IllustrationINCIDENT MILEAGE ON MY REPORT IS DUE TO BUYING THE VEHICLE USED, BUT HAS MOST LIKELY OCCURRED SINCE DATE OF ORIGINAL PURCHASE. DUE TO AN BAD CHECK VALVE IN THE FUEL TANK, OVERFILLING OCCURS AT ALMOST EVERY FILL-UP, CREATING BOTH ENVIRONMENTAL CONCERNS AND POTENTIAL HAZARDOUS CONDITIONS. *TR
2005 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2005 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1010–25K
16425–50K
15650–75K
6775–100K
33100–150K
12150K+
533 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 346 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports9 fire reports10 injury reports
What owners actually said
650 reportsWHEN TRYING TO PUT GAS INTO TANK THE GAS OVERFLOWS OUT THE FILL TUBE. *TR
EVERY TIME YOU FILL THE FUEL TANK, FUEL SPILL'S OUT ON THE SIDE OF THE VEHICLE AND ON THE GROUND CAUSING A VERY DANGEROUS FIRE PROBABILITY. *TR
2005 JEEP WRANGLER. WELL MAINTAINED. HIGHEST QUALITY OIL, SPARK PLUGS, AIR FILTERS, COOLING SYSTEM. CAMSHAFT FAILURE AT ROUGHLY 50,000 MILES. EXCESSIVE WEAR CAUSING KNOCKING. DIAGNOSIS FROM CHRYSLER: NEW ENGINE REQUIRED. NO OVERHEATING, NO ABUSE. THE OIL PUMP DRIVE ASSEMBLY GEARS ARE WORN DOWN SO OIL IS NOT FLOWING PROPERLY. THI…
Read full complaint
2005 JEEP WRANGLER. WELL MAINTAINED. HIGHEST QUALITY OIL, SPARK PLUGS, AIR FILTERS, COOLING SYSTEM. CAMSHAFT FAILURE AT ROUGHLY 50,000 MILES. EXCESSIVE WEAR CAUSING KNOCKING. DIAGNOSIS FROM CHRYSLER: NEW ENGINE REQUIRED. NO OVERHEATING, NO ABUSE. THE OIL PUMP DRIVE ASSEMBLY GEARS ARE WORN DOWN SO OIL IS NOT FLOWING PROPERLY. THIS IS A POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE. THE OTHER POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE IS THAT IT IS A FLAT TAPPET CAMSHAFT FROM THE FACTORY. THIS SPECIFIC TYPE OF CAMSHAFT NEEDS THE ZDDP OIL ADDITIVE. MODERN OIL DOES NOT CONTAIN ZDDP BECAUSE IT CAUSES CATALYTIC CONVERTER FAILURE. WITHOUT ZDDP EXCESSIVE WEAR OCCURS. THIS IS COVERED IN SAE BULLETIN # 770087. SAE IS THE SOCIETY OF AUTOMOTIVE ENGINEERS. ONCE WEAR REACHES A CERTAIN LEVEL FURTHER WEAR IS RAPID AND CAUSES CATASTROPHIC ENGINE FAILURE.FURTHERMORE, MY JEEP IS STILL UNDER POWERTRAIN WARRANTY. HOWEVER, MY WARRANTY HAS BEEN UNLAWFULLY DENIED BECAUSE I HAVE SOME UNRELATED AFTERMARKET PARTS ON MY JEEP. LITIGATION IS PENDING ON THIS ISSUE. CHRYSLER HAS GONE AGAINST THEIR OWN WRITTEN WARRANTY, AND WELL AS FEDERAL LAW (MAGNUSON-MOSS WARRANTY ACT). *TR
WHEN FILLING UP GAS TANK, GAS WILL SPILL OUT FOR FILL SPOUT BEFORE THE GAS NOSSEL SHUTS OFF. *TR
GAS SPILLS OUT WHENEVER I FUEL-UP. *TR
FUEL OVERFLOWS AND SPILLS ALL OVER THE EXTERIOR, GROUND AND SOMETIMES MY SHOES EVERY TIME I FILL MY GAS TANK. I KNOW THIS IS AN EXTREMELY COMMON ISSUE, AND AM HOPING FOR A RECALL. THANKS!!! *TR
WHEN I FILL MY 05 WRANGLER IT OVERFLOWS BEFORE PUMP SHUTS OFF,THIS HAPPENS EVERYTIME I FILL UP. *TR
GAS TANK SPILLS EVERY TIME I FILL IT UP. SQUIRTS OUT AND ONTO MY CLOTHES, GROUND, PAINT JOB AND FENDER. ME AND MANY OTHERS ARE HAVING THIS PROBLEM. RECALL!!!! *TR
GAS OVER FLOWS AND SOAKED MY PANTS. *KB
Official recalls
105V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.