TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STARTED SHAKING VIOLENTLY AND THEN CRASHED INTO THE SIDE OF THE RAMP. WHEN THE CONTACT EMERGED FROM THE VEHICLE, SHE NOTICED THE REAR PASSENGER TIRE FRACTURED COMPLETELY FROM THE SUSPENSION SYSTEM. THERE WERE NO INJURIES AND THE POLICE…
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STARTED SHAKING VIOLENTLY AND THEN CRASHED INTO THE SIDE OF THE RAMP. WHEN THE CONTACT EMERGED FROM THE VEHICLE, SHE NOTICED THE REAR PASSENGER TIRE FRACTURED COMPLETELY FROM THE SUSPENSION SYSTEM. THERE WERE NO INJURIES AND THE POLICE WERE NOTIFIED. A REPORT WAS AVAILABLE IF NEEDED. THE VEHICLE WAS TOWED TO AN AUTO MECHANIC SHOP AND THE INSURANCE COMPANY WAS ALSO NOTIFIED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 85,400.
NHTSA ODI #10454667
Mileage unknown · Oct 17, 2006
Suspension
MY BACK PASSENGER SIDE WHEEL BEARING HAS GONE BAD THREE TIMES WITH A YEAR'S TIME. THE LAST BEARING WAS REPLACED IN SEPTEMBER 06, AND THE SAME BEARING IS GOING BAD AGAIN (CURRENTLY MID OCTOBER). *NM
NHTSA ODI #10171094
16,000 miles · Apr 14, 2005
Electrical SystemFuel System, GasolineSuspension
MY 2003 KIA RIO HAS DIED OUT ON ME ABOUT SIX TIMES SO FAR. I HAVE BROUGHT IT INTO THE DEALER EACH TIME, NOW AND THEY HAVE SAID THAT THEY COULD NOT DUPLICATE THE PROBLEM OR FIND A PROBLEM. THEY HAVE REPLACED A THROTTLE POSITION SENSOR HOWEVER, THAT DID NOT HELP. MY CAR DOESN'T DIE OUT ALL THE TIME ONLY ONCE IN AWHILE. IT HAS …
Read full complaint
MY 2003 KIA RIO HAS DIED OUT ON ME ABOUT SIX TIMES SO FAR. I HAVE BROUGHT IT INTO THE DEALER EACH TIME, NOW AND THEY HAVE SAID THAT THEY COULD NOT DUPLICATE THE PROBLEM OR FIND A PROBLEM. THEY HAVE REPLACED A THROTTLE POSITION SENSOR HOWEVER, THAT DID NOT HELP. MY CAR DOESN'T DIE OUT ALL THE TIME ONLY ONCE IN AWHILE. IT HAS DIED OUT WHILE REVERSING, DRIVING ON THE HIGHWAY, WAITING AT A STOPLIGHT. I HAVE PURSUED LEMON LAW IN HAWAII AND AM WAITING FOR THE DECISION OF THE ARBITRATOR. AT HEARING, MANUFACTURER KNEW OF STALLING DEFECT HOWEVER, HE SAID IT DID NOT APPLY TO MY VIN NUMBER. I HAVE ALSO HAD PROBLEMS WITH THE SHOCKS ON MY VEHICLE, THEY DO NOT ABSORB MUCH AND MAKE NOISE WHEN I GO ON A BUMPY ROAD. MY CAR ALSO MAKES A LARGE WHISTLING SOUND WHEN DRIVING OVER 50 MPH BUT IT ONLY OCCURS SOMETIMES.*AK
NHTSA ODI #10117892
250 miles · Oct 8, 2003
Engine And Engine CoolingSuspension
WHILE DRIVING 35 MPH STEERING WHEEL WOULD PULL TO THE RIGHT, AND A LOUD NOISE WOULD BE COMING FROM THE STEERING WHEEL. ALSO, VEHICLE WOULD STALL FOR NO REASON WHILE DRIVING. DRIVER WOULD MAINTAIN CONTROL AND PULL TO THE SIDE OF ROAD. HAD VEHICLE TOWED TO DEALERSHIP, AND MECHANIC COULD MOT DETERMINE THE CAUSE OF EITHER PROBLEM…
Read full complaint
WHILE DRIVING 35 MPH STEERING WHEEL WOULD PULL TO THE RIGHT, AND A LOUD NOISE WOULD BE COMING FROM THE STEERING WHEEL. ALSO, VEHICLE WOULD STALL FOR NO REASON WHILE DRIVING. DRIVER WOULD MAINTAIN CONTROL AND PULL TO THE SIDE OF ROAD. HAD VEHICLE TOWED TO DEALERSHIP, AND MECHANIC COULD MOT DETERMINE THE CAUSE OF EITHER PROBLEM.*AK
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.
Consequence & remedy
Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT
2003 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration