NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
32 reportsClear category filter85,225 miles · Jan 26, 2007
Vehicle Speed Control
ON THE EVENING OF JANUARY 25, 2007 I WAS DRIVING HOME WHEN I NOTICED THAT MY CAR WAS NOT SLOWING DOWN WHEN I RELEASED PRESSURE FROM THE GAS PEDAL. IT THEN BECAME APPARENT TO ME THAT THE CAR WAS STILL ACCELERATING DESPITE THE FACT THAT MY FOOT WAS NOT ON THE GAS PEDAL. I SHIFTED THE VEHICLE INTO NEUTRAL AND THE TACHOMETER SHOW…
Read full complaint
ON THE EVENING OF JANUARY 25, 2007 I WAS DRIVING HOME WHEN I NOTICED THAT MY CAR WAS NOT SLOWING DOWN WHEN I RELEASED PRESSURE FROM THE GAS PEDAL. IT THEN BECAME APPARENT TO ME THAT THE CAR WAS STILL ACCELERATING DESPITE THE FACT THAT MY FOOT WAS NOT ON THE GAS PEDAL. I SHIFTED THE VEHICLE INTO NEUTRAL AND THE TACHOMETER SHOWED THAT THE ENGINE WAS REVVING IN THE 5,000 RPM RANGE WITHOUT MY FOOT ON THE GAS PEDAL. I MANAGED TO GET THE CAR OFF OF THE ROAD AND TURNED THE VEHICLE OFF WHILE THE TRANSMISSION WAS IN NEUTRAL, THEN SHIFTED TO PARK. I ATTEMPTED SEVERAL TIMES TO RESTART THE CAR, BUT EACH TIME THE ENGINE IMMEDIATELY REVVED UP TO THE 5,000 RPM RANGE AS IF THE GAS PEDAL WAS FLOORED. AFTER ABOUT 4 ATTEMPTS OF SHUTTING DOWN THE CAR AND RESTARTING THE ENGINE FINALLY IDLED AS IS SHOULD UPON START UP AND I WAS ABLE TO FINISH MY DRIVE HOME WITHOUT FURTHER INCIDENT. *JB
NHTSA ODI #10180776
79,000 miles · Dec 27, 2005
Vehicle Speed Control
DT: THE CONTACT STATED WITHOUT WARNING VEHICLE ACCELERATED TO OVER 100 MPH. AFTER THE FIRST INCIDENT THE THROTTLE CABLE WAS REPLACED. A MONTH LATER IT HAPPENED AGAIN, THE DEALER MADE REPAIRS TO THE CABLE. THE VEHICLE HAS BEEN RETURNED TO THE DEALER A THIRD TIME FOR THE SAME PROBLEM. CURRENTLY THE DEALER WAS UNABLE TO DUPLICATE…
Read full complaint
DT: THE CONTACT STATED WITHOUT WARNING VEHICLE ACCELERATED TO OVER 100 MPH. AFTER THE FIRST INCIDENT THE THROTTLE CABLE WAS REPLACED. A MONTH LATER IT HAPPENED AGAIN, THE DEALER MADE REPAIRS TO THE CABLE. THE VEHICLE HAS BEEN RETURNED TO THE DEALER A THIRD TIME FOR THE SAME PROBLEM. CURRENTLY THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM, AND NO ADDITIONAL REPAIRS WERE MADE. *AK
NHTSA ODI #10146118
67,000 miles · Feb 4, 2005
Vehicle Speed Control
CONSUMER PLACED THE VEHICLE IN CRUISE CONTROL. WHILE THE VEHICLE WAS STOPPED AT A TOLL BOOTH VEHICLE ACCELERATED. THEN, VEHICLE CONTINUED TO ACCELERATE, ONCE GETTING ONTO THE HIGHWAY, TO 72 MPH.. CONSUMER PULLED OVER, TURNED THE VEHICLE OFF FOR FORTY MINUTES, AND PROCEEDED HOME. THE NEXT DAY, CONSUMER TOOK THE VEHICLE TO…
Read full complaint
CONSUMER PLACED THE VEHICLE IN CRUISE CONTROL. WHILE THE VEHICLE WAS STOPPED AT A TOLL BOOTH VEHICLE ACCELERATED. THEN, VEHICLE CONTINUED TO ACCELERATE, ONCE GETTING ONTO THE HIGHWAY, TO 72 MPH.. CONSUMER PULLED OVER, TURNED THE VEHICLE OFF FOR FORTY MINUTES, AND PROCEEDED HOME. THE NEXT DAY, CONSUMER TOOK THE VEHICLE TO THE DEALERS FOR INSPECTION, WHERE IT REMAINED. *AK
NHTSA ODI #10110845
65,000 miles · Jan 31, 2005
Vehicle Speed Control
WHILE DRIVING 45 MPH VEHICLE ACCELERATED WITHOUT WARNING. NO IMPACT REPORTED. *AK *AK
NHTSA ODI #10109288
67,000 miles · Jan 17, 2005
Vehicle Speed Control
WHEN STOPPED, CAR WILL REV UP OVER 3000 RPM WITHOUT MY TOUCHING THE ACCELERATOR. FEELS LIKE CAR IS GOING TO TAKE OFF, RIGHT INTO AN INTERSECTION. HAVE HAD TO TURN OFF IGNITION TO AVOID A POTENTIAL ACCIDENT. IT ALSO OCCASIONALLY ACCELERATES WHILE DRIVING EVEN ONCE MY FOOT IS OFF THE ACCELERATOR AND NOT IN CRUISE CONTROL MODE. …
Read full complaint
WHEN STOPPED, CAR WILL REV UP OVER 3000 RPM WITHOUT MY TOUCHING THE ACCELERATOR. FEELS LIKE CAR IS GOING TO TAKE OFF, RIGHT INTO AN INTERSECTION. HAVE HAD TO TURN OFF IGNITION TO AVOID A POTENTIAL ACCIDENT. IT ALSO OCCASIONALLY ACCELERATES WHILE DRIVING EVEN ONCE MY FOOT IS OFF THE ACCELERATOR AND NOT IN CRUISE CONTROL MODE. *JB
NHTSA ODI #10106460
Mileage unknown · Jan 14, 2005
Service Brakes, HydraulicStructureSuspension
SUBMISSION OF COMPLAINT RE VW OF AMERICA FEEL HE HAS BEEN OVER CHARGED FOR NUMEROUS & EXTENSIVE REPAIR BILLS FOR HIS 1999 VW PASSAT. THE CONSUMER STATED HE IS STILL EXPERIENCING PROBLEMS WITH THE FRONT SUSPENSION. THE FRONT STABILIZER WAS REPAIRED AND THE LOWER CONTROL ARM WAS REPAIRED, HOWEVER THE PROBLEM RECURRED. THE REAR …
Read full complaint
SUBMISSION OF COMPLAINT RE VW OF AMERICA FEEL HE HAS BEEN OVER CHARGED FOR NUMEROUS & EXTENSIVE REPAIR BILLS FOR HIS 1999 VW PASSAT. THE CONSUMER STATED HE IS STILL EXPERIENCING PROBLEMS WITH THE FRONT SUSPENSION. THE FRONT STABILIZER WAS REPAIRED AND THE LOWER CONTROL ARM WAS REPAIRED, HOWEVER THE PROBLEM RECURRED. THE REAR BRAKE PADS WERE WORN. THE FRONT DOORS CREAKED WHEN OPENED. *JB THE CRUISE CONTROL WAS INTERMITTENT. THE CONSUMER REQUESTED ASSISTANCE OF ALL THE MATTERS. *SC *JB
NHTSA ODI #10094353
131,000 miles · Dec 16, 2004
Vehicle Speed Control
1999 VW PASSAT ON12/15/04 AND 12/16/04 SUDDENLY INCREASED SPEED ON ITS OWN WITHOUT DRIVER PRESSING THE GAS PEDAL. ON 12/15 WHILE DRIVING WB ON I-80 IN PENNA AROUND THE 278/279 MILE MARKER WITH THE VEHICLE IN CRUISE CONTROL THE CAR ITSELF INCREASED TO NEARLY 90 MPH WITHOUT ANY DRIVER INTERVENTION, I PUSHED BRAKE TO GET CRUISE TO…
Read full complaint
1999 VW PASSAT ON12/15/04 AND 12/16/04 SUDDENLY INCREASED SPEED ON ITS OWN WITHOUT DRIVER PRESSING THE GAS PEDAL. ON 12/15 WHILE DRIVING WB ON I-80 IN PENNA AROUND THE 278/279 MILE MARKER WITH THE VEHICLE IN CRUISE CONTROL THE CAR ITSELF INCREASED TO NEARLY 90 MPH WITHOUT ANY DRIVER INTERVENTION, I PUSHED BRAKE TO GET CRUISE TO RELEASE WHICH DIDN'T DO ANYTHING, I TURNED OFF CRUISE CONTROL ON TURN SIGNAL ARM WITH NO SPEED INCREASE STOPPAGE, I REACHED DOWN TO BE SURE THE FLOOR MAT WASN'T STUCK AND CAUSING GAS PEDAL TO BE PUSHED AND IT WASN'T. I FINALLY WHY STANDING WITH BOTH FEET ON THE BRAKES GOT THE VEHICLE TO SLOW ENOUGH TO SAFELY PULL OVER AND I TURNED IT OFF. I THEN TURNED THE VEHICLE ON TWICE AND THE RPM'S PEGGED IMMEDIATELY TO 5000-6000 RPM'S AND I TUNRNED THE CAR OFF AT ONCE. ON A THIRD TRY THE CAR TURNED ON IN IT'S NORMAL MODE AND IDLED OKAY. I THEN DROVE THE REMAINING APPROX 15 MILES TO WORK ON THE PA TURNPIKE AND PA RTE 115. I DROVE THE CAR HOME THE EVENING OF 12/15 WITHOUT ANY PROBLEMS BUT, DID NOT ENGAGE THE CRUISE CONTROL. ON THE MORNING OF 12/16 WHILE ON WAY TO WORK AT APPROX THE 114 MILE MARK OF THE PA TURNPIKE NB THE CAR DID THE SAME AS IT HAD DONE THE PEVIOUS MORNING AND STARTED TAKING OFF ON IT'S OWN AGAIN, HOWEVER, THIS DAY JUST LIKE THE RETURN TRIP HOME THE NIGHT OF 12/15 I DID NOT HAVE THE CRUISE CONTROL ENGAGED. ON 12/16 I GOT THE CAR ON THE SHOULDER SAFELY AND WHILE BRAKING AND GETTING THE CAR TO AROUND 35-40 MPH I TURNED IT OFF AND CAME TO A STOP. ON THE FIRST RESART THE CAR AGAIN PEGGED RPM'S UP TO AROUND 5000-6000 AND I TURNED IT OFF IMMEDIATELY. WITH THE SECOND RESTART OF THE CAR IT RAN NORMAL AND I COMPLETED THE REMAINING 4-5 MILES TO WORK.*AK
NHTSA ODI #10103066
20,000 miles · Oct 25, 2004
Fuel System, GasolineVehicle Speed Control
OUR 1999 PASSAT WITH THE 1.8 LITER ENGINE STALLS REPEATEDLY WHEN DECELERATING, THIS IS DANGEROUS. WE PURCHASED THE CAR NEW AND HAD A PROBLEMS BEFORE 20,000 MILES. VW CANNOT DIAGNOSE THIS PROBLEM. I TOOK VW TO THE BBB SINCE THEY WERE VERY UNCOOPERATIVE IN REPAIRING THIS PROBLEM, AND THEN THEY CHANGED THE THROTTLE BODY. THEN THE P…
Read full complaint
