The coating on the wiring harness is soy based and rodents chew the wires causing multiple electronic failures. Power steering failed, Adaptive Cruise Control failed, Automatic Emergency Braking failed, Lane Keeping Assistance failed. Vehicle is extremely unsafe!
COMPONENT SPOTLIGHT
Honda Civic electrical problems
1,532 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
54 crash reports59 fire reports30 injury reports
Reports by model year
YearTopic reportsRecallsInvestigations
20265
0020256
2020247
31202316
42202238
42202117
40202036
50201936
40201860
602017101
602016119
50201527
12201438
22201339
02201259
32201115
90201023
80200935
80200851
70200767
902006100
130200526
104200432
103200351
116200249
114200159
144200038
601999118
30199888
41199730
21199617
22199512
0019942
20199325
11199228
11199122
13199018
33198911
1319887
3319864
33Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
2210–25K
15925–50K
11250–75K
7775–100K
118100–150K
129150K+
816 reports with mileage · 716 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
1,532 reportsContinuous monitoring, including on the road, to create hazard. The following incidents are more about activities directly related to remaining qualified for a job and maintaining oneself in a state that is acceptable to employers. Reporter Name [XXX] HONDA Civic/CRX 2006Gray, CA[XXX] mySantaAna Work Order #[XXX] Traffic Engi…
Read full complaint
Continuous monitoring, including on the road, to create hazard. The following incidents are more about activities directly related to remaining qualified for a job and maintaining oneself in a state that is acceptable to employers. Reporter Name [XXX] HONDA Civic/CRX 2006Gray, CA[XXX] mySantaAna Work Order #[XXX] Traffic Engineering-Signal Issue Speed of Traffic Lights sped up and skipped through yellow to cause crossing at red or stopping within a foot of the crosswalk. Intersection has cameras around traffic lights. Timing was off enough to question, ie actually watching a stopwatch to know that it sped through yellow and ended green early from my view point was clearly seen. I will investigate further. Traffic patterns didn’t support such action and pedestrian activity just for that crossing was heavy while the other directions were not. Seemed suspicious but such timing had little effect on where my car stopped anyways. It was suspicious that there weren’t pedestrians traveling north and south on 17th or at the opposite side of the intersection, but that the side was on had at least 8 people immediately crossing. [XXX] Report Submitted NOV 16, 2022 - 7:39 AM New Request #[XXX] Location: [XXX] Description: Criminal or Illegal Activity (Trespass into Vehicle/ Theft of Control during Operation) in the City of West Covina I left Home Depot [XXX] on 11/16/22 9:59 PM PST. When I turned left onto Azusa Avenue to drive towards Amar Rd., two cars sped up in front of me. As both separated into each lane in front of me to drive side by side, the car on the left that drove in front of me, let out a significant amount of black smoke that began immediately after he merged into the far left lane in front of me after I turned left onto Azusa at The Heights traffic light intersection and ended immediately before the left turn p INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Hello. I have a 2020 Honda Civic Hatchback Sport. The stock audio system makes a VERY loud crackle and popping sound before completely cutting out, this abrupt malfunction frightens me and hurts my ears. Additionally the malfunction of this audio unit may cause other safety problems because it is connected to the back-up camera …
Read full complaint
Hello. I have a 2020 Honda Civic Hatchback Sport. The stock audio system makes a VERY loud crackle and popping sound before completely cutting out, this abrupt malfunction frightens me and hurts my ears. Additionally the malfunction of this audio unit may cause other safety problems because it is connected to the back-up camera which can freeze/reboot randomly when the electrical/software malfunction occurs. I listed the most recent incident date below however this problem has been intermittent since I purchased the car new in 2020. My car is now out of warranty and Honda refuses to address the issue even though it was present before 36,000/3 years. Thank you.
[12:29 PM] Rosales, Denise CTR (NHTSA) The contact owned a 2010 Honda Civic Hybrid. The contact stated the vehicle had been parked in her driveway and had not been driven for two days, when a fire had spontaneously ignited near the battery on the driver's side of the engine compartment. The fire had fully engulfed the engine com…
Read full complaint
[12:29 PM] Rosales, Denise CTR (NHTSA) The contact owned a 2010 Honda Civic Hybrid. The contact stated the vehicle had been parked in her driveway and had not been driven for two days, when a fire had spontaneously ignited near the battery on the driver's side of the engine compartment. The fire had fully engulfed the engine compartment. The fire department was called and extinguished the fire using water. The fire marshal filed a report. The vehicle had been declared a total loss by the contact's insurance provider. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.
The board control module failed and replacements are not available. Available for inspection upon request. Due to the component failing, the vehicle goes to accessory mode randomly or even to its on without engine mode. The wireless key will not grant access during these times or remote start. Without constantly charging the b…
Read full complaint
The board control module failed and replacements are not available. Available for inspection upon request. Due to the component failing, the vehicle goes to accessory mode randomly or even to its on without engine mode. The wireless key will not grant access during these times or remote start. Without constantly charging the battery, the vehicle will completely discharge its battery. This issue has been verified with the dealership and component inspected. No warning lamps gave away the process of the failure. warning lights only appear now after jumping the vehicle from a depleted battery due to the failure.
My car ran fine when started but the a few minutes later, it goes into limp mode where I cannot accelerate. Then it stalls out and now it won't restart. I do not know exactly what the problem is but my check engine light, IMA and red battery light comes on when it happened. As of now, my car is not even starting. This almost cau…
Read full complaint
My car ran fine when started but the a few minutes later, it goes into limp mode where I cannot accelerate. Then it stalls out and now it won't restart. I do not know exactly what the problem is but my check engine light, IMA and red battery light comes on when it happened. As of now, my car is not even starting. This almost caused an accident because I was driving on the freeway when it randomly decided to go into this limp mode
After less than 4 years, the dashboard Infotainment Screen stopped working and went blank/dark. I checked all connections and fuses with no luck. After a trip to the Honda Dealer, they quoted $1200.00 to replace the Infotainment screen. I do not have the money to replace this part. This part failed in less than 4 years time. As …
Read full complaint
After less than 4 years, the dashboard Infotainment Screen stopped working and went blank/dark. I checked all connections and fuses with no luck. After a trip to the Honda Dealer, they quoted $1200.00 to replace the Infotainment screen. I do not have the money to replace this part. This part failed in less than 4 years time. As a result, I have no access to the back up camera, tire inflation calibration, or radio controls and other functions displayed on this screen. This is causing a safety hazard while driving and undue driver distraction while driving while trying to access information usually displayed on the screen. I checked the internet regarding this issue, and there is wide spread data that this is a common issue with Honda, including several law firm class action lawsuits. I believe there should be a Safety Recall for Honda to replace this part.
On two (2) separate occasions the engine wiring harness was damaged by rodents. The damaged wiring harness compromised the power steering system, braking system and stability control system. Failure of these critical systems put the safety and welfare of myself, my family and all drivers on the road in danger of serious injury a…
Read full complaint
On two (2) separate occasions the engine wiring harness was damaged by rodents. The damaged wiring harness compromised the power steering system, braking system and stability control system. Failure of these critical systems put the safety and welfare of myself, my family and all drivers on the road in danger of serious injury and death. The damaged wiring harness is in my possession and available for inspection. The local Honda dealership and numerous other sources have stated the manufacturer is using a soy based plant material to produce the wire casing that attracts rodents to chew and permanently damage the food based wiring components. The local Honda dealership inspected and verified the cause and the effect of the damage. Steering, braking and stability control warning lights were indicated while driving the vehicle and prior to driving in subsequent trips
First it was two hoses that had issues with the AC then the condensor wasnt holding anything in so it kept leaking out and my AC still wasnt working so Honda said the Evaporator went out and said this is what Honda is known for and happens a lot. So my whole AC all these little parts kept going out and it cost me $4000 to replac…
Read full complaint
First it was two hoses that had issues with the AC then the condensor wasnt holding anything in so it kept leaking out and my AC still wasnt working so Honda said the Evaporator went out and said this is what Honda is known for and happens a lot. So my whole AC all these little parts kept going out and it cost me $4000 to replace all of them and to get it fixed. The evaporator is what cost $3000 to replace
Since I've owned the car, when driving above 40 mph(when LKAS may engage), with LKAS off, the steering becomes statically neutral...i.e in a turn the steering wheel will remain in the turned position when pressure on the wheel is reduced. In this case the steering wheel( as well as the front wheels themselves) should straighten …
Read full complaint
Since I've owned the car, when driving above 40 mph(when LKAS may engage), with LKAS off, the steering becomes statically neutral...i.e in a turn the steering wheel will remain in the turned position when pressure on the wheel is reduced. In this case the steering wheel( as well as the front wheels themselves) should straighten out as you continue to move. This is dangerous. Also, at highway speeds, in order to maintain the center of your lane small inputs to the steering wheel are normally required. In this vehicle, there is resistance to these small inputs. When the force of your input finally overcomes the resistance in the steering wheel the wheel turns more dramatically than intended(overcorrection). This is also dangerous. This also occurs with LKAS off. It's almost like LKAS engages the steering column preemptively above 40 mph but in a dangerous manner.
Related Official recalls
210V364000 · Electrical System:ignition
Aug 5, 2010
HONDA IS RECALLING CERTAIN MODEL YEAR 2003 HONDA ACCORD, CIVIC TWO AND FOUR DOOR, AND MODEL YEAR 2003-2004 HONDA ELEMENT VEHICLES. THE INTERLOCK LEVER OF THE IGNITION SWITCH MAY UNEXPECTEDLY DEFORM, WHICH CAN ALLOW THE INTERLOCK FUNCTION OF A VEHICLE WITH AN AUTOMATIC TRANSMISSION TO BE DEFEATED.
Consequence & remedy
Consequence: REMOVAL OF THE IGNITION KEY WHEN THE GEAR SELECTOR OF A VEHICLE WITH AN AUTOMATIC TRANSMISSION HAS NOT BEEN SHIFTED TO THE PARK POSITION CAN ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE ORIGINAL INTERLOCK PIN AND LEVER WITHIN THE IGNITION SWITCH, AND REPLACE THEM WITH NEW, DESIGNED COMPONENTS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 7, 2010. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
02V120000 · Electrical System:ignition:switch
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
4EA11012 · Low Beam Headlights Stop Illuminating
Opened Sep 12, 2011 · Closed Sep 17, 2012
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash; Exterior Lighting:headlights; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 2002-2004 CR-V and MY 2003 Pilot.In the DIR, Honda stated that tension from the combination switch wiring harness to the electrical terminal for the low beam headlight circuit could cause a small amount of motion as the combination switch was operated.This motion, over time, can wear the surface of the terminal creating copper oxide, increasing electrical resistance, which may cause the terminal to melt within the harness connector.ODI continued its investigation, and on August 31, 2012 Honda submitted another DIR to recall an additional 820,789 vehicles.This report included the MY 2002 Civic vehicles which were not subject to a prior safety recall (04V-086) for headlights, all of MY 2003 Civic, and MY 2004-2005 Pilot.Honda's DIR advised that operation of the turn signal switch lever at high speed and/or with heavy force can cause movement between the combination switch body and the sub-harness wiring connector.This can cause wear and continued movement can create copper oxide, increasing electrical resistance, and potentially causing the terminal to melt within the harness connector. Please see both DIRs at http://www-odi.nhtsa.dot.gov/recalls/ under safety recall 12V-136 for complete details.Honda also provided additional information on the Element model, stating that it was not recalled due to it's very low failure rate.Honda sold 301,497 Element vehicles in the United States and received 17 reports, while ODI received one report (see VOQ 10395219).Honda's technical explanation for the low rate, which was submitted under request for confidentiality, is that the headlight switch, as installed in the Element, reacts differently to the forces applied to it as compared to the recalled models.See attachment for additional information.
Additional source detail variants (4)
Electrical System:wiring:interior/under Dash
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 2002-2004 CR-V and MY 2003 Pilot.In the DIR, Honda stated that tension from the combination switch wiring harness to the electrical terminal for the low beam headlight circuit could cause a small amount of motion as the combination switch was operated.This motion, over time, can wear the surface of the terminal creating copper oxide, increasing electrical resistance, which may cause the terminal to melt within the harness connector.ODI continued its investigation, and on August 31, 2012 Honda submitted another DIR to recall an additional 820,789 vehicles.This report included the MY 2002 Civic vehicles which were not subject to a prior safety recall (04V-086) for headlights, all of MY 2003 Civic, and MY 2004-2005 Pilot.Honda's DIR advised that operation of the turn signal switch lever at high speed and/or with heavy force can cause movement between the combination switch body and the sub-harness wiring connector.This can cause wear and continued movement can create copper oxide, increasing electrical resistance, and potentially causing the terminal to melt within the harness connector. Please see both DIRs at http://www-odi.nhtsa.dot.gov/recalls/ under safety recall 12V-136 for complete details.Honda also provided additional information on the Element model, stating that it was not recalled due to it's very low failure rate.Honda sold 301,497 Element vehicles in the United States and received 17 reports, while ODI received one report (see VOQ 10395219).Honda's technical explanation for the low rate, which was submitted under request for confidentiality, is that the headlight switch, as installed in the Element, reacts differently to the forces applied to it as compared to the recalled models.See attachment for additional information.
Exterior Lighting:headlights:high/low Beam Dimmer Switch
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 2002-2004 CR-V and MY 2003 Pilot.In the DIR, Honda stated that tension from the combination switch wiring harness to the electrical terminal for the low beam headlight circuit could cause a small amount of motion as the combination switch was operated.This motion, over time, can wear the surface of the terminal creating copper oxide, increasing electrical resistance, which may cause the terminal to melt within the harness connector.ODI continued its investigation, and on August 31, 2012 Honda submitted another DIR to recall an additional 820,789 vehicles.This report included the MY 2002 Civic vehicles which were not subject to a prior safety recall (04V-086) for headlights, all of MY 2003 Civic, and MY 2004-2005 Pilot.Honda's DIR advised that operation of the turn signal switch lever at high speed and/or with heavy force can cause movement between the combination switch body and the sub-harness wiring connector.This can cause wear and continued movement can create copper oxide, increasing electrical resistance, and potentially causing the terminal to melt within the harness connector. Please see both DIRs at http://www-odi.nhtsa.dot.gov/recalls/ under safety recall 12V-136 for complete details.Honda also provided additional information on the Element model, stating that it was not recalled due to it's very low failure rate.Honda sold 301,497 Element vehicles in the United States and received 17 reports, while ODI received one report (see VOQ 10395219).Honda's technical explanation for the low rate, which was submitted under request for confidentiality, is that the headlight switch, as installed in the Element, reacts differently to the forces applied to it as compared to the recalled models.See attachment for additional information.
Exterior Lighting:headlights
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 2002-2004 CR-V and MY 2003 Pilot.In the DIR, Honda stated that tension from the combination switch wiring harness to the electrical terminal for the low beam headlight circuit could cause a small amount of motion as the combination switch was operated.This motion, over time, can wear the surface of the terminal creating copper oxide, increasing electrical resistance, which may cause the terminal to melt within the harness connector.ODI continued its investigation, and on August 31, 2012 Honda submitted another DIR to recall an additional 820,789 vehicles.This report included the MY 2002 Civic vehicles which were not subject to a prior safety recall (04V-086) for headlights, all of MY 2003 Civic, and MY 2004-2005 Pilot.Honda's DIR advised that operation of the turn signal switch lever at high speed and/or with heavy force can cause movement between the combination switch body and the sub-harness wiring connector.This can cause wear and continued movement can create copper oxide, increasing electrical resistance, and potentially causing the terminal to melt within the harness connector. Please see both DIRs at http://www-odi.nhtsa.dot.gov/recalls/ under safety recall 12V-136 for complete details.Honda also provided additional information on the Element model, stating that it was not recalled due to it's very low failure rate.Honda sold 301,497 Element vehicles in the United States and received 17 reports, while ODI received one report (see VOQ 10395219).Honda's technical explanation for the low rate, which was submitted under request for confidentiality, is that the headlight switch, as installed in the Element, reacts differently to the forces applied to it as compared to the recalled models.See attachment for additional information.
Exterior Lighting:headlights:switch
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 2002-2004 CR-V and MY 2003 Pilot.In the DIR, Honda stated that tension from the combination switch wiring harness to the electrical terminal for the low beam headlight circuit could cause a small amount of motion as the combination switch was operated.This motion, over time, can wear the surface of the terminal creating copper oxide, increasing electrical resistance, which may cause the terminal to melt within the harness connector.ODI continued its investigation, and on August 31, 2012 Honda submitted another DIR to recall an additional 820,789 vehicles.This report included the MY 2002 Civic vehicles which were not subject to a prior safety recall (04V-086) for headlights, all of MY 2003 Civic, and MY 2004-2005 Pilot.Honda's DIR advised that operation of the turn signal switch lever at high speed and/or with heavy force can cause movement between the combination switch body and the sub-harness wiring connector.This can cause wear and continued movement can create copper oxide, increasing electrical resistance, and potentially causing the terminal to melt within the harness connector. Please see both DIRs at http://www-odi.nhtsa.dot.gov/recalls/ under safety recall 12V-136 for complete details.Honda also provided additional information on the Element model, stating that it was not recalled due to it's very low failure rate.Honda sold 301,497 Element vehicles in the United States and received 17 reports, while ODI received one report (see VOQ 10395219).Honda's technical explanation for the low rate, which was submitted under request for confidentiality, is that the headlight switch, as installed in the Element, reacts differently to the forces applied to it as compared to the recalled models.See attachment for additional information.
EA09001 · Ignition Shift Interlock
Opened Jan 5, 2009 · Closed Oct 14, 2010
Status: closed (inferred from source dates) · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:switch
On August 4, 2010, American Honda Motor Co. (Honda) submitted a Defect Information Report (DIR) to NHTSA regarding a ignition interlock defect in approximately 384,220 model year (MY) 2003 Honda Accord and Civic and MY 2003 and 2004 Honda Element vehicles with automatic transmissions (Recall 10V-364).In a September 22, 2010 supplemental DIR, Honda expanded the scope of the recall population based on manufacturing and complaint data.The total population for the complete recall is approximately 551,498 vehicles.The information listed in this closing report refers only to the subject vehicles, MY 2003 Accords with automatic transmissions.According to Honda's DIR, Under certain conditions the interlock lever of the ignition switch may unexpectedly deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated if the driver does not follow the typical shut-down procedure of shifting the gear selector to the Park position before rotating the ignition key to the off position. Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the Park position can allow the vehicle to roll away, increasing the risk of a crash.Honda's dealers will be instructed to inspect the ignition interlock switch and, if necessary, replace the original interlock pin and lever within the ignition switch and replace them with new, redesigned parts.This investigation is closed.
Additional source detail variants (2)
Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
On August 4, 2010, American Honda Motor Co. (Honda) submitted a Defect Information Report (DIR) to NHTSA regarding a ignition interlock defect in approximately 384,220 model year (MY) 2003 Honda Accord and Civic and MY 2003 and 2004 Honda Element vehicles with automatic transmissions (Recall 10V-364).In a September 22, 2010 supplemental DIR, Honda expanded the scope of the recall population based on manufacturing and complaint data.The total population for the complete recall is approximately 551,498 vehicles.The information listed in this closing report refers only to the subject vehicles, MY 2003 Accords with automatic transmissions.According to Honda's DIR, Under certain conditions the interlock lever of the ignition switch may unexpectedly deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated if the driver does not follow the typical shut-down procedure of shifting the gear selector to the Park position before rotating the ignition key to the off position. Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the Park position can allow the vehicle to roll away, increasing the risk of a crash.Honda's dealers will be instructed to inspect the ignition interlock switch and, if necessary, replace the original interlock pin and lever within the ignition switch and replace them with new, redesigned parts.This investigation is closed.
Electrical System:ignition:switch
On August 4, 2010, American Honda Motor Co. (Honda) submitted a Defect Information Report (DIR) to NHTSA regarding a ignition interlock defect in approximately 384,220 model year (MY) 2003 Honda Accord and Civic and MY 2003 and 2004 Honda Element vehicles with automatic transmissions (Recall 10V-364).In a September 22, 2010 supplemental DIR, Honda expanded the scope of the recall population based on manufacturing and complaint data.The total population for the complete recall is approximately 551,498 vehicles.The information listed in this closing report refers only to the subject vehicles, MY 2003 Accords with automatic transmissions.According to Honda's DIR, Under certain conditions the interlock lever of the ignition switch may unexpectedly deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated if the driver does not follow the typical shut-down procedure of shifting the gear selector to the Park position before rotating the ignition key to the off position. Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the Park position can allow the vehicle to roll away, increasing the risk of a crash.Honda's dealers will be instructed to inspect the ignition interlock switch and, if necessary, replace the original interlock pin and lever within the ignition switch and replace them with new, redesigned parts.This investigation is closed.
DP00007 · Ignition Distributor
Opened Nov 13, 2000 · Closed Oct 25, 2001
Status: closed (inferred from source dates) · Electrical System
THE PETITION ALLEGES THAT IGNITION DISTRIBUTOR FAILURE COULD CAUSE A VEHICLE FIRE OR A TRAFFIC ACCIDENT
PE93082 · Stalling
Opened Sep 23, 1993 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available