WE PURCHASED A CHEVROLET EXPRESS VAN BRAND NEW IN AUGUST 2000, AND FROM DAY ONE WE HAVE HAD PROBLEMS WITH IT. THE FIRST THING TO GO WRONG WITH IT WAS THE MIRRORS WOULD SHAKE WHEN THE VAN WOULD GO UP ON THE HIGHWAY DOING 55 MPH. WE BROUGHT IT BACK TO THE DEALER WHO FIXET THE PROBLEM, BUT TO THIS DAY IT STILL EXISTS. THE NEXT THIN…
Read full complaint
WE PURCHASED A CHEVROLET EXPRESS VAN BRAND NEW IN AUGUST 2000, AND FROM DAY ONE WE HAVE HAD PROBLEMS WITH IT. THE FIRST THING TO GO WRONG WITH IT WAS THE MIRRORS WOULD SHAKE WHEN THE VAN WOULD GO UP ON THE HIGHWAY DOING 55 MPH. WE BROUGHT IT BACK TO THE DEALER WHO FIXET THE PROBLEM, BUT TO THIS DAY IT STILL EXISTS. THE NEXT THING IS THE PASSANGER SIDE REAR DOOR WILL SQUEAK AND GET STUCK WHEN YOU TRY TO OPEN/CLOSE IT. THE NEXT THING TO GO WRONG WITH IT IS THE TIRES. THE TREADS WORE OFF AND THE STEEL BELTS STARTED TO SHOW THROUGH, ALSO WE HAVE BROUGHT THE VAN TO HAVE NEW TIRES PUT ON AND THE MECHANIC COULD NOT GET THE BACK LUGS OFF OF THE VAN . THE NEXT THING TO GO WRONG IS THE DRIVERS SIDE WINDOW SWITCH LET GO IN SEPTEMBER OF LAST YEAR IN THE DOWN POSITION. WE HAD TO REPLACE THIS PART WHICH COST US OVER $100 DOLLARS. THIS NEW PART IS NOW STARTING TO LET GO ON US TOO. THE NEXT THING TO LET GO NOW IS THE WATER PUMP. WE BROUGHT IT TO A MECHANIC WHO SAID THAT IF WE WANTED US TO HEVE HIM FIX IT THAT IT WOULD COST US $380 (PART AND LABOR) THIS IS MONEY THAT I DO NOT HAVE. THIS IS A VAN THAT WAS BOUGHT OUT OF MY SONS TRUST FUND, HE HAS CEREBRAL PALSY.*AK
NHTSA ODI #10093045
18,000 miles · Jan 27, 2004
Engine And Engine Cooling
2000 CHEVROLET EXPRESS VAN, 1500, VA 4.3 LITER. CATALYTIC CONVERTER FAILS, DEALER SAYS THE INTERNALS COMPLETELY BREAK UP. HAVE HAD CATALYTIC CONVERTER REPLACED 3 TIMES AND THE ONE IN IT HAS FAILED ALSO. THE EXHAUST SYSTEM RATTLES WHEN CONVERTERS GO BAD. *JB
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
2000 Chevrolet Express Problems, Complaints & Recalls | Skip That Year
Illustration