IllustrationMY SUSPENSION BOTTOMS OUT ON ME NO MATTER WHERE I AM AT. MY FRONT SEATS WILL NOT MOVE BACK AND FORTH AT DUE TO THE HANDLE MECHANISM BREAKING. MY HEADLIGHT ASSEMBLIES DO NOT PUT OUT THE RIGHT BEAM OF LIGHT THE IT NEEDS TO BE ABLE TO SEE PROPERLY AT NIGHT. I NEED YOUR HELP IN THIS MATTER PLEASE. *TR
1999 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1999 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
2825–50K
5650–75K
5075–100K
58100–150K
24150K+
230 reports with mileage · 325 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports14 fire reports28 injury reports
Suspension complaints
33 reportsTL* THE CONTACT OWNS A 1999 DODGE CARAVAN. THE CONTACT STATED THAT THE TOWER STRUT WAS RUSTED. THE VEHICLE WAS TAKEN TO A MECHANIC FOR DIAGNOSTIC TESTING, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
PREPARING TO EXIT A PARKING LOT, THE GEAR SHIFT WAS ACCIDENTALLY CAUGHT BY MY SLEEVE AND PULLED DOWN TO THE "DRIVE" POSITION. THE VEHICLE WAS NOT RUNNING, BUT IT BEGAN TO MOVE FORWARD. BEING ON SOMEWHAT OF A SLOPE, THE VEHICLE PULLED ONTO A BUSY STREET. I GRABBED THE WHEEL TO TURN THE VAN AWAY FROM TRAFFIC, BUT IT HIT AND SCRAPE…
Read full complaint
PREPARING TO EXIT A PARKING LOT, THE GEAR SHIFT WAS ACCIDENTALLY CAUGHT BY MY SLEEVE AND PULLED DOWN TO THE "DRIVE" POSITION. THE VEHICLE WAS NOT RUNNING, BUT IT BEGAN TO MOVE FORWARD. BEING ON SOMEWHAT OF A SLOPE, THE VEHICLE PULLED ONTO A BUSY STREET. I GRABBED THE WHEEL TO TURN THE VAN AWAY FROM TRAFFIC, BUT IT HIT AND SCRAPED AGAINST A HIGH CURB, FLATTENING 2 TIRES, DAMAGING THE WHEELS/RIMS OF THOSE TIRES, BENDING A STRUT AND OTHER DAMAGE TO THE SUSPENSION (I GOT A REPAIR ESTIMATE FROM FIRESTONE, WHICH TOTALED OVER $1,900.00). I DIDN'T THINK IT WAS POSSIBLE FOR THE GEAR SHIFT TO MOVE WITHOUT HAVING MY FOOT ON THE BRAKE, BUT MOVE IT DID AND SO DID THE VAN. OTHER THAN BEING FRIGHTENED AND SHAKEN, WE WERE FORTUNATE THAT NO PHYSICAL INJURIES OCCURRED. HOWEVER, HAD I NOT HAD THAT SPLIT SECOND REACTION TO TURN THE STEERING WHEEL, THERE WOULD HAVE BEEN A VERY BAD COLLISION WITH AT LEAST TWO VEHICLES DRIVING DOWN THE BUSY STREET. WONDERING WHY THE GEAR SHIFT WAS ABLE TO MOVE WITHOUT THE CAR RUNNING AND WITHOUT MY FOOT ON THE BRAKE, I DID SOME RESEARCH AND FOUND THAT CHRYSLER KNOWS ABOUT THIS GRIEVOUS OMISSION AND DID NOT WANT TO SPEND THE EXTRA $9.00 PER VAN TO INSTALL A BRAKE SHIFT INTERLOCK. I'M INCREDULOUS! I INTEND TO WRITE TO CHRYSLER IN HOPES OF BEING REIMBURSED FOR THE DAMAGES SUSTAINED TO MY VEHICLE, BUT FIRST WANTED TO REPORT THIS INCIDENT TO THE APPROPRIATE AGENCY. *TR
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT CLUSTER FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE WIRING HARNESS WAS RUSTED AND WOULD NEED REPLACING. IN ADDITION, THE FRONT STRUT TOWER ASSEMBLY WAS ALSO FOUND TO BE COMPLETELY RUSTED. THE DEALER AD…
Read full complaint
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT CLUSTER FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE WIRING HARNESS WAS RUSTED AND WOULD NEED REPLACING. IN ADDITION, THE FRONT STRUT TOWER ASSEMBLY WAS ALSO FOUND TO BE COMPLETELY RUSTED. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE COULD NOT BE ALIGNED AND WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
THE LEFT HAND STRUT TOWER ON MY 1999 DODGE CARAVAN HAS ALMOST RUSTED THROUGH AND I WAS TOLD BY MECHANIC THAT IT IS NOT SAFE TO DRIVE. LOCAL DODGE DEALER SAID THIS IS NOT COVERED UNDER ANY WARRANTY OR RECALL AND THAT IT'S ONLY A COMESTIC PROBLEM. THEY WANT $2200 TO REPAIR WHICH IS MORE THAN VALUE OF VEHICLE. EVERYTHING I HAVE …
Read full complaint
THE LEFT HAND STRUT TOWER ON MY 1999 DODGE CARAVAN HAS ALMOST RUSTED THROUGH AND I WAS TOLD BY MECHANIC THAT IT IS NOT SAFE TO DRIVE. LOCAL DODGE DEALER SAID THIS IS NOT COVERED UNDER ANY WARRANTY OR RECALL AND THAT IT'S ONLY A COMESTIC PROBLEM. THEY WANT $2200 TO REPAIR WHICH IS MORE THAN VALUE OF VEHICLE. EVERYTHING I HAVE READ INDICATES THIS IS ABSOLUTELY A SAFETY ISSUE AND WOULD CAUSE A CRASH IF DRIVING WHEN THE STRUT TOWER COMPLETELY FAILS. WHY IS THERE NOT A RECALL FOR THIS WELL KNOWN AND DOCEMENTED SAFETY PROBLEM? *TR
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. THE CONTACT STATED A PRIVATE MECHANIC ADVISED THAT THE STRUT TOWERS ON THE VEHICLE WERE CORRODED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 155,000. UPDATED 01/10/12*LJ
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. WHILE AT THE DEALER FOR ROUTINE MAINTENANCE THE TECHNICIAN STATED THERE WAS A HOLE CAUSED BY CORROSION ON THE FRONT DRIVERS SIDE STRUT HOUSING TOWER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
STRUT TOWER CORROSION. *TR
BOTH STRUT TOWER CAPS RUSTED OUT. *TR
FRONT STRUT MOUNTS BREAKING CAUSING LOSS OF STEERING CONTROL. *TR
Official recalls
504V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V119000 · Seat Belts:front:retractor
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available