OUR 1999 PASSAT WITH THE 1.8 LITER ENGINE STALLS REPEATEDLY WHEN DECELERATING, THIS IS DANGEROUS. WE PURCHASED THE CAR NEW AND HAD A PROBLEMS BEFORE 20,000 MILES. VW CANNOT DIAGNOSE THIS PROBLEM. I TOOK VW TO THE BBB SINCE THEY WERE VERY UNCOOPERATIVE IN REPAIRING THIS PROBLEM, AND THEN THEY CHANGED THE THROTTLE BODY. THEN THE PROBLEM WENT AWAY FOR A FEW YEARS AND IS NOW BACK AND VW AGAIN REFUSES TO REPLACE THE THROTTLE BODY. THE THROTTLE BODY IS OBVIOUSLY DEFECTIVE AND THEY WILL NOT ADMIT THAT THERE IS A PROBLEM OR FIX IT. *AK
NHTSA ODI #10096384
2,000 miles · Mar 30, 2004
Vehicle Speed Control
CRUISE CONTROL SLOWLY FADES OUT (OCCASIONALLY) WITHOUT WARNING, EXCEPT THE SIGHT OFAN ENORMOUS TRUCK GRILL IN MY REAR-VIEW MIRROR. NONE OF THE LOCAL VW DEALERS COULD FIX IT, NOR WOULD THEY REPLACE IT. VW ZONE MANAGER TOLD ME TO FORGET IT. CAR IS 1999 PASSAT WAGON, 4-CYL. IS THIS COMMON?
NHTSA ODI #10064165
72,000 miles · Feb 26, 2004
Vehicle Speed Control
WHILE DRIVING AT 55 MPH VEHICLE ACCELERATED TO 80 MPH. *AK WHEN THE CONSUMER APPLIED THE BRAKES, ONE FOOT WAS LIFTED FROM THE BRAKES AND THE VEHICLE ACCELERATED BACK TO 80 MPH. THE VEHICLE DID NOT CEASE TO ACCELERATE UNTIL PLACED INTO NEUTRAL,TURNED OFF, AND HAD TO STAND ON THE BRAKES IN ORDER TO STOP THE VEHICLE. *SC
NHTSA ODI #10057440
Official recalls
5Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
Sep 13, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
May 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.
Remedy: DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
DP05003 · Alleged Premature Tie Rod Failure
Opened Aug 8, 2005 · Closed Dec 9, 2005
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
ON AUGUST 2, 2005, ODI RECEIVED A PETITION SUBMITTED BY MS. MIRIAM SCHNEIDER OF OLNEY, MD, REQUESTING AN INVESTIGATION OF ALLEGEDLY DEFECTIVE TIE RODS IN CERTAIN MODEL YEAR (MY) 1999 VOLKSWAGEN PASSAT VEHICLES NOT INCLUDED IN TWO PREVIOUS SAFETY RECALL CAMPAIGNS (IDENTIFIED HENCEFORTH AS THE SUBJECT VEHICLES).IN A SEPTEMBER 1999 LETTER, VOLKSWAGEN OF AMERICA, INC. (VW) NOTIFIED THE AGENCY THAT AN UNDETERMINED PERCENTAGE OF MY 1998-1999 VOLKSWAGEN PASSAT AND AUDI A4, A6, AND A8 VEHICLES CONTAINED A SAFETY-RELATED DEFECT AFFECTING ALUMINUM TIE ROD ENDS IN THE STEERING SYSTEM.VW INDICATED THAT IT WAS POSSIBLE THAT SOME TIE RODS WOULD NOT SEAL PROPERLY WHICH COULD ALLOW MOISTURE AND DUST PARTICLES TO ENTER THE SWIVEL BEARING MECHANISM, RESULTING IN PREMATURE WEAR.THE APPROXIMATELY 22,200 VOLKSWAGEN AND 29,700 AUDI VEHICLES AFFECTED BY THIS RECALL (IDENTIFIED BY NHTSA RECALL NO. 99V-248) WERE BUILT FROM JANUARY 1998 THROUGH JULY 1998 AND FELL WITHIN A SPECIFIC VEHICLE IDENTIFICATION NUMBER (VIN) RANGE.IN NOVEMBER 2000, VW CHOSE TO EXPAND THE SCOPE OF THE RECALL (IDENTIFIED BY NHTSA RECALL NO. 00V-414) AFTER IT DETERMINED THAT SOME POTENTIALLY DEFECTIVE ALUMINUM TIE ROD ENDS MAY HAVE BEEN INSTALLED IN AN ADDITIONAL 44,000 VOLKSWAGEN AND 39,000 AUDI VEHICLES BUILT FROM AUGUST 1998 THROUGH APRIL 1999.THESE SUBJECT RECALL ACTIONS WERE NOT INFLUENCED BY ODI.INSTEAD, VW MADE AN INDEPENDENT DETERMINATION TO CONDUCT A RECALL AFTER GERMAN VEHICLE INSPECTION AUTHORITIES NOTIFIED IT OF ?WORN? TIE RODS AND FACTORY INSPECTION OF SOME ?WORN? TIE RODS REVEALED IMPROPER SEALING.ACCORDING TO A DECEMBER 2004 REPORT, THE PETITIONER BROUGHT HER MY 1999 PASSAT TO AN AUTHORIZED VOLKSWAGEN DEALER FOR AN UNRELATED RECALL REPAIR WHERE SHE WAS NOTIFIED BY SERVICE PERSONNEL THAT, AFTER 59,000 MILES TRAVELED, THE TIE RODS ?HAVE TOO MUCH PLAY,? AND THE RECOMMENDED REPAIRS WOULD NOT BE COVERED FREE OF CHARGE BECAUSE HER VIN (WVWNA63B1XE499116) WAS OUTSIDE THE RECALL RANGE.IN JUNE 2005, AFTER 65,400 MILES TRAVELED, THE PETITIONER PAID $588.59 TO REPLACE WORN INNER AND OUTER TIE ROD ENDS ON BOTH SIDES OF THE VEHICLE.THE PETITION LETTER SPECIFICALLY REQUESTS THAT THE SCOPE OF VW?S RECALL BE EXPANDED TO INCLUDE THE PETITIONER?S VEHICLE AND THAT SHE BE REIMBURSED FOR THE COST OF THE REPAIRS.THERE ARE A TOTAL OF 191 NON-DUPLICATIVE COMPLAINTS TO ODI AND VW THAT ALLEGE PREMATURE WEAR OF EITHER ONE OR BOTH OUTER TIE ROD ENDS IN THE SUBJECT VEHICLES.AS OF NOVEMBER 18, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS OF TIE ROD SEPARATIONS RESULTING IN A LOSS OF VEHICLE CONTROL, CRASH OR INJURY IN THE SUBJECT VEHICLES.THE PETITIONER?S VEHICLE WAS MANUFACTURED ON JUNE 8, 1999 USING REVISED STEEL TIE ROD ENDS AND THEREFORE WAS ALREADY EQUIPPED WITH THE TIE ROD ENDS USED TO REMEDY DEFECTIVE VEHICLES IN THE SUBJECT RECALLS.ANALYSIS INDICATES THAT THERE DOES NOT APPEAR TO BE A SAFETY-RELATED DEFECT TREND WITH RESPECT TO THE STEEL TIE ROD ENDS USED IN THE SUBJECT VEHICLES.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA04017 · STUCK-OPEN Throttle
Opened Jun 30, 2004 · Closed Feb 10, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
RQ99008 · Power Brake Booster Vacuum BY-PASS
Opened Jun 1, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration