IllustrationThe driver's side rear trailing arm lower broke again. Was driving all of a sudden felt it start fishtailing and pulled over and thank God I didn't crash
2003 Hyundai Santa Fe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Hyundai Santa Fe do not stand out strongly from the model-year median of 212.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Santa Fe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
500–25K
3025–50K
3950–75K
3375–100K
65100–150K
28150K+
245 reports with mileage · 63 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports5 fire reports17 injury reports
Suspension complaints
56 reportsBROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN …
Read full complaint
BROUGHT MY VEHICLE IN FOR A ALIGNMENT AND THEY DISCOVERED THE RUSTED AND CORRADIATED REAR LEFT TRAILING CONTROL ARM ON MY 2003 HYUNDAI SANTA FE, I BROUGHT TO DEALERSHIP AFTER THAT TO GET A RECALL AND THE TOLD ME THAT SINCE THE VEHICLE WAS BOUGHT IN ND AND THAT STATE IS NOT INCLUDED IN THE RECALL THEY WILL DECLINE THE WORK, EVEN THOU MINN. IS RIGHT NEXT DOOR LIKE I LIVE ABOUT 1 MILE TO MN THEY STILL WOULDN'T EXCEPT THE RECALL, IT IS OBVIOUS THE PART THAT IS ON RECALL FITS MY CAR, WHEN LOOKING ON THE RIGHT SIDE ARM THERE IS NO RUST OR CORROSION. THE DEALER STATES IT IS NOT SAFE TO DRIVE VEHICLE, BECAUSE THE ARM IS STARTING TO BEND ALSO. SO WHAT DO I DO NOW, IT WILL BE VERY COSTLY TO FIX,
REAR TRAILING ARM CORRODED AND BUSTED WHILE IN MOTION. CAUSED REAR END TO COLLAPSE AND FISHTAIL. PASSENGER SIDE SNAPPED, DRIVERS SIDE IS VERY CORRODED. JUST PURCHASED THIS CAR A COUPLE WEEKS AGO, HAD NO IDEA THESE PARTS WERE UNSTABLE.
THE REAR END OF MY SANTA FE HAS RUSTED THROUGH AND THE BACK WHEELS WILL NOT TRACK IN A STRAIGHT LINE. HYUNDAI HAD A RECALL NR 09V123000 IN 4/16/2009 TO FIX THIS EXACT PROBLEM BUT ACCORDING TO HYUNDAI CUSTOMER ASSISTANCE, THIS RECALL DOES NOT APPLY TO ME BECAUSE MY SANTA FE WASN'T PURCHASED OR REGISTERED IN A SPECIFIC STATE. MY…
Read full complaint
THE REAR END OF MY SANTA FE HAS RUSTED THROUGH AND THE BACK WHEELS WILL NOT TRACK IN A STRAIGHT LINE. HYUNDAI HAD A RECALL NR 09V123000 IN 4/16/2009 TO FIX THIS EXACT PROBLEM BUT ACCORDING TO HYUNDAI CUSTOMER ASSISTANCE, THIS RECALL DOES NOT APPLY TO ME BECAUSE MY SANTA FE WASN'T PURCHASED OR REGISTERED IN A SPECIFIC STATE. MY GRANDSON WAS DRIVING THE CAR AND NEARLY WRECKED. HYUNDAI WOULDN'T EVEN OFFER A TOW INTO A DEALERSHIP TO INSPECT THE PROBLEM.
I CAN HEAR A STRONG RUBBING AGAINST THE TIRE WHEN I COME TO SLOW DOWN AND STOP
"TAKATA RECALL" MY DRIVER SIDE FRONT WHEEL FEELS LIKE IT'S GONNA FALL OFF ALL THE LUG NUTS ARE TIGHT
CURRENTLY THERE IS A NOISE UP FRONT OF THE CAR AND IN THE REAR A FRIEND THAT WAS RIDING IN MY CAR INDICATED THAT IT MAY BE A SUSPENSION PROBLEM. HE ALSO NOTED THAT THERE WAS A CLASS ACTION SUIT WITH HYUNDAI ABOUT A SUBFRAME RUST CORROSION ISSUE. THE NOISE HAS BECOME QUITE NOTICEABLE HE BELIEVES MIGHT CERTAINLY BE RELATED
CAR HAS CLUNKING NOISE IN FRONT END. MECHANIC SAID IT'S THE SUBFRAME BUSHINGS GOING IN AND OUT OF THE SUBFRAME AND RECOMMENDED REPLACING SUBFRAME. SAID CAR IS "UNSAFE TO DRIVE IN THIS CONDITION." THERE IS A RECALL IN "SALT-BELT" STATES. NOT SURE IT THEY CONSIDER UTAH A SALT-BELT STATE, BUT SALT IS USED HERE EXTENSIVELY IN TH…
Read full complaint
CAR HAS CLUNKING NOISE IN FRONT END. MECHANIC SAID IT'S THE SUBFRAME BUSHINGS GOING IN AND OUT OF THE SUBFRAME AND RECOMMENDED REPLACING SUBFRAME. SAID CAR IS "UNSAFE TO DRIVE IN THIS CONDITION." THERE IS A RECALL IN "SALT-BELT" STATES. NOT SURE IT THEY CONSIDER UTAH A SALT-BELT STATE, BUT SALT IS USED HERE EXTENSIVELY IN THE WINTER.
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT WAS NOT INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). WITHOUT WARNING, THE FRONT COIL SPRING FRACTURED AND THE FRONT PASSENGER SIDE TIRE FAILED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENC…
Read full complaint
TL* THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT WAS NOT INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). WITHOUT WARNING, THE FRONT COIL SPRING FRACTURED AND THE FRONT PASSENGER SIDE TIRE FAILED. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS WAITING ON A RESPONSE FROM THE MANUFACTURER TO ADDRESS THE RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.
FRONT SUSPENSION RUSTING THROUGH - DISCOVERED BY MECHANIC
Official recalls
414V435000 · Suspension:front:springs:coil Springs
Jul 18, 2014
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 salt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
Consequence & remedy
Consequence: If the front coil spring fractures due to corrosion it could cause the coil spring to make contact with the tire, possibly puncturing the tire and increasing the risk of a vehicle crash.
Remedy: Hyundai will notify owners, and dealers will inspect and if necessary replace the coil spring, free of charge. The recall began on October 24, 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 124.
09V123000 · Suspension:rear
Apr 16, 2009
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
Consequence & remedy
Consequence: IF THE CORROSION IS ALLOWED TO PROGRESS, THE REAR TRAILING ARM MAY FRACTURE WHILE DRIVING, THEREBY INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR TRAILING ARMS FOR INTERNAL CORROSION DAMAGE. IF SPECIFIED LEVELS OF CORROSION DAMAGE ARE FOUND, THE REAR TRAILING ARMS WILL BE REPLACED. REAR TRAILING ARMS THAT DO NOT REQUIRE REPLACEMENT WILL HAVE DRAINAGE HOLES ADDED AND WILL BE TREATED WITH RUST-PROOFING MATERIAL TO ARREST THE CORROSION PROCESS. INSPECTION, TREATMENT AND REPLACEMENT PROCEDURES WILL BE CONDUCTED AT NO COST TO OWNERS. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
04V131000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Mar 16, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
Consequence & remedy
Consequence: IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
03V520000 · Equipment:other:labels
Dec 18, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA08023 · Rear Trailing Arm Corrosion Failure
Opened Oct 28, 2008 · Closed Apr 17, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (2)
Suspension
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.
Suspension:rear
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 85,000 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI SANTA FE VEHICLES MANUFACTURED PRIOR TO JANUARY 27, 2003, THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA:CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF EITHER THE RIGHT OR LEFT REAR TRAILING ARMS MAY RESULT IN FRACTURE OF THE AFFECTED ARM WHILE DRIVING, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH.THE REAR TRAILING ARMS WILL BE INSPECTED IN THE RECALLED VEHICLES USING A PROCEDURE DEVELOPED BY HYUNDAI TO MEASURE METAL THICKNESS.PARTS WITH PERFORATIONS FROM CORROSION OR WITH METAL BELOW THE SPECIFIED THICKNESS WILL BE REPLACED WITH REDESIGNED TRAILING ARMS.IF THE MINIMUM METAL THICKNESS IS MET, DRAINAGE HOLES AND AND RUST PROOFING MATERIAL WILL BE ADDED TO THE EXISTING REAR TRAILING ARMS.ALTHOUGH NOT SUBJECT COMPONENTS OF THIS INVESTIGATION, HYUNDAI NOTED IT WOULD PERFORM A SIMILAR PROCEDURE FOR THE FRONT SUBFRAMES OF THE SUBJECT VEHICLES. ODI'S ANALYSIS OF COMPLAINT DATA REVEALED THAT 99% OF ALL CONSUMER COMPLAINTS RELATED TO TRAILING ARM CORROSION WERE FROM VEHICLES EITHER ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES. SIMILARLY 92% OF THE WARRANTY CLAIMS WERE FROM VEHICLES ORIGINALLY SOLD OR OPERATED IN SALTBELT STATES.ODI IDENTIFIED 30 REAR TRAILING ARM FRACTURE INCIDENTS THROUGH ANALYSIS OF COMPLAINT AND WARRANTY INFORMATION AND CONSUMER INTERVIEWS.TWENTY-NINE (29) OF THE FRACTURE INCIDENTS INVOLVED VEHICLES IN STATES COVERED BY THE RECALL.BASED ON HYUNDAI'S DECISION TO CONDUCT A SAFETY RECALL THIS ENGINEERING ANALYSIS IS CLOSED.