TL*THE CONTACT OWNS 1993 FORD F-250. WHILE DRIVING 60 MPH THE VEHICLE STARTED TO 'SHIMMY" VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. AFTER 4 DAYS THE TECHNICIAN CONCLUDED THAT THE TIRE PRESSURE WAS HIGH; HOWEVER, HE SPECULATED THAT THE TIRES WERE NOT THE CAUSE OF THE FAILURE. THERE ARE NUMEROUS COMPLAINTS RE…
Read full complaint
TL*THE CONTACT OWNS 1993 FORD F-250. WHILE DRIVING 60 MPH THE VEHICLE STARTED TO 'SHIMMY" VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. AFTER 4 DAYS THE TECHNICIAN CONCLUDED THAT THE TIRE PRESSURE WAS HIGH; HOWEVER, HE SPECULATED THAT THE TIRES WERE NOT THE CAUSE OF THE FAILURE. THERE ARE NUMEROUS COMPLAINTS REGARDING THE "SHIMMY" ON SEVERAK YEAR, MAKE, AND MODELS, OF THE F-SERIES. THE CURRENT AND FAILURE MILEAGE WAS 61,000.
NHTSA ODI #10288699
Mileage unknown · Jan 22, 2002
Steering
WHILE DRIVING 30-40 MPH POWER ASSIST BELT HAS COME OFF TWICE, LEAVING VEHICLE WITHOUT POWER OR BRAKES. FORD HAD A SAFETY CAMPAIGN BUT IT HAS EXPIRED ACCORDING TO CONSUMER.*AK *TT
NHTSA ODI #8002551
Mileage unknown · Jan 11, 2001
Steering
STEERING BELT TENSIONER ASSEMBLY WORE OUT, CAUSING LOSS OF POWER TO BRAKES & STEERING. *AK
NHTSA ODI #739228
Mileage unknown · Apr 24, 2000
Steering
I CONSIDERED IT TO BE HIGHLY UNUSAL THAT MY STEERING SHOULD FAIL LIKE THIS. MY STEERING COLUMN BEARINGS FAILED. I WOULD LIKE TO KNOW IF THIS HAS OCCURRED IN OTHER VEHICLES OR IF THERE HAS BEEN ANY FATALITES. I WOULD LIKE TO BE REIMBURSED BY FORD MOTER COMPANY. *AK
NHTSA ODI #721878
Mileage unknown · Mar 30, 2000
Engine And Engine CoolingService Brakes, HydraulicSteering
WHILE STARTING UP TRUCK DRIVE BELT FELL OFF. ALSO, THERE WERE NO BRAKES OR STEERING WHEN THIS HAPPENED. CONSUMER HAD TO REPLACE DRIVE BELT SIX TIMES. CONSUMER INDICATED IF GOING DOWN A HILL VEHICLE WOULD HAVE CRASHED. NEITHER DEALER NOT MANUFACTURER PROVIDED ANY HELP. *AK *ML
NHTSA ODI #859478
Mileage unknown · Dec 8, 1999
Engine And Engine CoolingSteeringSuspension
THE INCIDENT WITH THE SERPENTINE BELT TENSIONER,AGAIN RESULTED IN LOSS OF STEERING, AND BRAKING EFFECTIVENESS DUE TO THE VACUUM PUMP BEING RUN BY THE ACCESSORY DRIVE BELT. THE VEHICLE WAS DIFFICULT TO STOP, AND STEERING WAS EXTREMELY HARD. IF MY WIFE WERE DRIVING THE VEHICLE, THERE WOULD SURELY HAVE BEEN AN ACCIDENT, ESPECIALLY …
Read full complaint
THE INCIDENT WITH THE SERPENTINE BELT TENSIONER,AGAIN RESULTED IN LOSS OF STEERING, AND BRAKING EFFECTIVENESS DUE TO THE VACUUM PUMP BEING RUN BY THE ACCESSORY DRIVE BELT. THE VEHICLE WAS DIFFICULT TO STOP, AND STEERING WAS EXTREMELY HARD. IF MY WIFE WERE DRIVING THE VEHICLE, THERE WOULD SURELY HAVE BEEN AN ACCIDENT, ESPECIALLY AT HIGHER HIGHWAY SPEEDS. THIS IS THE THIRD TIME THAT THIS UNIT HAS BEEN REPLACED ON THIS ENGINE. FORD HAS NOT COME UP WITH A SUITABLE ENGINEERING DESIGN TO CORRECT THE PROBLEM ASSOCIATED WITH THIS FAILURE. I EXPECT THAT THIS WILL AGAIN FAIL SOMETIME IN THE FUTURE, I HOPE NOT WITH DISASTEROUS RESULTS. THE DAMPENER, SHOCK ABSORBER FAILED CAUSING PREMATURE WEAR, AND SUBSEQUENT FAILURE OF THE TENSIONER. THE RECALL WHICH WAS DONE ON THIS VEHICLE WAS NOT AS EFFECTIVE AS YOU WERE LED TO BELIEVE. THE DEFROSTER ALSO FAILS TO GO INTO THE DEFROST MODE ONCE THE VEHICLE IS EXTREMELY COLD, AND THE BLOWER MOTOR IS MAKING A GRINDING, SQUEELING NOISE. I EXPECT THAT THESE WILL STOP COMPLETLY IN THE NEAR FUTURE.
NHTSA ODI #715822
Mileage unknown · Feb 2, 1998
Electrical SystemEquipmentFuel System, Gasoline
FUEL INJECTOR FAILED.
NHTSA ODI #529557
Mileage unknown · Jul 16, 1997
SteeringSuspension
WHILE DRIVING VEHICLE UNDER NORMAL CONDITIONS FRONT VEHICLE SPRINGS HAVE WORN OUT, CAUSING VEHICLE TO BOTTOM OUT. ALSO PREMATURE FAILURE OF DRAG LINK AND TIE ROD ENDS. *AK
NHTSA ODI #813178
Mileage unknown · Aug 11, 1995
Steering
POLY V-BELT BROKE, CAUSING LOSS OF POWER STEERING/BRAKES/BELT CUT STARTER SOLENOID/STRIPPED COLD WEATHER ENGINE. *SD
NHTSA ODI #484964
Mileage unknown · Jul 12, 1995
Engine And Engine CoolingPower TrainSteering
THE SERPENTINE BELT CAME OF, CAUSING LOSS OF POWER. TT
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND CAB CHASSIS EQUIPPED WITH GASOLINE ENGINES AND DUAL FUEL TANKS. THE CARBON STEEL FUEL PRESSURE REGULATOR IN THE FUEL SYSTEM CAN WEAR OUT DURING THE LIFE OF THE VEHICLE. IF THE FUEL PRESSURE REGULATOR MALFUNCTIONS, IT CAN CAUSE HIGH FUEL SYSTEM PRESSURE, WHICH DAMAGES THE FUEL PUMP CHECK VALVE. THIS ALLOWS FUEL TO BE TRANSFERRED FROM ONE TANK TO THE OTHER, POSSIBLY OVERFILLING THE NON-OPERATING TANK, RESULTING IN FUEL OVERFLOW PAST THE FILLER CAP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL HAVE A STAINLESS STEEL FUEL PRESSURE REGULATOR INSTALLED. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (SEE PREVIOUS NHTSA RECALL 93V-125/FORD RECALL 93S68).
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
1993 Ford F-250 Problems, Complaints & Recalls | Skip That Year
Illustration