IllustrationMY SUSPENSION BOTTOMS OUT ON ME NO MATTER WHERE I AM AT. MY FRONT SEATS WILL NOT MOVE BACK AND FORTH AT DUE TO THE HANDLE MECHANISM BREAKING. MY HEADLIGHT ASSEMBLIES DO NOT PUT OUT THE RIGHT BEAM OF LIGHT THE IT NEEDS TO BE ABLE TO SEE PROPERLY AT NIGHT. I NEED YOUR HELP IN THIS MATTER PLEASE. *TR
1999 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 1999 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
2825–50K
5650–75K
5075–100K
58100–150K
24150K+
230 reports with mileage · 325 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports14 fire reports28 injury reports
Exterior Lighting complaints
16 reportsWHILE DRIVING THE VEHICLE, THE INSTRUMENT PANEL SHUTS OFF WITHOUT WARNING AND FOR NO KNOWN REASON. DODGE TOLD US THAT IT WAS A SHORT IN THE WIRING IN THE DASH THAT CAUSED THE COMPUTER TO SHUT DOWN. THE TECHNICIANS INSISTED THAT THE PROBLEM WOULD BE IMPOSSIBLE TO FIND, ESPECIALLY SINCE IT COULD NOT BE REPLICATED ON DEMAND. THIS H…
Read full complaint
WHILE DRIVING THE VEHICLE, THE INSTRUMENT PANEL SHUTS OFF WITHOUT WARNING AND FOR NO KNOWN REASON. DODGE TOLD US THAT IT WAS A SHORT IN THE WIRING IN THE DASH THAT CAUSED THE COMPUTER TO SHUT DOWN. THE TECHNICIANS INSISTED THAT THE PROBLEM WOULD BE IMPOSSIBLE TO FIND, ESPECIALLY SINCE IT COULD NOT BE REPLICATED ON DEMAND. THIS HAS CONTINUED TO HAPPEN PERIODICALLY, MOST RECENTLY IN JANUARY 2014, WHEN THE COMPUTER WENT OUT, SHUTTING DOWN THE INSTRUMENT PANEL AND THE WHEELS ON THE PASSENGER SIDE OF THE VEHICLE. THE DRIVER'S SIDE CONTINUED FORWARD, WHICH PUSHED THE VEHICLE INTO A CURB, FLATTENING TWO TIRES AND DAMAGING THOSE RESPECTIVE RIMS. ALTHOUGH NO ONE WAS INJURED, HAD THERE BEEN A VEHICLE NEXT TO THE VAN, AS OPPOSED TO A HIGH CURB, THE DEFECT IN THE VEHICLES WIRING AND COMPUTER WOULD HAVE CAUSED A COLLISION. THERE IS NEVER ANY WARNING PRIOR TO THE ELECTRICAL AND INSTRUMENT PANEL GOING OUT. THERE IS NO KNOWN TRIGGER THAT CAUSES THIS PROBLEM. IT IS NOT TRIGGERED BY GOING OVER A BUMP, DRIVING AT ANY PARTICULAR SPEED, STOPPING OR ACCELERATING. I WANTED TO REPORT THIS, BECAUSE A WITNESS (WHO HAPPENED TO BE A POLICE OFFICER) TO THE MOST RECENT INCIDENT ADVISED US THAT THIS IS A KNOWN AND COMMON ISSUE IN DODGE CARAVANS BUILT IN THE LATE 1990S/EARLY 2000S. *TR
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. ON APRIL 24, 2008, WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE LIGHT ON THE INSTRUMENT CONTROL PANEL ILLUMINATED, AND THE TEMPERATURE OF THE VEHICLE INCREASED. THE CONTACT PULLED OVER TO ALLOW THE VEHICLE TO COOL. HE RESTARTED THE VEHICLE AND DROVE HOME. THE DEALER INSTRUCT…
Read full complaint
TL* THE CONTACT OWNS A 1999 DODGE CARAVAN. ON APRIL 24, 2008, WHILE DRIVING APPROXIMATELY 25 MPH, THE CHECK ENGINE LIGHT ON THE INSTRUMENT CONTROL PANEL ILLUMINATED, AND THE TEMPERATURE OF THE VEHICLE INCREASED. THE CONTACT PULLED OVER TO ALLOW THE VEHICLE TO COOL. HE RESTARTED THE VEHICLE AND DROVE HOME. THE DEALER INSTRUCTED HIM TO BRING THE VEHICLE IN TO BE DIAGNOSED; HOWEVER, THE VEHICLE WAS NOT IN DRIVING CONDITION AND NO LONGER COVERED UNDER WARRANTY. THE CONTACT REPAIRED THE VEHICLE HIMSELF. THE FAILURE MILEAGE WAS 91,000 AND CURRENT MILEAGE WAS 91,929. UPDATED 07/07/08.*LJ THE FAN RELAY SWITCH WAS REPLACED TWICE. THE DEALER REPLACED THE WIRING HARNESS. THE HEADLIGHT HAD CONDENSATION ON THEINSIDE. UPDATED
TL*THE CONTACT OWNS A 1999 DODGE CARAVAN. WHILE DRIVING 5 MPH, THE BRAKE LIGHTS FAILED TO ILLUMINATE AND THE HORN NO LONGER WORKED. ALSO, THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 74,000 AND FAILURE MILEAGE WAS APPRO…
Read full complaint
TL*THE CONTACT OWNS A 1999 DODGE CARAVAN. WHILE DRIVING 5 MPH, THE BRAKE LIGHTS FAILED TO ILLUMINATE AND THE HORN NO LONGER WORKED. ALSO, THE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 74,000 AND FAILURE MILEAGE WAS APPROXIMATELY 73,500.
MY 1999 DODGE CARAVAN HAS PLASTIC HEADLIGHTS COVERS. THE LEFT SIDE IS SO BAD IT HAS REDUCED THE OUT PUT BY HALF. I HAD A ACCIDENT THAT CAUSED THE RIGHT PLASTIC ON TO BE REPLACED. SO I BELIEVE ANY ONE WHO HAS NOT REPLACED THESE EXPENSIVE COVERS HAS LOST THERE OUT PUT OF THESE & NOT KNOW IT BECAUSE THEY CAN NOT COMPARE IT AGAINS…
Read full complaint
MY 1999 DODGE CARAVAN HAS PLASTIC HEADLIGHTS COVERS. THE LEFT SIDE IS SO BAD IT HAS REDUCED THE OUT PUT BY HALF. I HAD A ACCIDENT THAT CAUSED THE RIGHT PLASTIC ON TO BE REPLACED. SO I BELIEVE ANY ONE WHO HAS NOT REPLACED THESE EXPENSIVE COVERS HAS LOST THERE OUT PUT OF THESE & NOT KNOW IT BECAUSE THEY CAN NOT COMPARE IT AGAINST A GOOD ONE. *NM
THE LEVER AND BOLT BROKE OFF THE DRIVER'S SEAT. THE SEAT IS UNABLE TO RECLINE, CAUSING THE DRIVER TO BE UNCOMFORTABLE WHILE DRIVING. CONSUMER WILL NOTIFY THE MANUFACTURER.*AK. ALSO, THIRD BRAKE LIGHT BULBS MALFUNCTIONED, BULD WAS REPLACED. *AK THE DRIVER'S SEAT ADJUSTER HANDLE BROKE. *NM
PLASTIC COVER ON HEADLIGHTS DETERIORATED. THIS AFFECTED THE LIGHT BULB. THE DRIVER HAS DIFFICULTY SEEING THE ROAD AT NIGHT.*AK *TC
THE HAZARD FLASHING WARNING LIGHTS WOULD INTERMITTENTLY ILLUMINATE WHEN MAKING LEFT TURNS. DEALER WAS NOT NOTIFIED. *AK
THE HEADLIGHTS LENS DEVELOPED A CLOUDY DISCOLORATION WHICH REDUCED THE HEADLIGHTS ILLUMINATION. THIS RESULTED IN POOR VISIBILITY. THE DEALERSHIP REPLACED THE ENTIRE HEADLIGHT ASSEMBLY TO CORRECT THE PROBLEM. THE PARTS WERE $260.00 PER HEADLIGHT. *AK THE REPORTS STATED THAT THIS WAS A COMMON PROBLEM IN ALL CARAVANS. *SC…
Read full complaint
THE HEADLIGHTS LENS DEVELOPED A CLOUDY DISCOLORATION WHICH REDUCED THE HEADLIGHTS ILLUMINATION. THIS RESULTED IN POOR VISIBILITY. THE DEALERSHIP REPLACED THE ENTIRE HEADLIGHT ASSEMBLY TO CORRECT THE PROBLEM. THE PARTS WERE $260.00 PER HEADLIGHT. *AK THE REPORTS STATED THAT THIS WAS A COMMON PROBLEM IN ALL CARAVANS. *SC *JB
THE PLASTIC HEADLIGHT LENS DEVELOPED AN OPAQUE COLOR THAT REDUCED THE LIGHTS ILLUMINATION. TO CORRECT THIS PROBLEM THE ENTIRE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED.*AK *JB
Official recalls
504V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V119000 · Seat Belts:front:retractor
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available