IllustrationBRAKES KEEP WEARING OUT ON THIS VEHICLE. 4 BRAKE JOBS AND IT ONLY HAS 55,000 MILES AND WE BABY THIS VAN.*AK
2000 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
625–50K
1050–75K
275–100K
2100–150K
1150K+
26 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Service Brakes, Hydraulic complaints
17 reportsWHILE DRIVING , THE DRIVER AND PASSENGER SIDE SEAT SNAPPED OFF THE BASE, ON DIFFERENT OCCASIONS. *AK THE SEAT BELTS UNLATCHED BY THEMSELVES, THE REAR BENCH SEAT FAILED TO STAY TIGHT, THE SIDE DOORS WERE DIFFICULT TO OPEN AND THE OUTSIDE MIRRORS VIBRATED AND THE BRAKES WERE FAULTY *JB *NM
WHILE DRIVING FRONT BRAKES WOULD GET TOO HOT, CAUSING EXTENDED STOPPING DISTANCE. DEALER HAS BEEN NOTIFIED. *AK THE PASSENGER FRONT SIDE WHEEL SPEED SENSOR MELTED, THE ROTORS SHOWED MANY CRACKS IN THE SURFACE, AND THE CALIPER HAD BEEN REPLACED. THE FRONT WHEEL BEARINGS SHOWED SIGNS OF HEAT. THE CONSUMER REQUESTED TO BE INFOR…
Read full complaint
WHILE DRIVING FRONT BRAKES WOULD GET TOO HOT, CAUSING EXTENDED STOPPING DISTANCE. DEALER HAS BEEN NOTIFIED. *AK THE PASSENGER FRONT SIDE WHEEL SPEED SENSOR MELTED, THE ROTORS SHOWED MANY CRACKS IN THE SURFACE, AND THE CALIPER HAD BEEN REPLACED. THE FRONT WHEEL BEARINGS SHOWED SIGNS OF HEAT. THE CONSUMER REQUESTED TO BE INFORMED ABOUT THIS PROBLEM. *SCC *JB
THERE WAS VIBRATION WHEN APPLYING BRAKES. FRONT ROTORS HAVE BEEN TURNED ONCE, THEN REPLACED DUE TO WARPING.*AK
FRONT BRAKES ARE WEARING OUT PREMATURELY, IT CAUSES FRONT WHEEL TO LOCK UP. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK
REPAIRS TO THE BRAKES 8 TIMES, MELTED THREE SETS OF ABS SENSORS, BURNT TWO SETS OF CALIPERS AND BEARINGS OUT, MELTED THE HUB CAPS OFF TWICE. MADE EIGHT ATTEMPS TO REPAIR TO NO AVAIL.
WHILE DRIVING ABOUT 30 MPH APPLIED BRAKES, PEDAL FELT SPONGY AND WENT TO THE FLOOR. NO BRAKING ACTION, HIT VEHICLE IN FRONT. $ 1200.00 DAMAGE. DEALER SAID THERE WAS NOTHING WRONG WITH BRAKES. CONSUMER THEN WENT TO ANOTHER DEALER, WAS TOLD REAR BRAKES WERE NOT FUNCTIONAL. CHEVROLET TOOK NO RESPONSIBILITY FOR ACCIDENT.*AK
WHEN TRAVELING THERE IS NO CERTAIN SPEED, AND STEERING IS HARD TO STEER. WHEN APPLYING BRAKES VEHICLE DOESN'T STOP, RESULTS IN EXTENDED STOPPING DISTANCE. *AK SHAFT BROKE IN POWER STEETING PUMP AND FRONT BRAKES FAILED. *YH
GLADIATOR CONVERSION, THERE IS PROBLEM WITH RIGHT WHEEL WHICH IS CAUSING BOTH BRAKES TO WEAR OUT EVERY 1500 TO 1800 MILES. DEALER HAS CHANGED SPRING COIL TWICE ON RIGHT WHEEL AND ONCE IN THE LEFT WHEEL, BUT PROBLEM STILL OCCURS.*AK
THERE IS A CLUNKING NOISE WHEN APPLYING BRAKES AT SPEEDS OF 20 MPH, AND UNDER ON BOTH CORNERS OF FRONT END. AFTER 13 ATTEMPTS OF TRYING TO FIX DEFECT , MANUFACTURER IS BUYING VEHICLE BACK. *AK *SLC
Official recalls
100V085000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 16, 2000
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.