1997 Chevrolet Express

TL* THE CONTACT OWNS A 1997 CHEVROLET EXPRESS. THE CONTACT STATED THAT A FUEL ODOR CAME FROM THE VEHICLE AND THE VEHICLE LEAKED FUEL ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE. UPDATED 04/22/16*LJ UPDATED 05/31/18*JB

DT*: THE CONTACT STATED WHILE TRAVELING 75 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER INTO THE MEDIAN AND THE TIRE WAS CHANGED. TWO HUNDRED MILES LATER, THE PASSENGER SIDE REAR TIRE BLEW OUT. THE VEHICLE WAS PULLED OVER TO THE SHOULDER AND THE TIRE WAS REPLACED. THE TIRES WERE SENT TO THE MANUFACTURER WHICH DETERMINED THE BLOWOUTS WERE A RESULT OF ROAD HAZARDS. UPDATED 4/6/2006 - THE CONSUMER BELIEVES THE FAILURE WAS DUE TO TREAD SEPARATION. *NM

THE TRANSMISSION HAD AN OVERHEATING PROBLEM THAT CAUSED THE VEHICLE TO SWITCH TO "SAFE" MODE. SAFE MODE COMPENSATED THE TRANSMISSION HEAT PROBLEM BY HARD SHIFTING. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALTY REPAIR SHOP WHERE I LEARNED THAT THE PROBLEM WAS IN THE DESIGN OF THE TRANSMISSION. IT WAS THE OPINION OF THE REPAIR SHOP THAT GM KNEW OF THE PROBLEM BUT WOULD NOT ISSUE A RECALL BECAUSE THE ISSUE WAS NOT LIFE THREATENING. COST OF MODIFICATION WAS $1,600.*JB

DT: WHILE DRIVING SERVICE ENGINE LIGHT ILLUMINATED ON THE DASH PANEL. THE CONSUMER TOOK THE VEHICLE TO A CHEVROLET DEALER, WHO PERFORMED A DIAGNOSTIC TEST WHICH SHOWED THAT TRANSMISSION WAS SLIPPING. THE DEALER NOTED THE NEXT STEP WOULD BE TO CHECK THE TRANSMISSION FLUID. DUE TO THE COLOR OF THE FLUID IT WAS DETERMINED A NEW TRANSMISSION WOULD BE NEEDED. THE DEALER REFERRED THE CONSUMER TO OTHER INDEPENDENT SHOPS, AND THEY TOO CONFIRMED WHAT THE DEALER SAID. THE CONSUMER TOOK THE VEHICLE HOME AND PARKED IT. NO CORRECTIONS OR REPAIRS WERE MADE. THE CONSUMER CALLED CHEVROLET MANUFACTURER, AND THEY SAID THERE WAS NOTHING THEY COULD DO. THE CONSUMER CONTACTED CHEVROLET AGAIN, AND THEY ESCALATED HIS CONCERNS BUT OFFERED NO FURTHER ASSISTANCE. *AK UPDATED 05/06/08 *BF THE CONSUMER STATED THE ABS AND MASS AIR FLOW SENSOR FAILED. UPDATED 05/06/08

FUEL GUAGE FAILURE ON MY 1997 EXPRESS VAN. GUAGE SHOWED FUEL TANK EMPTY. ESTIMATED REPAIRS= $600.00. THIS HAS HAPPENED TO FRIENDS WITH SAME YEAR CHEVROLETS. INTERNET FULL OF COMPLAINTS FOR 1997 AND 2000 YEARS. THIS IS A SERIOUS SAFETY ISSUE, AND A VERY COSTLY REPAIR THAT MANY CANNOT AFFORD. PLEASE, PLEASE HELP. I AM SUBMITTING THE SAME FUEL GUAGE FAILURE COMPLAINT FOR A 2000 CHEVROLET BLAZER REGARDING AN INCIDENT THAT PUT MY TEENAGER IN SERIOUS JEOPARDY!*AK

THIS PROBLEM AFFECTS 1996-2002 G-SERIES VANS (CHEVY EXPRESS AND GMC SAVANA). THE POWERTRAIN CONTROL MODULE/VEHICLE CONTROL MODULE (PCM/VCM) CORRODES OVER TIME AND THE CASE ENCLOSING THE COMPUTER SPLITS OPEN ALLOWING WATER TO ENTER THE VEHICLE'S ELECTRICAL SYSTEM. GM HAS ACKNOWLEDGED THIS PROBLEM IN TECHNICAL SERVICE BULLETIN 02-06-04-020, ATTRIBUTING IT TO LOCATION OF THE PCM/VCM AND DESIGN OF THE ENGINE WIRING HARNESS DEFLECTOR. THIS DEFLECTOR ACTS MUCH LIKE A "RAIN GUTTER" TO ROUTE WATER AWAY FROM THE COMPUTER. IT WAS POORLY DESIGNED AND INSTEAD DUMPS WATER DIRECTLY ON TO THE COMPUTER TRIGGERING CORROSION. THE CORROSION MAY ALSO BE THE RESULT OF GALVANIC ACTION (TWO DISSIMILAR METALS GENERATING AN ELECTRICAL CHARGE) AS THE COMPUTER CASE IS ALUMIONUM AND SCREWS HOLDING IT TOGETHER ARE STEEL. A SMALL CLAIMS COURT ACTION FILED AGAINST GM AND THE DEALERSHIP IMMEDIATELY RESULTED IN AN OFFER FROM GM TO PAY FOR ALL REPAIRS (PRIOR TO ANY HEARINGS). THIS LEADS US TO BELIEVE THEY ARE VERY AWARE OF THIS PROBLEM AND MAY IN EFFECT HAVE A "SECRET WARRANTY" IN PLACE. TOTAL REPAIR COST WAS $1,400 BUT IT COULD HAVE BEEN MUCH MORE SINCE WE CHOSE TO "DRY OUT" THE ELECTRICAL SYSTEM RATHER THAN REPLACE THE ENTIRE WIRING HARNESS (MORE THAN $2,000 PARTS AND LABOR).