIODICALLY, THE PUMP STOPS OPERATING AFTER IT DOES COME ON WHILE DRIVING. NO WARNING. CAUSES SAFETY PROBLEM ON ROAD BY NOT HAVING ANY POWER TO MOVE CAR OFF ROAD. *TR
TL* THE CONTACT OWNS A 2001 KIA RIO. THE CONTACT STATED WAS DRIVING APPROXIMATELY 60 MPH AND ATTEMPTING TO SWITCH LANES WHEN SHE HEARD AN UNUSUAL NOISE SIMILAR TO RUMBLING METAL, FOLLOWED BY A LOUD CLUNK. THE CONTACT WAS BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE YET WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROADWAY. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2001 KIA RIO. THE CONTACT STATED WAS DRIVING APPROXIMATELY 60 MPH AND ATTEMPTING TO SWITCH LANES WHEN SHE HEARD AN UNUSUAL NOISE SIMILAR TO RUMBLING METAL, FOLLOWED BY A LOUD CLUNK. THE CONTACT WAS BARELY ABLE TO MAINTAIN CONTROL OF THE VEHICLE YET WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROADWAY. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE SHE WAS ADVISED THAT THE WHEEL BEARING SPACER WOULD NEED REPLACING. THE DEALER MADE REPAIRS TO THE VEHICLE YET THE FAILURE RECURRED WITHIN SIX MONTHS. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED EIGHT TIMES FOR THE FAILURE SINCE PURCHASE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 81,000.
THIS IS A KIA RIO 4 DR. 2001 ..WITH 12,000 APROX MILES WHEN THE ECU FUSE BROKE, ON HWY 127 NEAR DEATH VALLEY ..HAD TO GET TOWED INTO MY DESTINATION.IT TOOK ABOUT 5 DAYS TO GET A PART FROM CALIF,UPS TO ME FROM A FRIEND, I CHANGED THE FUEL LEVEL SENSOR,,WHICH I THOUGHT WAS THE PROBLEM...THE NEAREST KIA DEALER WAS 80 MILES AWAY IN …
Read full complaint
THIS IS A KIA RIO 4 DR. 2001 ..WITH 12,000 APROX MILES WHEN THE ECU FUSE BROKE, ON HWY 127 NEAR DEATH VALLEY ..HAD TO GET TOWED INTO MY DESTINATION.IT TOOK ABOUT 5 DAYS TO GET A PART FROM CALIF,UPS TO ME FROM A FRIEND, I CHANGED THE FUEL LEVEL SENSOR,,WHICH I THOUGHT WAS THE PROBLEM...THE NEAREST KIA DEALER WAS 80 MILES AWAY IN LAS VEGAS,,,I LATER DISCOVERED THAT IT WAS A BLOWN ECU FUSE..NOT A SENSOR..I THEN DROVE THE CAR APTROX 500 MILES BACK TO CALOIF,WHEN IT BLEW AGAIN ON THE HWY 15 NEAR FONTANA,...I TOOK THE CAR TO KIA DEALER IN ONTARIO CALIF, THEY ONLY DID 2 WARRANTY ITEMS ON THE CAR.#1 WAS AN UPGRADE OF THE ECM.AND #2 REPLACED A FUEL DIST SENSOR////THE DEALER SAID IT WOULD FIX THE FUSE ISSUE,,,WHICH I TOLD THEM UP FRONT. THEY RETURNED THE CAR I WAS GOING BACK TO NEVADA IT BLEW A FUSE ECU ON HWY 15 HAD IT TOWED HOME AGAIN,,,,THE DEALER PICKED UP THE CAR FROM RIALTO 10 MILES AWAY FROM MY PARENTS....THEY HAD THE CAR 4 DAYS AND TOLD ME IT WOULD TAKE APROX 600$ TO GET UNDER THE DASH WHERE THEY BELIEVE THERE IS A SHORT THAT IS CAUSING THIS ECU TO BLOW,,I HAD THE CAR RETURNED ON MY AAA AGAIN TOOK IT FOR A SECOND OPINION,,,AGAIN THEY ALSO SAID IT COULD BE UNDER THE DASH AND THE AMOUNT THEY WANTED TO FIX IT AND KEEP THE CAR FOR ABOUT 3 OR 4 DAYS TO MAKE SURE THE PROBLEM WAS FIXED. THE DEALER NEVER TEST DROVE THE CAR AFTER THE WARRANTY WORK..AS PER THE INVOICE MILEAGE IN AND MILEAGE OUT...THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM...AGAIN...AFTER THE 2ND OPINION..I HAD TO TOW IT AGAIN WHEN I WAS DRIVING IT HOME ON THE STREETS..THAT WAS 55 MILES FROM MY PARENTS HOUSE... I HAVE ALL THE AAA RECORDS ON TOWING ...I'M OUT OF TOWS... THIS CAR COULD CAUSE AN ACCIDENT ....ONLY BECAUSE THE CAR WILL STOP RUNNING WITH OUT ANY NOTICE AND SO FAR I WAS LUCKY THAT NOTHING WENT WRONG. *TR
Official recalls
305V159000 · Wheels
Apr 20, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE A MANUFACTURING FLAW THAT COULD CAUSE THE WHEELS TO CRACK UNDER LONG TERM DRIVING FATIGUE. IF CRACKS OCCUR, WHEEL NOISE AND VIBRATION WILL RESULT AND BECOME PROGRESSIVELY WORSE OVER TIME.
Consequence & remedy
Consequence: IF THE CRACK IS SEVERE, THE WHEEL COULD SEPARATE FROM THE VEHICLE AND POSSIBLY RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.
Remedy: DEALERS WILL REPLACE ALL FOUR WHEELS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
04V179000 · Fuel System, Gasoline:delivery
Apr 9, 2004
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
03V352000 · Fuel System, Gasoline
Sep 24, 2003
ON CERTAIN PASSENGER VEHICLES, FUEL LEAKS MAY DEVELOP AT THE FUEL DISTRIBUTOR ASSEMBLY BECAUSE OF QUALITY DEVIATIONS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE FUEL DISTRIBUTOR AND FUEL CONNECTOR ASSEMBLIES. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING THE FIRST QUARTER OF 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04020 · Steel Wheel Fracture
Opened Jul 22, 2004 · Closed Apr 28, 2005
Status: closed (inferred from source dates) · Wheels; Wheels:hubcap/cover
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-030) TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED FROM MAY 12 THROUGH OCTOBER 17, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 40 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE, 6 OF WHICH ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.AS OF MARCH 31, 2005, KIA MOTORS AMERICA, INC. (KIA) HAS PAID 535 WARRANTY CLAIMS FOR THE REPLACEMENT OF ONE OR MORE WHEELS ON THE SUBJECT VEHICLES DUE TO FRACTURE.BY LETTER DATED APRIL 18, 2005, KIA HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-159) TO REPLACE DEFECTIVE WHEELS IN APPROXIMATELY 24,119 SUBJECT VEHICLES.KIA WILL REPLACE ALL FOUR STEEL WHEELS FREE OF CHARGE.THE ACTION TAKEN BY KIA IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Wheels:hubcap/cover
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-030) TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED FROM MAY 12 THROUGH OCTOBER 17, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 40 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE, 6 OF WHICH ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.AS OF MARCH 31, 2005, KIA MOTORS AMERICA, INC. (KIA) HAS PAID 535 WARRANTY CLAIMS FOR THE REPLACEMENT OF ONE OR MORE WHEELS ON THE SUBJECT VEHICLES DUE TO FRACTURE.BY LETTER DATED APRIL 18, 2005, KIA HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-159) TO REPLACE DEFECTIVE WHEELS IN APPROXIMATELY 24,119 SUBJECT VEHICLES.KIA WILL REPLACE ALL FOUR STEEL WHEELS FREE OF CHARGE.THE ACTION TAKEN BY KIA IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Wheels
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-030) TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED FROM MAY 12 THROUGH OCTOBER 17, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 40 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE, 6 OF WHICH ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.AS OF MARCH 31, 2005, KIA MOTORS AMERICA, INC. (KIA) HAS PAID 535 WARRANTY CLAIMS FOR THE REPLACEMENT OF ONE OR MORE WHEELS ON THE SUBJECT VEHICLES DUE TO FRACTURE.BY LETTER DATED APRIL 18, 2005, KIA HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NTHSA RECALL NO. 05V-159) TO REPLACE DEFECTIVE WHEELS IN APPROXIMATELY 24,119 SUBJECT VEHICLES.KIA WILL REPLACE ALL FOUR STEEL WHEELS FREE OF CHARGE.THE ACTION TAKEN BY KIA IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04030 · Steel Wheel Fracture
Opened Mar 24, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Wheels; Wheels:hubcap/cover
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED BETWEEN MAY 12 AND OCTOBER 18, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 30 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE AND 3 ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.KIA HAS PAID 576 WARRANTY CLAIMS FOR WHEEL REPLACEMENT ON THE SUBJECT VEHICLES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-020) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Additional source detail variants (2)
Wheels:hubcap/cover
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED BETWEEN MAY 12 AND OCTOBER 18, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 30 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE AND 3 ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.KIA HAS PAID 576 WARRANTY CLAIMS FOR WHEEL REPLACEMENT ON THE SUBJECT VEHICLES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-020) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Wheels
ON MARCH 24, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STEEL WHEEL FRACTURES IN CERTAIN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE SUBJECT VEHICLES ARE EQUIPPED WITH WHEELS MANUFACTURED BETWEEN MAY 12 AND OCTOBER 18, 2000.WHEELS WERE MANUFACTURED DURING THIS PERIOD USING A TOOL (RING DIE) THAT HAD IMPROPER SURFACE TREATMENT.THIS ALLOWED TOOL DAMAGE TO DEVELOP WITH ACCUMULATED USE AND RESULTED IN AN IRREGULAR SHAPED STAMPING ON THE WHEEL DISC AT THE HAT AREA.THE IRREGULAR SHAPED HAT AREA CREATES A STRESS RISER THAT MAY LEAD TO THE FORMATION OF CRACKS.ODI IS AWARE OF 30 NON-DUPLICATIVE CONSUMER REPORTS ALLEGING WHEEL FRACTURE AND 3 ALLEGED WHEEL SEPARATION INCIDENTS ON THE SUBJECT VEHICLES.KIA HAS PAID 576 WARRANTY CLAIMS FOR WHEEL REPLACEMENT ON THE SUBJECT VEHICLES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-020) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
EA03015 · Fuel Rail Leakage
Opened Aug 28, 2003 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (10)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:delivery
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:delivery
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:fuel Injection System
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:fuel Injection System
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
ON APRIL 15, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-016) TO INVESTIGATE ENGINE COMPARTMENT FIRES DUE TO ALLEGED FUEL SYSTEM LEAKS IN MODEL YEAR (MY) 2001 KIA RIO VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON AUGUST 28, 2003.ON SEPTEMBER 22, 2003, THE MANUFACTURER NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (03V-352) TO INSPECT THE SUBJECT VEHICLES FOR FUEL LEAKS.AN INFORMATION REQUEST (IR) LETTER WAS SUBMITTED TO THE MANUFACTURER ON NOVEMBER 17, 2003 TO OBTAIN ADDITIONAL INFORMATION SO THAT THE OFFICE COULD EVALUATE THE DEFECT AS REPORTED BY KIA.THE IR LETTER ALSO ADDRESSED OTHER KIA VEHICLES NOT SUBJECT TO THIS INVESTIGATION THAT USE FUEL DELIVERY SYSTEM COMPONENTS IDENTICAL TO THE SUBJECT VEHICLES BUT WERE NOT INCLUDED IN RECALL 03V-352.KIA?S SEPTEMBER 22, 2003 DEFECT NOTIFICATION LETTER IDENTIFIED QUALITY DEVIATIONS IN THE SUBJECT COMPONENTS THAT COULD RESULT IN FUEL LEAKAGE.DURING MY 2001 PRODUCTION, THE SUPPLIER OF THE FUEL RAIL (FUEL DISTRIBUTOR ASSEMBLY) IDENTIFIED QUALITY ISSUES THAT AFFECTED THE INTEGRITY OF PLASTIC WELDS AT THE SERVICE PORT AND/OR FUEL INTAKE NIPPLE.FUEL LEAKAGE COULD ALSO OCCUR IF THE BRASS SERVICE PORT (SCHRADER) VALVE WAS NOT PROPERLY INSTALLED INTO THE VALVE RECEPTACLE.THE SUPPLIER ADOPTED CHANGES TO REMEDY THE PROBLEM AND INSTITUTED A 100% INSPECTION PROCEDURE.SUBSEQUENT TO THIS INVESTIGATION, KIA ALSO CONDUCTED PERFORMANCE TESTING AND ANALYSIS OF WARRANTY AND COMPLAINT DATA.KIA DETERMINED THAT THE FUEL RAIL IS SUBJECT TO FRACTURE AT THE INTAKE NIPPLE DURING THE ASSEMBLY PROCESS OR VEHICLE SERVICING.DAMAGE MAY OCCUR WHEN THE FLEXIBLE FUEL LINE (MAIN FUEL TUBE ASSEMBLY) QUICK CONNECT COUPLING IS IMPROPERLY ATTACHED OR REMOVED FROM THE FUEL RAIL, OR WHEN EXCESSIVE FORCE IS OTHERWISE APPLIED.ODI IS AWARE OF 9 NON-DUPLICATE, NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY FUEL SYSTEM LEAKS AND AN ADDITIONAL 14 FIRES OF UNKNOWN CAUSE THAT MAY BE RELATED TO THE DEFECT IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE 6 FIRES IN MY 2002 AND 3 FIRES IN MY 2003 RIO/RIO CINCO VEHICLES THAT MAY BE RELATED TO THE DEFECT.TO REDUCE THE POSSIBILITY OF FUEL RAIL DAMAGE, KIA HAS REDESIGNED THE FUEL RAIL TO INCLUDE A STEEL INTAKE NIPPLE, AND THE ATTACHING FUEL LINE QUICK CONNECT COUPLING HAS BEEN CHANGED TO FACILITATE EASIER SERVICING.ON APRIL 7, 2004, KIA NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A SAFETY RECALL (04V-179) TO REPLACE THESE TWO COMPONENTS FREE OF CHARGE FOR OWNERS OF ALL MY 2001-2004 KIA RIO AND RIO CINCO VEHICLES PRODUCED FROM MAY 4, 2000 THROUGH MARCH 31, 2004.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03016 · Engine Compartment Fires
Opened Apr 15, 2003 · Closed Aug 28, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Additional source detail variants (6)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Fuel System, Gasoline:delivery
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Fuel System, Gasoline:fuel Injection System:injectors
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Fuel System, Gasoline:fuel Injection System
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
Fuel System, Gasoline
KIA HAS IDENTIFIED 22 NON-CRASH ENGINE COMPARTMENT FIRES OF ANY OR UNSPECIFIED CAUSE ON THE SUBJECT VEHICLES.NINE FIRES (OF WHICH 4 WERE ALSO REPORTED TO ODI) ARE IDENTIFIED AS BEING DUE TO A FUEL SYSTEM LEAK ORIGINATING BETWEEN THE FIREWALL AND THE FUEL INJECTOR RAIL (P/N 0K30E 13 150) IN THE PASSENGER SIDE AREA OF THE ENGINE COMPARTMENT.THE REMAINING FIRES WERE DUE TO VARIED OR UNKNOWN CAUSES.ALL 9 FIRES CAUSED BY A FUEL SYSTEM LEAK SUSTAINED SEVERE AND TOTAL DAMAGE.ANALYSIS INDICATES THAT 1 FIRE WAS CAUSED BY A FAILED QUICK CONNECT BETWEEN THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE (P/N 0K32A 13 49XB) AND THE RIGID LINE MOUNTED TO THE FIREWALL; 5 FIRES WERE CAUSED BY A FAILURE OF THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE ITSELF OR ITS RELATED CONNECTORS; THE REMAINING 3 FIRES WERE CAUSED BY UNSPECIFIED FUEL LEAKS IN THE VICINITY OF THE FUEL INJECTOR RAIL, FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE, AND THE RIGID LINE MOUNTED TO THE FIREWALL.KIA REPORTS THAT NEITHER THE FUEL INJECTOR RAIL NOR THE FLEXIBLE HIGH-PRESSURE FUEL SUPPLY LINE HAS BEEN SUBSTANTIALLY MODIFIED SINCE THEIR INTRODUCTION IN THE 2001 MODEL YEAR.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-015) SO THAT ODI MAY COLLECT ADDITIONAL INFORMATION AND CONDUCT FURTHER STUDY OF THIS ISSUE.
EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT
PE02022 · Air Bag NON-DEPLOYMENT Frontal Crash
Opened Feb 12, 2002 · Closed Jul 2, 2002
Status: closed (inferred from source dates) · Air Bags
IN ADDITION TO THE DECEMBER 2001 FATAL CRASH REPORTED TO ODI THAT PROVIDED THE BASIS FOR OPENING PE02-022, KIA PROVIDED ODI 29 ADDITIONAL REPORTS OF ALLEGATIONS OF NON-DEPLOYMENT OF THE AIR BAG IN A CRASH.NO ADDITIONAL FATAL CRASHES ARE REPORTED.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO CONDUCT FURTHER ANALYSIS OF THE SUBJECT VEHICLE'S AIR BAG SYSTEM.