IllustrationSERPENTINE BELT FREQUENTLY COMES OFF, RESULTING IN NO POWER STEERING AND OIL PUMP FAILURE.*AK
1996 Dodge Van
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Van years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
18 reportsI WOULD LIKE TO INFORM YOU OF MY 1996 DODGE GRAND CARAVAN THE DASH BOARD IS CRACKED AND THE VEHICLE STOPPED RUNNING IN THE MIDDLE OF THE ROAD MY GAUGES HAVE BEEN ACTING UP EVER SINCE MY DASH STARTED CRACKING MY AC COMES ON AND OFF MY RADIO COMES AND GOES MY HAZARD LIGHTS DON'T COME ON WHEN MY GAUGES DON'T WORK MY AIRBAG LIGHTS C…
Read full complaint
I WOULD LIKE TO INFORM YOU OF MY 1996 DODGE GRAND CARAVAN THE DASH BOARD IS CRACKED AND THE VEHICLE STOPPED RUNNING IN THE MIDDLE OF THE ROAD MY GAUGES HAVE BEEN ACTING UP EVER SINCE MY DASH STARTED CRACKING MY AC COMES ON AND OFF MY RADIO COMES AND GOES MY HAZARD LIGHTS DON'T COME ON WHEN MY GAUGES DON'T WORK MY AIRBAG LIGHTS COME AND GO OFF WHILE DRIVING AND MY WINDOWS DON'T WORK WHEN MY AIRBAG LIGHT COMES ON ANT THE RADIO GOES OUT WHEN THIS HAPPENS MY VAN IS AT THE REPAIR SHOP AT THIS TIME NOTHING WORKS ON IT NOT IT WILL NOT START WHEN IT STOPPED IT STOPPED DEAD IN THE ROAD WHILE DRIVING ON A BUSY HIGHWAY IN THE LANE OF TRAFFIC.*TR
THE VEHICLE'S STRUT TOWER RUSTED THROUGH COMPLETELY. THE CONSUMER BELIEVES THE MANUFACTURER SHOULD ISSUE A STRUT TOWER RECALL. *NM *NM
WHILE DRIVING ON OR ABOUT 60-65MPH MY DUNLOP RADAIL ROVER AT TIRES WITH ONLY 6000 MILES ON THEM ARE SEPARATING. WENT BACK TO TIRE KINGDOM IN SEMINOLE FL AND HAD IT REPLACED. A MONTH LATER A SECOND TIRE ON MY VAN SEPARATED ALSO AND AGAIN RETURNED TO TIRE KINGDOM FOR AN ANSWER ONLY TO FIND NO ONE WILL DO ANYRTHING ABOUT IT EXCEPT …
Read full complaint
WHILE DRIVING ON OR ABOUT 60-65MPH MY DUNLOP RADAIL ROVER AT TIRES WITH ONLY 6000 MILES ON THEM ARE SEPARATING. WENT BACK TO TIRE KINGDOM IN SEMINOLE FL AND HAD IT REPLACED. A MONTH LATER A SECOND TIRE ON MY VAN SEPARATED ALSO AND AGAIN RETURNED TO TIRE KINGDOM FOR AN ANSWER ONLY TO FIND NO ONE WILL DO ANYRTHING ABOUT IT EXCEPT TO REPLACE THE DEFECTIVE TIRES AT MY COST. WANT TO FIND OUT AFTER THE FIRESTONE INCIDENCE IF ANYONE ELSE HAS HAD THESE TIRES GO BAD ON THEM NUMBER ONE REASON BEING TO PROTECT THE SAFTY OF OTHER PEOPLE AS WELL AS MINE, THANK YOU. *AK
TRANSMISSION IS HARD WHEN SHIFTING GEARS. DEALERSHIP IS AWARE OF PROBLEM.*AK REAR DOOR LEAKED WATER AT TOP. DEALER FOUND FRONT CLUTCH SEAL IN THE TRANSMISSION FAILED, DEALER REPLACED ALL CLUTCHES AND SEALS AND REBUILD O/D ASSEMBLY, THE COOLER HOSE WAS REPLACED DUE TO A BUBBLE ON SIDE OF HOSE. *SLC
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
I SENT A DEFECT INVESTIGATION IN EARLIER TODAY BUT I HAD FORGOTTEN ABOUT THIS ONE UNTIL NOW. WE HAD A PROBLEM WITH THE TRANSMISSION & HAD TO HAVE IT COMPLETELY OVERHAULED.
THE WHOLE COOLING SYSTEM WAS FOUND TO BE COMPLETELY RUSTED OUT A FEW MONTHS AGO. WE HAD THE COOLING SYSTEM FIXED ONCE & JUST FOUND OUT THAT IT IS RUSTED AGAIN TODAY. IT WAS REPLACED THE FIRST TIME BY GOODYEAR (WHERE SON WORKS). IT COST ABOUT $1000.00 THE FIRST TIME TO FIX IT. THE FUEL TANK WAS LEAKING A GOOD WHILE BACK, WA…
Read full complaint
THE WHOLE COOLING SYSTEM WAS FOUND TO BE COMPLETELY RUSTED OUT A FEW MONTHS AGO. WE HAD THE COOLING SYSTEM FIXED ONCE & JUST FOUND OUT THAT IT IS RUSTED AGAIN TODAY. IT WAS REPLACED THE FIRST TIME BY GOODYEAR (WHERE SON WORKS). IT COST ABOUT $1000.00 THE FIRST TIME TO FIX IT. THE FUEL TANK WAS LEAKING A GOOD WHILE BACK, WAS FIXED & STARTED LEAKING AGAIN. THE FUEL TANK PROBLEM WAS FIXED TWICE, BOTH TIMES UNDER WARRANTY IF I REMEMBER RIGHT. WE HAD IT FIXED AT A DODGE DEALERSHIP IN HAMILTON. I HAVE HAD A PROBLEM EVERY SINCE IT WAS FIXED THE SECOND TIME THAT WHEN YOU PUMP GAS INTO IT IT CONSTANTLY STOPS LIKE THERE IS SOMETHING KEEPING THE GAS FROM PUMPING IN PROPERLY. I STILL HAVE THE PROBLEM WHEN FILLING UP WITH GAS. THE REASON WE HAD THE COOLING SYSTEM FIXED AT GOODYEAR INSTEAD OF THE DEALERSHIP IS BECAUSE WE DIDN'T LIKE THE JOB THEY DID BEFORE ON THE FUEL LEAK.
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
VEHICLE STALLS INTERMITTENTLY. VEHICLE TOWED TO DEALER. THE NEXT TIME THE HAZARD LIGHTS AND THE POWER WINDOWS DIDN'T WORK. ENGINE CHECK LIGHT CAME ON. *AK *ML
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.