Engine And Engine Cooling. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports2 fire reports4 injury reports

What owners actually said

74 reports

Mileage unknown · Sep 30, 2003

Engine And Engine CoolingPower Train

WHILE DRIVING VEHICLE WOULD RUN HOT. DEALER HAS REPLACED THE ENGINE ONCE, AND REPLACED AUTOMATIC TRANSMISSION TWICE. HOWEVER, PROBLEM CONTINUED. DEALER HAD NOT FOUND A SOLUTION FOR THE PROBLEM. *AK

NHTSA ODI #10042018

Mileage unknown · Sep 25, 2003

Engine And Engine Cooling

IN COLD WEATHER THE VEHICLE WAS VERY DIFFICULT TO START. ANYTIME THE VEHICLE WAS LEFT TO WARM UP IT WOULD STALL OUT. THE VEHICLE HAS NOT BEEN TO THE DEALER. *NLM

NHTSA ODI #10040583

1,300 miles · Sep 24, 2003

Electrical System

VEHICLE WILL NOT START INTERMITTENTLY WHEN THE KEY IS INSERTED. DEALER IS AWARE OF THE PROBLEM, AND STATES THAT HE DOES NOT KNOW HOW TO FIX IT. MANUFACTURER WILL BE NOTIFIED OF THE PROBLEM SOON.*AK

NHTSA ODI #10040531

150 miles · Sep 24, 2003

Fuel System, Gasoline

AFTER TWO VISITS TO THE DEALER'S SERVICE SHOP, I FOUND OUT THAT 03 KIA RIOS HAVE A PROBLEM WITH THE ENGINE CONTROL MODULES. AS SOON AS THE WEATHER IS COOL, IT PREVENTS THE ENGINE FROM GETTING ENOUGH GAS. THE CAR WON'T START COLD UNTIL IT'S BEEN CRANKED FOR ABOUT 10 MINUTES, AND ONCE YOU GET IT STARTED, THE CAR WILL CUT OUT FRO…

Read full complaint

NHTSA ODI #10039468

36 miles · Jul 24, 2003

Seat Belts

Read full complaint

THE CHILD SAFETY RESTRAINT SEAT BELT SYSTEM IN THE REAR SEATS OF OUR NEW KIA RIO CINCO DOES NOT WORK. THE DEALERSHIP WAS NOTIFIED, NEW PARTS INSTALLED AND THE PROBLEM PERSISTED. THE KIA REPRESENTATIVE HAS DECLARED NO PROBLEMS ARE PRESENT. HOWEVER, THE SEAT BELT WILL NOT LOCK DOWN TO INSTALL A CHILD SAFETY SEAT. THE LOCKING MECHANISM RELEASES TO EARLY. THE REPRESENTATIVE STATED THAT THE SEATBELT SHOULD LOCK ON IMPACT. THIS IS NOT SAFE FOR INSTALLATION OF A CHILD SEAT.*AK

NHTSA ODI #10029113

Mileage unknown · Jul 22, 2003

Electrical System

WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE VEHICLE SHUT DOWN AND WILL NOT RESTART. PLEASE FILL IN ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM.

NHTSA ODI #10029901

Mileage unknown · Jul 17, 2003

Power TrainSeat Belts

BOUGHT 2003 KIA ON 11/16/02 EIGHT MON. AGO,SEATBELT LOCK CAME OFF,TRIMMING AROUND DOORS AND WINDOWS CAME OFF,NOW DRIVINGG INTO THE INTERSTATE CAR CUT OFF,TRANSMISSION VERY SLOW IN SHIFTING GEARS.*AK

NHTSA ODI #10028504

1,000 miles · Jun 16, 2003

Electrical System

Read full complaint

I BOUGHT MY KIA RIO 2003 FEBRUARY 8, 2003. THE PROBLEMS STARTED ON MAY 15, 2003 MY CAR CUT OFF WHILE DRIVING TO WORK, AS I TRIED TO START THE CAR BACK UP IT TOOK 3 TO 4 TIMES TO GET IT TO FINALLY START. I TOOK IT IN 3 TIMES TO BE SERVICED AND THEY EITHER TELL ME THAT THEY DIDN'T FIND ANYTHING WRONG WITH IT, OR THEY TELL ME TO USE A DIFFERENT TYPE OF GAS IN MY CAR AND A DIFFERENT GRADE. THE MAINTENANCE DEPARTMENT SAID THAT KIA INC. SAYS IT HAD SOMETHING TO DO WITH THE MIDWEST FUEL, YET WHEN I WENT TO THE SERVICE DESK TWO OTHER PEOPLE WERE BEING SERVICED FOR THE SAME EXACT PROBLEM. THE MAINTENANCE CREW ADMITTED AFTER THE SECOND TIME THAT THEY DON'T KNOW WHY IT IS CUTTING OFF, AND THAT IT IS BECOMING A COMMON PROBLEM FOR THE 2003 KIA RIO. ALL THE TIMES I'VE BEEN SERVICED AT KIA NOTHING HAS BEEN DONE, THEY TELL ME THEY DROVE MY CAR "X" AMOUNT OF MILES YET THEY FIND NO PROBLEM WITH IT, ALTHOUGH WHEN I DRIVE IT EITHER IT CUTS OFF WHILE DRIVING, HAS A HARD START, OR THE BRAKES SQUEAKS LOUDLY WHEN I COME TO A STOP. I TOLD THEM ABOUT THE BRAKES AND THEY TOLD ME ITS NORMAL FOR A NEW CAR, YET IT SEEMS TO GET LOUDER AND LOUDER. MY CAR WAS HARD AT TRYING TO START TODAY, AND IT CUT OFF AGAIN AT THE TOLLWAY BOOTH, I WILL BE TAKING IT BACK TO MATTESON KIA AUTO MART TOMORROW JUNE 16, 2003 AND THIS WILL BE THE FOURTH TIME FOR THE SAME PROBLEMS THAT HAS NOT BEEN RESOLVED. *NLM

NHTSA ODI #10023113

1,000 miles · Jun 16, 2003

Electrical System

Read full complaint

NHTSA ODI #10023112

6,000 miles · Jun 11, 2003

Electrical System

ELECTRICAL SYSTEM. *AK

NHTSA ODI #10021426

Official recalls

06V294000 · Seat Belts:rear/other

Aug 4, 2006

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.

Consequence & remedy

Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.

05V557000 · Child Seat

Dec 12, 2005

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.

Consequence & remedy

Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.

04V179000 · Fuel System, Gasoline:delivery

Apr 9, 2004

ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA02009 · Air Bag Non Deploy

Opened Jul 2, 2002 · Closed Jul 2, 2003

Status: closed (inferred from source dates) · Air Bags

THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT