NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
308 reports53,521 miles · May 4, 2018
Vehicle Speed Control
WHILE DRIVING OR STOPPED THE VEHICLE WOULD ACCELERATE TO THE HIGHEST RATE OF SPEED, ON IT'S OWN, AND I HAD TO PUT IT IN NEUTRAL TO STOP AN ACCIDENT FROM HAPPENING. THIS HAPPENED MORE THAN ONCE, ALMOST FATALLY INJURING SEVERAL PEDESTRIANS. WE TOOK IT TO THE DEALER FOR REPAIR AND IT WAS SO UNSAFE DUE TO THE ACCELERATION PROBLEM T…
Read full complaint
WHILE DRIVING OR STOPPED THE VEHICLE WOULD ACCELERATE TO THE HIGHEST RATE OF SPEED, ON IT'S OWN, AND I HAD TO PUT IT IN NEUTRAL TO STOP AN ACCIDENT FROM HAPPENING. THIS HAPPENED MORE THAN ONCE, ALMOST FATALLY INJURING SEVERAL PEDESTRIANS. WE TOOK IT TO THE DEALER FOR REPAIR AND IT WAS SO UNSAFE DUE TO THE ACCELERATION PROBLEM THEY WOULDN'T EVEN DRIVE IT ! I HAD TO HAVE IT TOWED BACK AND FORTH TO THE DEALER TWICE BEFORE THEY COULD EVEN FIGURE OUT WHAT THE PROBLEM WAS. NOW THEY ARE SAYING IT IS THE THROTTLE BODY ASSEMBLY. $1,753.11 FOR A VEHICLE THAT WAS GARAGED AND ONLY DRIVEN IN THE WINTER. 53,567 MILES ON IT. FOR A PART THAT REGULATES YOUR SPEED? THIS IS NOT THE FIRST TIME THIS IS REPORTED - THERE WAS A CASE IN JAPAN WHERE PEOPLE ACTUALLY DIED - AFTER GOING TO COURT THEY SAID IT WAS DRIVER ERROR - STEPPING ON THE GAS INSTEAD OF THE BRAKE. I HIGHLY DOUBT IT NOW - THERE ARE MANY MORE CASES AND REPAIRS LIKE THIS ONE - SOMEONE NEEDS TO DO A LITTLE RESEARCH. I FOR ONE WOULD LIKE A LITTLE HELP - I'M 73 YEARS OLD AND BOUGHT THIS CAR NEW - IT'S ALWAYS BEEN TAKEN CARE OF - THE DEALER HAS THE RECORDS.
NHTSA ODI #11091695
Mileage unknown · Apr 15, 2018
SteeringStructure
I WAS DRIVING AN I CAME YO A STOP AN BEGAN TO TURN UP A SIDE BLOCK WEN I HEARD SOMETHING LIKE IT WAS METAL IN MERSL SCRAPPING SO I IMMEDIATELY PULLED OVER AN HAD TO CALL MY MECHANIC TO COME SEE WHAT WAS THAT AWFUL NOISE HE LAYER SHOWD UP LIFTED MY CAR IN THE AIR WHICH HE FOUND A LOT OF CORROSION AN RUST AN MY LOWER ARM CONTROL A…
Read full complaint
I WAS DRIVING AN I CAME YO A STOP AN BEGAN TO TURN UP A SIDE BLOCK WEN I HEARD SOMETHING LIKE IT WAS METAL IN MERSL SCRAPPING SO I IMMEDIATELY PULLED OVER AN HAD TO CALL MY MECHANIC TO COME SEE WHAT WAS THAT AWFUL NOISE HE LAYER SHOWD UP LIFTED MY CAR IN THE AIR WHICH HE FOUND A LOT OF CORROSION AN RUST AN MY LOWER ARM CONTROL AN SUB FRAME NEEDING TO BE REPLACED UNDERNEATH MY CAR THATS WHY MY STEERING WHEEL WAS FREEWHEELING
NHTSA ODI #11085148
Mileage unknown · Feb 6, 2018
StructureSuspensionUnknown Or Other
CAR HAS CLUNKING NOISE IN FRONT END. MECHANIC SAID IT'S THE SUBFRAME BUSHINGS GOING IN AND OUT OF THE SUBFRAME AND RECOMMENDED REPLACING SUBFRAME. SAID CAR IS "UNSAFE TO DRIVE IN THIS CONDITION." THERE IS A RECALL IN "SALT-BELT" STATES. NOT SURE IT THEY CONSIDER UTAH A SALT-BELT STATE, BUT SALT IS USED HERE EXTENSIVELY IN TH…
Read full complaint
CAR HAS CLUNKING NOISE IN FRONT END. MECHANIC SAID IT'S THE SUBFRAME BUSHINGS GOING IN AND OUT OF THE SUBFRAME AND RECOMMENDED REPLACING SUBFRAME. SAID CAR IS "UNSAFE TO DRIVE IN THIS CONDITION." THERE IS A RECALL IN "SALT-BELT" STATES. NOT SURE IT THEY CONSIDER UTAH A SALT-BELT STATE, BUT SALT IS USED HERE EXTENSIVELY IN THE WINTER.
NHTSA ODI #11067165
165,000 miles · Dec 4, 2017
Air BagsStructureWheelsCrashInjury
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF …
Read full complaint
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF THE CAR. THE CAR FLIPPED AND WAS TOTALED. AGAIN, NO AIRBAGS WERE DEPLOYED. I HAVE INCLUDED PICTURES OF THE CAR AFTER THE ACCIDENT. MY MAIN CONCERN IS THE ISSUE WITH THE AIRBAGS. I FEEL AS THOUGH THESE SHOULD HAVE WORKED PROPERLY AND THAT I AM FORTUNATE ENOUGH THAT THE ACCIDENT WAS NOT ANY WORSE, AS MORE SERIOUS INJURIES COULD HAVE THEN OCCURRED. IF NEEDED, I HAVE MORE PICTURES; HOWEVER, DUE TO THE FILE SIZE ALLOWED, I HAVE LIMITED IT TO KEY PICTURE. PLEASE LET ME KNOW.
