Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
2825–50K
5650–75K
5075–100K
58100–150K
24150K+
230 reports with mileage · 325 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports14 fire reports28 injury reports
What owners actually said
555 reports
40,900 miles · Mar 11, 2003
Vehicle Speed Control
IT IS AN INTERMITTENT PROBLEM. THE SPEEDOMETER GETS STUCK ON A NUMBER BUT THE CAR IS STILL GOING FASTER OR SLOWER THAN SHOWN ON THE DISPLAY. IT STAYS STUCK FOR A FEW MINUTES WHEN IT HAPPENS. I TRY NOT ACCELERATE AND EVEN APPLY THE BRAKE, HOWEVER, THE NEEDLE REMAINS STUCK. THEN IT EVENTUALLY GOES BACK TO NORMAL. IT JUST RECE…
Read full complaint
IT IS AN INTERMITTENT PROBLEM. THE SPEEDOMETER GETS STUCK ON A NUMBER BUT THE CAR IS STILL GOING FASTER OR SLOWER THAN SHOWN ON THE DISPLAY. IT STAYS STUCK FOR A FEW MINUTES WHEN IT HAPPENS. I TRY NOT ACCELERATE AND EVEN APPLY THE BRAKE, HOWEVER, THE NEEDLE REMAINS STUCK. THEN IT EVENTUALLY GOES BACK TO NORMAL. IT JUST RECENTLY HAPPENED AGAIN, SO I WAS CHECKING TO SEE IF A RECALL WAS ISSUED FOR THIS PROBLEM. IT WAS INVESTIGATED AS I SEE HERE, HOWEVER, IT WAS NOT RECALLED. THIS IS A DEFECT. I AM SURE, NOT POSITIVE THAT OTHER PEOPLE ARE HAVING THE SAME PROBLEM WITH THEIR CARAVANS. NOTE, AUTOMOBILE STILLS ACCELERATES AND SLOWS BUT THE ACTUAL SPEED IS NOT KNOWN BECAUSE THE NEEDLE IS STUCK. *JB
NHTSA ODI #10010275
Mileage unknown · Mar 10, 2003
Engine And Engine Cooling
THE VEHICLE STALLED WITHOUT WARNING. VEHICLE WAS REPAIRED AND KEPT IN THE GARAGE.*JB
NHTSA ODI #10011304
67,723 miles · Mar 5, 2003
Power Train
COMPLETE TRANSMISSION FAILURE ON A 1999 DODGE GE AND CARAVAN VIN# [XXX] AT 67,723 MILES. NO HELP FROM CHRYSLER ON THIS PROBLEM, BECAUSE OF HIGH MILEAGE. TRANSMISSIONS SHOULD NOT FAIL THIS SOON. WE HAD A TRANSMISSION FAILURE ON ANOTHER GRAND CARAVAN WITH VIN# [XXX] THAT HAD 37,491 MILES ON IT THAT WAS MOSTLY COVERED BY THEM. …
Read full complaint
COMPLETE TRANSMISSION FAILURE ON A 1999 DODGE GE AND CARAVAN VIN# [XXX] AT 67,723 MILES. NO HELP FROM CHRYSLER ON THIS PROBLEM, BECAUSE OF HIGH MILEAGE. TRANSMISSIONS SHOULD NOT FAIL THIS SOON. WE HAD A TRANSMISSION FAILURE ON ANOTHER GRAND CARAVAN WITH VIN# [XXX] THAT HAD 37,491 MILES ON IT THAT WAS MOSTLY COVERED BY THEM. THESE VEHICLES APPEAR TO HAVE DEFECTS AND SHOULD BE COVERED BY CHRYSLER AND BUILT TO LAST. *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10008428
Mileage unknown · Mar 3, 2003
Air Bags
THERE WAS A RECALL ON DODGE, CARAVAN, 1998 FOR A FLAW IN THE AIR BAG, WHICH CAUSED THE CRUISE CONTROL TO RELEASE AUTOMATICALLY. CONSUMER FELT THAT RECALL SHOULD EXTEND TO DODGE, CARAVAN, 1999.*AK *JB
NHTSA ODI #10007261
Mileage unknown · Feb 26, 2003
Engine And Engine Cooling
THE VEHICLE STALLED WITHOUT WARNING. *JB
NHTSA ODI #10009458
Mileage unknown · Feb 19, 2003
Engine And Engine CoolingPower Train
ENGINE RACES, THE TRANSMISSION WHINES AND CHANGES GEARS WHILE IN THE PARK POSITION. THE CONSUMER ALSO COMPLAINED OF ANOTHER VEHICLE SHE OWNS A 1996 CHRYSLER CIRRUS. THE KEY LOCK WAS REPLACED 3 TIMES AND IT ACCELERATED ON ITS OWN. *JB
NHTSA ODI #10008683
Mileage unknown · Feb 12, 2003
Service Brakes, Hydraulic
THE ROTORS CORRODED, WHICH CAUSED EXTENDED STOPPING DISTANCE.*JB
NHTSA ODI #10007123
Mileage unknown · Feb 10, 2003
Air Bags
THERE WAS A RECALL REGARDING THE CLOCK SPRING, HOWEVER CONSUMER WAS INFORMED VEHICLE WAS NOT INCLUDED, DUE TO THE VEHICLE IDENTIFICATION NUMBER.*JB
NHTSA ODI #10006835
64,000 miles · Feb 6, 2003
Electrical System
HORN DOES NOT WORK, HAS BEEN REPAIRED TWICE. DEALER NOTIFIED. PLEASE PROVIDE ADDITIONAL INFORMATION. PH
NHTSA ODI #10006706
88,000 miles · Feb 4, 2003
Power Train
WHILE DRIVING, THE VEHICLE STALLED OUT. THE DEALERSHIP INDICATED THAT THIS WAS CAUSED BY A PIN IN THE AUTOMATIC TRANSMISSION WHICH WAS COMING A LOOSE, AND HAD BLOWN A HOLE IN THE TRANSMISSION. PH SCC
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1999 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration