IllustrationTHE CHECK VALVE IS BAD AND GAS IS TRANSFERRED TO THE FRONT TANK CAUSING IT TO SPILL OVER. SOME F250 FROM THAT YEAR ARE UNDER RECALL. WHY IS MINE NOT
1992 Ford F-250
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford F-250 do not stand out strongly from the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 119 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports6 fire reports3 injury reports
What owners actually said
119 reportsTL* THE CONTACT OWNS A 1992 FORD F-250. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STARTED TO SHAKE. WHEN THE SPEED DECREASED TO 20 MPH, THE VEHICLE STOPPED SHAKING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F-250. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STARTED TO SHAKE. WHEN THE SPEED DECREASED TO 20 MPH, THE VEHICLE STOPPED SHAKING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. UPDATED 02/12/16*LJ *JS
TL* THE CONTACT OWNS A 1992 FORD F250. THE CONTACT STATED THE EMERGENCY BRAKE WOULD NOT ENGAGE. IN ADDITION, THE ODOMETER GAUGE WAS INOPERABLE. THE DEALER WAS NOTIFIED WHO STATED THAT THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 94V169001 (PARKING BRAKE: CONVENTIONAL) HOWEVER, THE VEHICLE WAS NOT INCLUDED. …
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD F250. THE CONTACT STATED THE EMERGENCY BRAKE WOULD NOT ENGAGE. IN ADDITION, THE ODOMETER GAUGE WAS INOPERABLE. THE DEALER WAS NOTIFIED WHO STATED THAT THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 94V169001 (PARKING BRAKE: CONVENTIONAL) HOWEVER, THE VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.
WITH MY 3 GRANDDAUGHTERS IN THE CAB OF MY FORD F250 I STOPPED AT THE BICYCLE SHOP TO DROP OFF 2 BICYCLES THAT NEEDED REPAIR, THIS TOOK LESS THAN 5 MINUTES. WHEN I RETURNED TO MY TRUCK THERE WAS NO LESS THAN 1/2 GALON OF FUEL ON THE PAVEMENT AND FUEL WAS STILL LEAKING OUT OF THE REAR TANK FILLER NECK. I QUICKLY TOOK MY GRANDD…
Read full complaint
WITH MY 3 GRANDDAUGHTERS IN THE CAB OF MY FORD F250 I STOPPED AT THE BICYCLE SHOP TO DROP OFF 2 BICYCLES THAT NEEDED REPAIR, THIS TOOK LESS THAN 5 MINUTES. WHEN I RETURNED TO MY TRUCK THERE WAS NO LESS THAN 1/2 GALON OF FUEL ON THE PAVEMENT AND FUEL WAS STILL LEAKING OUT OF THE REAR TANK FILLER NECK. I QUICKLY TOOK MY GRANDDAUGHTERS OUT OF THE TRUCK TO SAFETY AND HAD MY TRUCK TOWED TO MY MECHANIC. HE CALLED THE FORD DEALER IN ALHAMBRA CA. AND WAS TOLD OF THE DEFECTIVE VALVE, BUT THERE WAS NO RECALL AND THAT IT WOULD COST NO LESS THAN $ 400.00 TO CORRECT. I TOOK MY TRUCK TO THAT SAME DEALER THE FOLLOWING WEEK TO HAVE NEW SHOCKS INSTALLED AND WAS TOLD THE SAME THING BY THE SHOP MANAGER. THIS PREVENTS ME FROM FILLING BOTH TANKS OR LEAKAGE WILL OCCUR. ANOTHER INCIDENT OCCURRED WHEN A DRIVER OF ANOTHER VEHICLE PULLED ME OVER TO REPORT THAT HIS CAR HAD FUEL ALL OVER HIS NEW CAR AND TOOK DOWN MY INFORMATION, BUT WENT TO A NEARBY CAR WASH, BUT THAT I WOULD BE RESPONSIBLE IF ANY DAMAGE TO THE FINISH OCCURRED. THIS VALVE PROBLEM PUT MY FAMILY IN POTENTIAL GRAVE DANGER AND I FEEL THAT FORD IS RESPONSIBLE TO CORRECT THE PROBLEM AT THEIR EXPENSE. ACCORDING TO THE "AUTO RECALL CAR REPORT" FORD HAS EXTENDED THE WARRANTY FOR 12 YEAR OR 150,000 MILES. IS THE DOT ABLE TO HELP MY SITUATION AND ORDER FORD TO CORRECT THE FUEL CROSSOVER AND FUEL SPILLAGE PROBLEM? *TR
TL*THE CONTACT OWNS A 1992 FORD F250. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) ON AUGUST 27, 2007. HE TOOK THE VEHICLE TO THE DEALER AND THEY INFORMED HIM THAT THE PARTS WOULD BE UNAVAILABLE UNTIL JANUARY OF 2008. THEY ADVISED HIM TO DEACTIVATE HIS SPEED CONTROL SWITC…
Read full complaint
TL*THE CONTACT OWNS A 1992 FORD F250. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) ON AUGUST 27, 2007. HE TOOK THE VEHICLE TO THE DEALER AND THEY INFORMED HIM THAT THE PARTS WOULD BE UNAVAILABLE UNTIL JANUARY OF 2008. THEY ADVISED HIM TO DEACTIVATE HIS SPEED CONTROL SWITCH, HOWEVER, THE CONTACT REFUSED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 120,000.
TIRE BLOWOUT. *JB
CONSUMER PARKED THE VEHICLE, WENT INTO THE HOUSE, AND SMELLED SMOKE. BY THE TIME THE CONSUMER COULD RESPOND THE WINDOWS BLEW OUT BECAUSE OF THE FIRE.*AK
CONSUMER COMPLAINED ABOUT A FUEL TANK PROBLEM. HOWEVER, THERE TWO RECALLS, RECALL 011008000 AND RECALL 93V125000 WERE ISSUED. THIS VEHICLE WA SNOT INCLUDED. CONSUMER CONTACTED THE FORD DEALER AND THE MANUFACTURER. *AK
NHTSA# 93-V-125-000 THE VEHICLE EXPERIENCED THE SAME PROBLEM AS STATED IN RECALL 93 V 125 000, HOWEVER THE DEALER REFUSED TO FIX. *JB
CONSUMER STATES WHILE HIS WIFE WAS DRIVING THEIR TRUCK, THE TIRE ON THE FRONT OF THE TRUCK BLEW. HE STATES THAT THE SIDEWALL ON THE TIRE EXPLODED. HE ALSO STATES THAT HE OR HIS WIFE HAD HIT ANYTHING PRIOR. CONSUMER STATES THAT THE TIRES WAS SUPPOSE TO BE GOOD FOR 50,000 MILES INSTEAD HE JUST HAD 20,000 MILES ON THEM. HE A…
Read full complaint
CONSUMER STATES WHILE HIS WIFE WAS DRIVING THEIR TRUCK, THE TIRE ON THE FRONT OF THE TRUCK BLEW. HE STATES THAT THE SIDEWALL ON THE TIRE EXPLODED. HE ALSO STATES THAT HE OR HIS WIFE HAD HIT ANYTHING PRIOR. CONSUMER STATES THAT THE TIRES WAS SUPPOSE TO BE GOOD FOR 50,000 MILES INSTEAD HE JUST HAD 20,000 MILES ON THEM. HE ALSO STATES THAT THE TIRE WAS A UNIROYAL SIZE LT 235 85 R/16. TS
Official recalls
494V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
93V125000 · Fuel System, Gasoline:storage:tank Assembly
Aug 2, 1993
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
92V112000 · Engine And Engine Cooling:engine:gasoline
Aug 4, 1992
THE SOUND INSULATION ON THE ENGINE SIDE OF THE DASH PANEL CAN CONTACT THE EXHAUST MANIFOLD.
Consequence & remedy
Consequence: CONTACT BETWEEN THE INSULATION AND THE HOT EXHAUSTMANIFOLD MAY RESULT IN A ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL MODIFY THE SOUND INSULATOR AT NO COST TO OWNERS.
92V006000 · Structure:body:door
Jan 14, 1992
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92055 · Engine Compartment Fires
Opened Jun 24, 1992 · Closed Aug 20, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available