NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
308 reportsMileage unknown · Nov 1, 2024
Service Brakes, Hydraulic
The contact owns a 2003 Hyundai Santa Fe. The contact stated while driving 30 MPH, the ABS system activated, and there was an abnormal shuddering in the brake pedal. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ABS needed to be replaced. The vehicle was not repaired. The man…
Read full complaint
The contact owns a 2003 Hyundai Santa Fe. The contact stated while driving 30 MPH, the ABS system activated, and there was an abnormal shuddering in the brake pedal. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ABS needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA ODI #11623194
Mileage unknown · May 17, 2024
SteeringSuspension
The driver's side rear trailing arm lower broke again. Was driving all of a sudden felt it start fishtailing and pulled over and thank God I didn't crash
NHTSA ODI #11589298
Mileage unknown · Mar 26, 2023
Engine
Bought a set of duralast gold wrists a801116 asks since the day i put them in i had to replace parts whole charging a problem that turned out to be from the wires. Cause it was causing arcing in every one of the cylinders.
NHTSA ODI #11513824
190,000 miles · Jul 26, 2021
Wheels
The contact owns a 2003 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the passenger’s side front wheel detached without warning. The wheel bearing and hub were replaced by the owner. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not contact…
Read full complaint
The contact owns a 2003 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the passenger’s side front wheel detached without warning. The wheel bearing and hub were replaced by the owner. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The manufacturer was not contacted nor informed of the failure. The approximate failure mileage was 190,000.
NHTSA ODI #11426465
147,263 miles · Dec 17, 2020
StructureSuspension
BROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN …
Read full complaint
BROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN THOU MINN. IS RIGHT NEXT DOOR LIKE I LIVE ABOUT 1 MILE TO MN THEY STILL WOULDN'T EXCEPT THE RECALL, IT IS OBVIOUS THE PART THAT IS ON RECALL FITS MY CAR, WHEN LOOKING ON THE RIGHT SIDE ARM THERE IS NO RUST OR CORROSION. THE DEALER STATES IT IS NOT SAFE TO DRIVE VEHICLE, BECAUSE THE ARM IS STARTING TO BEND ALSO. SO WHAT DO I DO NOW, IT WILL BE VERY COSTLY TO FIX,
NHTSA ODI #11383941
142,000 miles · Oct 19, 2020
Structure
THE SUBFRAME IS RUSTED THROUGH. IT WAS GARAGE KEPT AND DOESN'T EVEN HAVE 150,000 MILES ON IT.
NHTSA ODI #11365190
150,000 miles · Jun 12, 2020
WheelsCrash
MY VEHICLE CALLS FOR A SWAY BAR N LINK IT DOES NOT HAVE ONE OR A PLACE TO PUT ONE FOR THE REAR PASSENGER SIDE. WHEN I GO OVER A BUMP IT MAKES A REAL LOUD NOISE. I REPLACED BOTH SHOCKS. NOISE IS STILL THERE. THERE ARE 4 RECALLS ON THIS CAR. RECALL #03V030000, #14V435000,#09V123000,03V520000. IN MOTION *TR
NHTSA ODI #11328527
211,312 miles · Nov 30, 2019
Suspension
REAR TRAILING ARM CORRODED AND BUSTED WHILE IN MOTION. CAUSED REAR END TO COLLAPSE AND FISHTAIL. PASSENGER SIDE SNAPPED, DRIVERS SIDE IS VERY CORRODED. JUST PURCHASED THIS CAR A COUPLE WEEKS AGO, HAD NO IDEA THESE PARTS WERE UNSTABLE.
NHTSA ODI #11283039
100,000 miles · Nov 27, 2019
Suspension
THE REAR END OF MY SANTA FE HAS RUSTED THROUGH AND THE BACK WHEELS WILL NOT TRACK IN A STRAIGHT LINE. HYUNDAI HAD A RECALL NR 09V123000 IN 4/16/2009 TO FIX THIS EXACT PROBLEM BUT ACCORDING TO HYUNDAI CUSTOMER ASSISTANCE, THIS RECALL DOES NOT APPLY TO ME BECAUSE MY SANTA FE WASN'T PURCHASED OR REGISTERED IN A SPECIFIC STATE. MY…
Read full complaint
THE REAR END OF MY SANTA FE HAS RUSTED THROUGH AND THE BACK WHEELS WILL NOT TRACK IN A STRAIGHT LINE. HYUNDAI HAD A RECALL NR 09V123000 IN 4/16/2009 TO FIX THIS EXACT PROBLEM BUT ACCORDING TO HYUNDAI CUSTOMER ASSISTANCE, THIS RECALL DOES NOT APPLY TO ME BECAUSE MY SANTA FE WASN'T PURCHASED OR REGISTERED IN A SPECIFIC STATE. MY GRANDSON WAS DRIVING THE CAR AND NEARLY WRECKED. HYUNDAI WOULDN'T EVEN OFFER A TOW INTO A DEALERSHIP TO INSPECT THE PROBLEM.
NHTSA ODI #11282729
Mileage unknown · Sep 5, 2019
Tires
MICHELIN X RADIAL LT2 P225/70R16 101T TIRES WITH DOT NUMBERS AP4V 003X 2614, AP4V 003X 2714, AP4V 003X 2614,AND AP4V 003X 2114. ALL 4 TIRES INSTALLED 09/04/2014 @ 80,421 MILES. 08/31/2019 ODOMETER AT 97,528 MILES. 17,107 MILES ON 75,000 MILE WARRANTY TIRES. TIRE DRY ROT AND CRACKING FIRST NOTICED IN 2015 AND HAS PROGRESSED TO…
Read full complaint
MICHELIN X RADIAL LT2 P225/70R16 101T TIRES WITH DOT NUMBERS AP4V 003X 2614, AP4V 003X 2714, AP4V 003X 2614,AND AP4V 003X 2114. ALL 4 TIRES INSTALLED 09/04/2014 @ 80,421 MILES. 08/31/2019 ODOMETER AT 97,528 MILES. 17,107 MILES ON 75,000 MILE WARRANTY TIRES. TIRE DRY ROT AND CRACKING FIRST NOTICED IN 2015 AND HAS PROGRESSED TO THE POINT WHERE A TIRE PROFESSIONAL HAS STATED THAT THE TIRES ARE NO LONGER SAFE TO DRIVE WITH ON 08/31/2019. THERE IS A NEED FOR A DETERMINATION ON WHAT SIZE OF SIDEWALL AND TREAD CRACKING THAT WILL CAUSE A SAFETY RISK AND WHEN A MANUFACTURER SHOULD RECALL AND REPLACE FOR THESE DEFECTS. I HAVE TIRES FROM THE SAME MANUFACTURER THAT ARE YEARS OLDER THAT HAVE BEEN EXPOSED TO THE SUN A LOT MORE THAT DO NOT HAVE DRY ROT CRACKING ON THE SIDEWALL OR IN THE TREAD.
NHTSA ODI #11253324
Official recalls
4Jul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence & remedy
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
Apr 16, 2009
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
Consequence & remedy
Consequence: IF THE CORROSION IS ALLOWED TO PROGRESS, THE REAR TRAILING ARM MAY FRACTURE WHILE DRIVING, THEREBY INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR TRAILING ARMS FOR INTERNAL CORROSION DAMAGE. IF SPECIFIED LEVELS OF CORROSION DAMAGE ARE FOUND, THE REAR TRAILING ARMS WILL BE REPLACED. REAR TRAILING ARMS THAT DO NOT REQUIRE REPLACEMENT WILL HAVE DRAINAGE HOLES ADDED AND WILL BE TREATED WITH RUST-PROOFING MATERIAL TO ARREST THE CORROSION PROCESS. INSPECTION, TREATMENT AND REPLACEMENT PROCEDURES WILL BE CONDUCTED AT NO COST TO OWNERS. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
Mar 16, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
Consequence & remedy
Consequence: IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Dec 18, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08023 · Rear Trailing Arm Corrosion Failure
Opened Oct 28, 2008 · Closed Apr 17, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (2)
Suspension
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Illustration