NHTSA ODI #11052221
165,000 miles · Dec 4, 2017
Air BagsStructureWheelsCrashInjury
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF …
Read full complaint
MY AIRBAGS WERE DEFECTIVE. I WAS IN A CAR ACCIDENT, AND THE AIRBAGS DID NOT DEPLOY. AFTER THE ACCIDENT, I WAS TAKEN TO THE HOSPITAL TO TREAT MULTIPLE BODILY INJURING, WHICH COULD HAVE BEEN PREVENTED IF THE AIRBAG HAD DEPLOYED. I WAS DRIVING IN TOWN WHEN THE ACCIDENT OCCURRED. I OVERSHOT A TURN AND HIT A POLL ON THE LEFT SIDE OF THE CAR. THE CAR FLIPPED AND WAS TOTALED. AGAIN, NO AIRBAGS WERE DEPLOYED. I HAVE INCLUDED PICTURES OF THE CAR AFTER THE ACCIDENT. MY MAIN CONCERN IS THE ISSUE WITH THE AIRBAGS. I FEEL AS THOUGH THESE SHOULD HAVE WORKED PROPERLY AND THAT I AM FORTUNATE ENOUGH THAT THE ACCIDENT WAS NOT ANY WORSE, AS MORE SERIOUS INJURIES COULD HAVE THEN OCCURRED.
NHTSA ODI #11052199
89,000 miles · Apr 7, 2017
Engine
ENGINE DIED MULTIPLE TIMES WHILE IN OPERATION ON A CITY STREET GOING STRAIGHT, APPROXIMATELY 35-40 MILES PER HOUR AND ON HIWAY GOING APPROX. 60 MPH TWICE. WE NO LONGER DRIVE IT ON A HIWAY. REPAIR SHOP CAN'T FIND ANYTHING WRONG.
NHTSA ODI #10971095
145,960 miles · Feb 17, 2017
Air Bags
WAS DRIVING DOWN PENDLETON PIKE GOING SOUTH TURN ON 38TH STREET GOING WEST,THEIR WAS BIG LOUD POP I THOUGH I BLEW A TIRE OVER SEEN THE AIR BAG HAD EXPLODED ON THE PASSENGER SEAT THIS HAPPENED ON 2/13/2017 MY NAME IS [XXX] EMAIL [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). …
Read full complaint
WAS DRIVING DOWN PENDLETON PIKE GOING SOUTH TURN ON 38TH STREET GOING WEST,THEIR WAS BIG LOUD POP I THOUGH I BLEW A TIRE OVER SEEN THE AIR BAG HAD EXPLODED ON THE PASSENGER SEAT THIS HAPPENED ON 2/13/2017 MY NAME IS [XXX] EMAIL [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10955196
2 miles · Feb 15, 2017
Air Bags
ON 2/13 2017 MY AIR BAG ON PASSENGER SIDE DEPLOYED, WHICH ALL AIR NO GOOD. CALL HYN DEALER TOLD ME 2500 DOLLARS TO FIX NO ACCIDENT JUST DRIVING. I THOUGHT I BLUE A TIRE AND IT WAS MY PASSENGER SEAT AIR BAG MY NAME IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10954639
Mileage unknown · Jan 13, 2017
Air BagsElectrical SystemLatches/locks/linkages
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG INDICATOR REMAINED ILLUMINATED IN ADDITION, THE CHILD SAFETY LOCKS FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS NOT NOTIFIED, BUT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE …
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG INDICATOR REMAINED ILLUMINATED IN ADDITION, THE CHILD SAFETY LOCKS FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS NOT NOTIFIED, BUT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT. UPDATED 03/16/17*LJ *CN
NHTSA ODI #10945011
220,000 miles · Jan 4, 2017
Suspension
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT WAS NOT INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). WITHOUT WARNING, THE FRONT COIL SPRING FRACTURED AND THE FRONT PASSENGER SIDE TIRE FAILED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENC…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT WAS NOT INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). WITHOUT WARNING, THE FRONT COIL SPRING FRACTURED AND THE FRONT PASSENGER SIDE TIRE FAILED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS WAITING ON A RESPONSE FROM THE MANUFACTURER TO ADDRESS THE RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.
NHTSA ODI #10939621
Official recalls
4Jul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence & remedy
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Apr 16, 2009
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
Consequence & remedy
Consequence: IF THE CORROSION IS ALLOWED TO PROGRESS, THE REAR TRAILING ARM MAY FRACTURE WHILE DRIVING, THEREBY INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR TRAILING ARMS FOR INTERNAL CORROSION DAMAGE. IF SPECIFIED LEVELS OF CORROSION DAMAGE ARE FOUND, THE REAR TRAILING ARMS WILL BE REPLACED. REAR TRAILING ARMS THAT DO NOT REQUIRE REPLACEMENT WILL HAVE DRAINAGE HOLES ADDED AND WILL BE TREATED WITH RUST-PROOFING MATERIAL TO ARREST THE CORROSION PROCESS. INSPECTION, TREATMENT AND REPLACEMENT PROCEDURES WILL BE CONDUCTED AT NO COST TO OWNERS. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 16, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
Consequence & remedy
Consequence: IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Dec 18, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08023 · Rear Trailing Arm Corrosion Failure
Opened Oct 28, 2008 · Closed Apr 17, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (2)
Suspension
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration