IllustrationOdometer Fraud. The contact purchased a 2003 Chevrolet Express. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was approximately 156,000. It was later discovered that the mileage on July 2, 2024, was 258,051.
2003 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
825–50K
850–75K
275–100K
4100–150K
7150K+
45 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports7 fire reports1 injury reports
What owners actually said
58 reportsTHE FRAME AND ITS CROSSMEMBERS ARE RUSTED (ROTTED) THRU ABOVE THE GAS TANK MAKING THE VAN USELESS. THE GAS TANK IS EVEN ATTACHED AT THOSE AREAS MAKING IT A TICKING TIME BOMB. THIS IS A KNOW GM FRAME PROBLEM FOR MANY YEARS ON MANY TRUCK BODIES.
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED T…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED THAT THE REAR DRIVER AND PASSENGER SIDE DOOR HINGES FRACTURED. THE CONTACT STATED THAT THE DOORS WERE GLUED SHUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 228,000. UPDATED 10/17*LJ UPDATED 10/4/18*JB
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE FRONT OF THE VEHICLE VIBRATED WHENEVER THE VEHICLE WAS BEING DRIVEN OVER 30 MPH OVER A BUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTROL ARMS, THE PITMAN ARM, THE TIRES AND THE HUBS WERE REPLACED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE FRONT OF THE VEHICLE VIBRATED WHENEVER THE VEHICLE WAS BEING DRIVEN OVER 30 MPH OVER A BUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTROL ARMS, THE PITMAN ARM, THE TIRES AND THE HUBS WERE REPLACED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE. ....UPDATED 07/22/15 *BF UPDATED 10/4/2017*CN
I RECEIVED A NOTICE FROM GM ( DOC ID #32202443, #12167 FUEL FILLER PIPE CORROSION) STATING THAT THERE WAS A RECALL ON MY VEHICLE FOR LEAKING GASOLINE. I BROUGHT IT TO SIGHN CHEVROLET IN RIVERSIDE CA AND THE SERVICE MANAGER TOLD ME THAT CA VEHICLES DO NOT QUALIFY. I CONTACTED CUSTOMER COMPLAINTS CASE # [XXX] AND ALL THEY DID WAS …
Read full complaint
I RECEIVED A NOTICE FROM GM ( DOC ID #32202443, #12167 FUEL FILLER PIPE CORROSION) STATING THAT THERE WAS A RECALL ON MY VEHICLE FOR LEAKING GASOLINE. I BROUGHT IT TO SIGHN CHEVROLET IN RIVERSIDE CA AND THE SERVICE MANAGER TOLD ME THAT CA VEHICLES DO NOT QUALIFY. I CONTACTED CUSTOMER COMPLAINTS CASE # [XXX] AND ALL THEY DID WAS CALL THE SAME SERVICE MANAGER AND GOT BACK TO ME SAYING THEY WON'T FIX IT. I BELIEVE I AM DRIVING AROUND WITH A VEHICLE LEAKING GAS ON THE ROAD CREATING AN EXTREMELY DANGEROUS SITUATION FOR MY FAMILY WITH A DIRE FIRE HAZARD. MY CONTENTION IS, WHY WOULD THEY SEND ME A RECALL NOTICE AND THEN TELL ME I DON'T QUALIFY? I DID RECEIVE THE NOTICE AND IT SAID IT HAD TO BE ACTED ON BEFORE 12/31/12 BUT IT WAS NOT LEAKING THEN. I DON'T CARE WHEN IT EXPIRES. IT IS A ADMITTED DEFECT AND GM SHOULD STAND BEHIND THEIR DANGEROUS ERRORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR
MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE …
Read full complaint
MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE ARE NO SPECIFIC ACTIONS I CAN TAKE TO TRIGGER THE ERRATIC SYMPTOM, NOR ANY SPECIFIC ACTION I CAN TAKE TO CAUSE NORMAL OPERATION. WITH SNOW AND ICE ON THE ROADS AT THIS TIME OF THE YEAR THIS IS EXTREMELY DANGEROUS AS IT COULD CAUSE THE VAN TO LOCK UP THE REAR WHEELS ON SLIPPERY PAVEMENT CAUSING LACK OF CONTROL. THIS CONDITION CAN OCCUR REGARDLESS OF WHETHER OR NOT CRUISE CONTROL IS SELECTED, REGARDLESS OF THE GEAR I MANUALLY SELECT, AND REGARDLESS OF THE TRAILER MODE BEING SELECTED OR NOT. SIMULTANEOUSLY THE "CHECK ENGINE" LIGHT GOES ON, THE "ABS LIGHT" AND "BRAKES" LIGHTS ARE LIT ON THE DASHBOARD ALTHOUGH NO BRAKING ABNORMALITIES ARE NOTED. I REPORTED A LESS SEVERE CASE OF THIS SEVERAL MONTHS AGO, BUT RECEIVED NO REPLY FROM THE NHTSA. DOING INTERNET RESEARCH I FIND THAT IT MAY BE A DEFECTIVE SPEEDOMETER DASHBOARD ASSEMBLY THAT WOULD NEED TO BE SENT AWAY FOR REPAIR/EXCHANGE. THEY REQUIRE A LARGE DEPOSIT IN ORDER TO GO THRU THE VERIFICATION PROCESS THAT THE ODOMETER READING I REPORT IS THE SAME AS THE UNIT I SEND IN. PART COST WITH DEPOSIT IS CLOSE TO $600, AND THEY SHOW AN ONLINE INTERNET VIDEO OF HOW TO REMOVE THE DASHBOARD UNIT WHICH TAKES LESS THAN 3 MINUTES. I'VE READ THIS IS A COMMON PROBLEM WITH THIS VEHICLE MAKE, MODEL AND YEAR. I AM THE ORIGINAL OWNER SINCE NEW, AND IT HAS LESS THAN 17,000 ACTUAL MILES ON IT. *TR
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT INDICATED THAT AFTER REFUELING, FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FILLER NECK NEEDED TO BE REPLACED AND THE METAL FUEL FILLER PIPE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT INDICATED THAT AFTER REFUELING, FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FILLER NECK NEEDED TO BE REPLACED AND THE METAL FUEL FILLER PIPE WAS CORRODED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,500.
DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERR…
Read full complaint
DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERRATIC MOVEMENT ON MY CELL PHONE AS A VIDEO, SHOWING ROAD MOVEMENT + ALL GAUGES + AUDIO EVENTS LIKE ENGINE OVER-REVVING AT SAME TIME. THE VIDEO IS OF HIGH QUALITY AND THE EVENTS TAKING PLACE ARE DOCUMENTED WITH THE VIDEO. RURAL AREA WITH FEW CARS ON ROAD AT THE TIME. IF IT TOOK PLACE IN A CITY INTERSTATE ENVIRONMENT (ESPECIALLY IN THE WINTER MONTHS) IT MIGHT HAVE CAUSED A MULTIPLE CAR COLLISION WITH SUDDEN UNEXPECTED DOWNSHIFTING THAT WAS OUT OF MY CONTROL. ENGINE RPM ALSO HUNTS ERRATICALLY AND OUT OF MY CONTROL. PREDICTABLE IN WHAT IT DOES, IT BEGINS APPROXIMATELY WITHIN A RANGE OF 4-8 MILES AFTER LEAVING HOME DAILY. WHEN ENGINE TURNED OFF AND PARKED AT A LOCAL STORE AS AN EXAMPLE, IT WILL CLEAR IT'S PROBLEM AS IF A CPU IS "RE-BOOTED", AND REPEAT THE CYCLE OF ERRATIC BEHAVIOR FROM THAT NEW STARTING POINT. WHEN I BOUGHT + INSTALLED ACTRON BRAND OBD-II CODE READER WHICH FEATURES ABILITY TO REVEAL ABS BRAKE CODES, IT NEVER SHOWS ANY OTHER STORED CODES EXCEPT A SINGLE PO446 WHICH IS AN EMISSIONS RELATED CODE. THIS VAN WAS ORIGINALLY SENT NEW BY THE SELLING NH CHEVROLET DEALER TO THE PENNSYLVANIA BASED QUIGLEY CONVERSION FACILITY, SO IN FEBRUARY 2004 WAS MODIFIED FROM RWD TO A 4WD BY EXCHANGING STOCK MODEL 2500 FRONT END FOR A 4 WD PICKUP TRUCK NEW FACTORY FRONT END WITH 4WDL, NEUTRAL, 2WDH 4WDH FLOOR CONTROL LEVER. THE DRIVER'S DOOR JAM HAS AN 8600 LB GVW CERTIFICATION WHICH IS APPROPRIATELY QUIGLEY'S. MY VERY LOW ODOMETER AT 16,614 MILES IS ACCURATE, AS I ALSO HAVE OTHER VEHICLES TO USE, AND WORK AT HOME. *TR
THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS W…
Read full complaint
THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR
FOR THE SECOND TIME IN ONE WEEK THE ENGINE RACED TO MAX RPM WITHOUT A THROTTLE INPUT. HAD TO PUT IT IN NEUTRAL TO SLOW DOWN WITH THE BRAKES. THE FIRST TIME (35MPH SLOWING DOWN FOR A RED LIGHT) WENT TO NEUTRAL, FOOT ON BRAKE AND BACK TO DRIVE, THE ENGINE RESPONDED NORMALLY. LAST NIGHT THE ENGINE RACED TO MAX RPM AGAIN 100 FEET…
Read full complaint
FOR THE SECOND TIME IN ONE WEEK THE ENGINE RACED TO MAX RPM WITHOUT A THROTTLE INPUT. HAD TO PUT IT IN NEUTRAL TO SLOW DOWN WITH THE BRAKES. THE FIRST TIME (35MPH SLOWING DOWN FOR A RED LIGHT) WENT TO NEUTRAL, FOOT ON BRAKE AND BACK TO DRIVE, THE ENGINE RESPONDED NORMALLY. LAST NIGHT THE ENGINE RACED TO MAX RPM AGAIN 100 FEET FROM MY PARKING SPOT GOING LESS THAN 5MPH WENT TO NEUTRAL BACK TO DRIVE NO CHANGE IN ENGINE SPEED BACK TO NEUTRAL GLIDE TO PARKING SPOT TURNED ENGINE OFF. NO WARNING WHEN THE MAX ENGINE REV WOULD BEGIN, ONE WAS SLOW SPEED THE OTHER MODERATE SPEED, TEMP 75 ONE DAY, TEMP 45 YESTERDAY. WORKED FINE TODAY. WORRIED THE PROBLEM IS NOT REPEATABLE OR CAN BE FOUND USING A CODE READER. WORRIED THAT THE ONLY WAY NOW TO STOP MAX ENGINE RPM IS BY TURNING ENGINE OFF, NOT SAFE WHILE DRIVING ON THE INTERSTATE. *TT
Official recalls
1012V388000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Aug 8, 2012
General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.
Consequence & remedy
Consequence: Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire.
Remedy: GM will notify owners, and dealers will install a new fuel filler neck, free of charge. The safety recall began on October 1, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546 and GMC at 1-866-996-9463.
05V558000 · Seat Belts
Dec 19, 2005
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
04V225000 · Seat Belts:front:anchorage
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
04V045000 · Service Brakes, Hydraulic
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
03V217000 · Exterior Lighting
Jun 10, 2003
CERTAIN VANS HAVE A CONDITION IN WHICH WATER MAY ENTER AND CORRODE THE REAR LICENSE PLATE LAMP SOCKET. IF THE LAMP SOCKET WERE TO CORRODE, THE REAR LICENSE PLATE LAMP MAY OPERATE INTERMITTENTLY OR NOT AT ALL, AND THE LEFT REAR TAIL LAMP MAY BECOME INOPERATIVE. THE TEMPERATURE OF THE LICENSE PLATE LAMP SOCKET COULD INCREASE TO THE POINT THAT IT MAY BEGIN TO SOFTEN AND MELT.
Consequence & remedy
Consequence: IF THE SOCKET ASSEMBLY WERE TO REACH THE POINT OF MELTING, THE OCCUPANTS OF THE VEHICLE MAY NOTICE AN ODOR AND SMOKE AT THE REAR DOORS OF THE VEHICLE. IF THIS ODOR AND SMOKE WERE IGNORED, THE PLASTIC COULD IGNITE AND A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW SEALED REAR LICENSE PLATE LAMP SOCKET ASSEMBLY. OWNER NOTIFICATION BEGAN JULY 21, 2003. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
03V050000 · Seat Belts:front:buckle Assembly
Feb 14, 2003
ON CERTAIN VANS WITH A GROSS VEHICLE WEIGHT OF LESS THAN 8,500 POUNDS, DURING A VEHICLE CRASH SUFFICIENT ENOUGH TO DEPLOY THE SAFETY BELT PRETENSIONER, THE FRONT SAFETY BELT BUCKLES MAY NOT RELEASE AFTER THE VEHICLE CRASH, OR ALTERNATELY MAY EJECT THE SAFETY BELT LATCH DURING THE VEHICLE CRASH.
Consequence & remedy
Consequence: THIS COULD RESULT IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SIDE SAFETY BELT BUCKLE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
02V330000 · Steering:linkages
Dec 12, 2002
ON CERTAIN VANS WITH AN 8,500 LB. OR 8,600 LB. GROSS VEHICLE WEIGHT RATING, THE NUT ATTACHING THE PITMAN ARM TO THE STEERING LINKAGE MAY NOT BE TIGHTENED ADEQUATELY RESULTING IN A POSSIBLE SEPARATION.
Consequence & remedy
Consequence: A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, AND A CRASH COULD OCCUR WITH PRIOR WARNING.
Remedy: DEALERS WILL TIGHTEN THE PITMAN ARM NUT TO THE PROPER SPECIFICATION. IF THE NUT IS MISSING, THE DEALER WILL INSTALL A NEW NUT AND TIGHTEN IT CORRECTLY. OWNER NOTIFICATION BEGAN DECEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
02V326000 · Steering:linkages:tie Rod Assembly
Dec 2, 2002
ON CERTAIN VANS, THE RIGHT-HAND TIE ROD END NUT MAY NOT BE TIGHTENED ADEQUATELY. THE NUT CAN LOOSEN RESULTING IN SEPARATION OF THE TIE ROD FROM THE STEERING KNUCKLE.
Consequence & remedy
Consequence: SEPARATION OF A TIE ROD CAN CAUSE UNEXPECTED VEHICLE STEERING IN SOME MANEUVERS AND COULD CAUSE A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TIGHTEN THE TIE ROD END NUT AND, IF NECESSARY, REPLACE THE TIE ROD END. OWNER NOTIFICATION BEGAN NOVEMBER 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
02V305000 · Wheels:lugs/nuts/bolts/studs
Nov 14, 2002
CERTAIN VANS WERE BUILT WITHOUT A WHEEL BEARING ASSEMBLY RETAINING NUT, WHICH COULD LEAD TO A POSSIBLE BEARING SEPARATION.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, THE AMBER-COLORED ABS TELL-TALE LAMP IN THE INSTRUMENT PANEL WOULD ILLUMINATE AND THE ABS SYSTEM WOULD BE DISABLED. THE DRIVER WOULD ALSO NOTICE A GRINDING NOISE, A DECREASE IN THE VEHICLE SPEED, AND THE STEERING WILL PULL IN THE DIRECTION OF THE AFFECTED BRAKE ASSEMBLY. THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE WHEEL BEARING ASSEMBLY. IF THE INSPECTION REVEALS A MISSING RETAINING NUT, THE WHEEL BEARING ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11040 · Fuel Filler Pipe Corrosion/leakage
Opened Dec 14, 2011 · Closed Aug 16, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Fuel System, Gasoline
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.