IllustrationTwice over the winter my serpentine belt came off as I was driving through a puddle. Nothing deeper than a few inches. It also happened once last year.
2000 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 2000 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3825–50K
5350–75K
4375–100K
44100–150K
25150K+
222 reports with mileage · 248 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
65 crash reports5 fire reports44 injury reports
What owners actually said
470 reportsBelt under hood keeps falling off and or breaking car seizes up and locks up almost crashed a few times Also engine problems smokes a lot wipers don’t work windows won’t go down also transmission jerks when driving
VEHICLE WAS IN MOTION- WHILE DRIVING ALONG I HEARD AND FELT A LOUD NOISE (BOOM) FROM REAR OF VEHICLE-VEHICLE THEN SWERVED WILDLY OUT OF CONTROL SPINNING AROUND AND TAKING DOWN SIGNS, MAILBOX-AFTER LOOKING AT VAN IT IS APPARENT THAT THE REAR AXLE SLID BACKWARDS IN WHEEL WELL. WHILE BODY IS RUST FREE, UNDERCARRIAGE HAS EXCESSIVE…
Read full complaint
VEHICLE WAS IN MOTION- WHILE DRIVING ALONG I HEARD AND FELT A LOUD NOISE (BOOM) FROM REAR OF VEHICLE-VEHICLE THEN SWERVED WILDLY OUT OF CONTROL SPINNING AROUND AND TAKING DOWN SIGNS, MAILBOX-AFTER LOOKING AT VAN IT IS APPARENT THAT THE REAR AXLE SLID BACKWARDS IN WHEEL WELL. WHILE BODY IS RUST FREE, UNDERCARRIAGE HAS EXCESSIVE RUST IN SPRING HANGER AREA-VAN HAS BEEN PARKED ON PAVEMENT ITS ENTIRE LIFE.
THE CONSUMER STATED THIS IS THE 2ND TIME THE CHILD SEAT BELT BECAME JAMMED AND WAS NOT ABLE TO GET HIS NEPHEW OUT OF THE SEAT. *TR
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE POWER STEERING SEIZED FOR THE THIRD TIME. AFTER THE PREVIOUS FAILURES, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE SERPENTINE BELT SLIPPED OFF AND NEEDED TO BE REPLACED. AFTER THE RECENT FAILURE, THE VEHICLE WAS NOT DI…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE POWER STEERING SEIZED FOR THE THIRD TIME. AFTER THE PREVIOUS FAILURES, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE SERPENTINE BELT SLIPPED OFF AND NEEDED TO BE REPLACED. AFTER THE RECENT FAILURE, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING 40 MPH, THE AIR BAG WARNING INDICATOR FLASHED ON AND OFF INTERMITTENTLY, WHICH WAS A SAFETY CONCERN. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 166,000.
2000 DODGE MINI VAN. CONSUMER WRITES IN REGARDS TO SEAT BELT MALFUNCTION. *SMD THE CONSUMER STATED THE SEAT BELT BECAME TOO TIGHT AROUND A CHILD PASSENGER. THE SEAT BELT HAD TO BE CUT ON 2 SEPARATE OCCASIONS.*JS THE CONSUMER STATED THE POWER CONTROL MODULE BOX MALFUNCTIONED. THE VEHICLE WOULD CUT OFF AND THE ENGINE WOULD…
Read full complaint
2000 DODGE MINI VAN. CONSUMER WRITES IN REGARDS TO SEAT BELT MALFUNCTION. *SMD THE CONSUMER STATED THE SEAT BELT BECAME TOO TIGHT AROUND A CHILD PASSENGER. THE SEAT BELT HAD TO BE CUT ON 2 SEPARATE OCCASIONS.*JS THE CONSUMER STATED THE POWER CONTROL MODULE BOX MALFUNCTIONED. THE VEHICLE WOULD CUT OFF AND THE ENGINE WOULD REV UP TO 3,000 RPMS. *JS
TL* TAKATA RECALL. THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED (EASTCHESTER…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 04V480000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED (EASTCHESTER CHRYSLER, JEEP, DODGE, 4007 BOSTON ROAD, BRONX, NY) AND A REPAIR APPOINTMENT WAS SCHEDULED. AFTER TWO HOURS OF WAITING AT THE DEALER'S, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE, BUT OFFERED NO ASSISTANCE. ALSO, WHENEVER THE VEHICLE WAS STARTED, OIL FUMES WERE NOTICED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 11,444. PARTS DISTRIBUTION DISCONNECT.
STRUT TOWERS IN ENGINE COMPARTMENT RUSTED THROUGH ESPECIALLY ON THE RIGHT. I'VE BEEN TOLD BY A MECHANIC AND OTHERS THAT THE STRUT TOWER MAY FAIL COMPLETELY AND PUSH UP THROUGH THE HOOD, CAUSING ACCIDENT AND INJURY TO DRIVER (ME).
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, ANOTHER VEHICLE COLLIDED WITH THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE VEHICLE DID NOT HAVE AIR BAGS AND THE HORN MALFUNCTIONED. THE CONTACT RECEIVED INJURIES TO THE LEFT SHOULDER, NECK, BACK, AND HEAD THAT REQUIRED MEDICAL ATTENTION. A POLI…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, ANOTHER VEHICLE COLLIDED WITH THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE VEHICLE DID NOT HAVE AIR BAGS AND THE HORN MALFUNCTIONED. THE CONTACT RECEIVED INJURIES TO THE LEFT SHOULDER, NECK, BACK, AND HEAD THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN AUTO MECHANIC FACILITY WITH PENDING DIAGNOSTIC RESULTS. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 296,000.
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available