IllustrationRIGHT FRONT LOWER CONTROL ARMS HAS CORROSION DAMAGE SHOWING IN RUSTED BROKEN FRAME. DESCRIPTION IS SIMILAR TO HYUNDAI RECALL NO 091. *TR
2003 Hyundai Santa Fe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Hyundai Santa Fe do not stand out strongly from the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
500–25K
3025–50K
3950–75K
3375–100K
65100–150K
28150K+
245 reports with mileage · 63 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports5 fire reports17 injury reports
What owners actually said
308 reportsI OWN A 2003 SANTA FE AND JUST FOUND OUT ABOUT THE CARRIAGE CORROSION PROBLEMS WITH THE 2001-2003 HYUNDAI AND SUBSEQUENT RECALL IN THE "SNOW BELT" STATES. I LIVE IN KANSAS, WHERE THEY TREAT THE LOCAL HIGHWAYS IN THE WINTER WITH SALT AND OTHER CORROSIVES. WHY ISN'T KANSAS INCLUDED IN THIS RECALL? HAS HYUNDAI INCLUDED VEHICLES I…
Read full complaint
I OWN A 2003 SANTA FE AND JUST FOUND OUT ABOUT THE CARRIAGE CORROSION PROBLEMS WITH THE 2001-2003 HYUNDAI AND SUBSEQUENT RECALL IN THE "SNOW BELT" STATES. I LIVE IN KANSAS, WHERE THEY TREAT THE LOCAL HIGHWAYS IN THE WINTER WITH SALT AND OTHER CORROSIVES. WHY ISN'T KANSAS INCLUDED IN THIS RECALL? HAS HYUNDAI INCLUDED VEHICLES IN THIS STATE FOR THE RECALL? THE LITTLE TRUCK HAS BEEN TERRIFIC, WITH NOTHING GOING WRONG UNTIL NOW. THE GARAGE I TAKE MY VEHICLES TO WOULD NOT ALLOW MY DAUGHTER TO GET BACK INTO THE SANTA FE, FEARING THAT SHE WOULD HAVE AN ACCIDENT. THANK GOODNESS FOR SMALL FAVORS! I WILL GIVE HIS CONTACT INFORMATION UPON RESPONSE FROM YOU. *TR
I WAS DRIVING DOWN THE ROAD GOING ABOUT 40 TO 45 MILES AN HOUR ON A BUSY ROAD. I HAD MY GRANDCHILDREN IN THE CAR WITH ME. THE CAR ALL OF A SUDDEN SHUT OFF ON ME. THANK GOD I HAD ENOUGH MOMENTUM TO PULL OVER ON THE SIDE OF THE ROAD. I COULDN'T GET THE CAR TO START SO I SAT THERE WITH THEM PRAYING I WOULDN'T GET HIT. AFTER A …
Read full complaint
I WAS DRIVING DOWN THE ROAD GOING ABOUT 40 TO 45 MILES AN HOUR ON A BUSY ROAD. I HAD MY GRANDCHILDREN IN THE CAR WITH ME. THE CAR ALL OF A SUDDEN SHUT OFF ON ME. THANK GOD I HAD ENOUGH MOMENTUM TO PULL OVER ON THE SIDE OF THE ROAD. I COULDN'T GET THE CAR TO START SO I SAT THERE WITH THEM PRAYING I WOULDN'T GET HIT. AFTER A WHILE IT STARTED UP AGAIN AND I WENT MAYBE TWO FEET AND IT DIED AGAIN. I WAS ABLE TO ROLL INTO AN EMPTY GARAGE AND I CALLED MY HUSBAND. THERE WAS AN AUTO ZONE NEAR BY SO HE GOT A MACHINE WHICH SAID WHAT WAS WRONG. IT SAID IT WAS THE CRANKSHAFT SENSOR. MY CAR IS NOW BEING FIXED AT A HYUNDAI DEALER. I WENT ON LINE FOR RECALLS AND I FOUND ONE THAT SAID THERE WAS A RECALL ON THEM BUT NOT FOR MY VEHICLE. IF IT WAS ON ONE VEHICLE YEAR WHY WOULDN'T MY YEAR BE COVERED. MY FAMILY COULD HAVE BEEN KILLED BECAUSE OF THE VEHICLE STOPPING ALL OF A SUDDEN ON A MAIN RD. LIKE I WAS ON. WE HAVE KEPT UP WITH ALL THE RECALLS THAT THEY SEND US. *TR
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE REVERSING AT UNKNOWN SPEEDS, THE FRONT DRIVER'S SIDE COIL SPRING FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 105,760.
VERY POOR VISIBILITY WHILE DRIVING AT NIGHT. CAR DEALER ADJUSTED HEADLAMPS. THIS HAD NO EFFECT. THE VEHICLE IN QUESTION IS NOT SAFE TO DRIVE AT NIGHT WITH THIS STYLE HEADLAMP. *JB
THE PASSENGER FROM SUB FRAME BROKE DROPPING THE LOWER CONTROL ARM BENDING THE WHEEL OUT. THIS WAS AT BIG O TIRES CHECKING ALIGNMENT. I SEE THERE WAS A CLASS ACTION LAW SUIT ON THIS MATTER COVERING 2001-2003 SANTAFE'S. THE FRONT SUB FRAME MUST BE REPLACED. *TR
FUELING CAR TAKES AN INORDINATE AMOUNT OF TIME. IT IS AS IF THERE IS A BLOCKAGE IN THE TANK FILLER PIPE. ACCORDING TO THE DEALER THIS IS CAUSED BY AN AGING CHARCOAL FILTER WITHIN THE FUEL SYSTEM. THE DEALER IS AWARE OF THE PROBLEM BUT HAS NO EXPLANATION, NOR SUGGESTIONS FOR A FIX. *TR
2003 HYUNDAI SANTE FE GLS - DROVE THROUGH A 2 INCH DEEP PUDDLE. LOST POWER STEERING, BATTERY LIGHT AND BRAKE LIGHT FLASHED THEN A RUBBER BURNING SMELL STARTED. DROVE THE CAR FOR TWO ADDITIONAL DAYS AFTER THE REPAIR SHOP COULDN'T FIND ANYTHING. THEN DRIVING HOME FROM WORK, AIRBAG LIGHT TURNED ON, BRAKE LIGHT TURNED ON BATTERY …
Read full complaint
2003 HYUNDAI SANTE FE GLS - DROVE THROUGH A 2 INCH DEEP PUDDLE. LOST POWER STEERING, BATTERY LIGHT AND BRAKE LIGHT FLASHED THEN A RUBBER BURNING SMELL STARTED. DROVE THE CAR FOR TWO ADDITIONAL DAYS AFTER THE REPAIR SHOP COULDN'T FIND ANYTHING. THEN DRIVING HOME FROM WORK, AIRBAG LIGHT TURNED ON, BRAKE LIGHT TURNED ON BATTERY LIGHT TURNED ON, ALL ANALOG INSTRUMENTS FAILED, TACH FAILED, BRAKING BECAME INCONSISTENT AND ENGINE STARTED MISSING. I DROVE DIRECTLY TO REPAIR SHOP, AS I MADE MY FINAL TURN INTO THE REPAIR SHOP THE POWER STEERING FAILED THEN THE CAR SHUTOFF. EARLY REPORT FROM MECHANIC IS A FAILED ALTERNATOR - MY THIRD ONE IN THE LAST YEAR. I THINK I HAVE A LARGER ELECTRICAL PROBLEM WITH THE CAR, FANS FLUCTUATE IN SPEED FOR THE PAST COUPLE OF YEARS AND EVERY TIME IT RAINS I GET FLASHING BRAKE AND BATTERY LIGHTS. LOSING THE POWER STEERING TWICE IN THREE DAYS IS A LITTLE UNSETTLING... *TR ## VIN FAILED ##
AT SLOW SPEEDS, WHILE LIGHTLY APPLYING BRAKES, ABS CAUSES CHATTER AND EXTENDS STOPPING DISTANCE. *TR
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS AN OVERPOWERING FUEL SMELL IN THE INTERIOR CABIN. THE CONTACT ALSO STATED THAT THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL TANK AND FUEL LINES WERE RUSTED. THE VEHICLE WAS NOT REPAIRED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT THERE WAS AN OVERPOWERING FUEL SMELL IN THE INTERIOR CABIN. THE CONTACT ALSO STATED THAT THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL TANK AND FUEL LINES WERE RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,350.
Official recalls
414V435000 · Suspension:front:springs:coil Springs
Jul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence & remedy
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
09V123000 · Suspension:rear
Apr 16, 2009
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
Consequence & remedy
Consequence: IF THE CORROSION IS ALLOWED TO PROGRESS, THE REAR TRAILING ARM MAY FRACTURE WHILE DRIVING, THEREBY INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR TRAILING ARMS FOR INTERNAL CORROSION DAMAGE. IF SPECIFIED LEVELS OF CORROSION DAMAGE ARE FOUND, THE REAR TRAILING ARMS WILL BE REPLACED. REAR TRAILING ARMS THAT DO NOT REQUIRE REPLACEMENT WILL HAVE DRAINAGE HOLES ADDED AND WILL BE TREATED WITH RUST-PROOFING MATERIAL TO ARREST THE CORROSION PROCESS. INSPECTION, TREATMENT AND REPLACEMENT PROCEDURES WILL BE CONDUCTED AT NO COST TO OWNERS. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
04V131000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Mar 16, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
Consequence & remedy
Consequence: IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
03V520000 · Equipment:other:labels
Dec 18, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08023 · Rear Trailing Arm Corrosion Failure
Opened Oct 28, 2008 · Closed Apr 17, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (2)
Suspension
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.