IllustrationI WOS DRIVING FROM WORK TO HOME I TOOK THE PARKWAY I WOS GOING 60 MILES THEN IN HIS OWN THE CAR STARTING INCREASING SPEED SO I MOVE THE SHOULDER I PUT THE CAR NEUTRAL AND STOP THE CAR.THE TOOK ME 3 TRY TO THE CAR GO BACK TO NORMAL. I DONT KNOW IF THIS CAR GOT I RECALL.
1999 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 1999 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
4525–50K
12850–75K
11075–100K
74100–150K
18150K+
391 reports with mileage · 273 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports13 fire reports8 injury reports
Vehicle Speed Control complaints
32 reportsPASSAT BEGAN TO ACCELERATE UNDER NO PRESSURE TO PEDAL. PASSAT STARTED TO ACCELERATE FAIRLY SLOWLY BUT STEADILY AT FIRST, THEN IT INCREASED. IT WASN'T POSSIBLE TO DECELERATE/NO PRESSURE ON THE BRAKE PEDAL STOPPED THE ACCELERATION. IT BEGAN TO REACH AN UNSAFE SPEED THEN I BEGAN TO DOWNSHIFT AND TO APPLY THE BRAKE IN SEQUENCE TO SL…
Read full complaint
PASSAT BEGAN TO ACCELERATE UNDER NO PRESSURE TO PEDAL. PASSAT STARTED TO ACCELERATE FAIRLY SLOWLY BUT STEADILY AT FIRST, THEN IT INCREASED. IT WASN'T POSSIBLE TO DECELERATE/NO PRESSURE ON THE BRAKE PEDAL STOPPED THE ACCELERATION. IT BEGAN TO REACH AN UNSAFE SPEED THEN I BEGAN TO DOWNSHIFT AND TO APPLY THE BRAKE IN SEQUENCE TO SLOW THE PASSAT, THEN I TRIED TO SLOW THE VEHICLE TO COAST IT ONTO THE SHOULDER, BUT THE SPEED REMAINED TOO HIGH TO HALT THE CAR. HAVING NO OTHER WAY TO SLOW THE VEHICLE, I STARTED TO DOWNSHIFT AND TO APPLY EXTREME PRESSURE TO THE BREAKS, AND WAS ABLE TO SLOW THE VEHICLE ENOUGH AFTER SEVERAL MILES OF DOWNSHIFTING AND RIDING THE BREAKS TO REACH A POINT AT WHICH I COULD SHIFT THE CAR INTO NEUTRAL, THEN BEGAN COASTING IT UP A LONG DRIVEWAY WHILE THE ENGINE CONTINUED TO RACE AND REV. I THEN DROPPED THE CAR INTO NEUTRAL AND ENGAGED THE EMERGENCY BREAK, THEN FORCED THE TRANS INTO PARK AND SHUT THE PASSAT OFF. THE FRONT BREAKS WERE BOTH GLOWING, WITH THE DRIVER'S SIDE HAVING BURST INTO FLAMES AS A RESULT OF THE FRICTION AND HEAT FROM HAVING RIDDEN THEM FOR SEVERAL MILES. SHOP THAT EXAMINED THE PASSAT ASSESSED THAT THE THROTTLE BODY CONTROL MODULE HAD FAILED AND WASN'T COMMUNICATING WITH THE MAIN ON-BOARD COMPUTER, AND THAT THIS TYPE OF PROBLEM HAD BEEN SEEN BEFORE ON OTHER VOLKSWAGEN MODELS OF THE SAME ERA. TECHNICIAN INDICATED THAT THIS WAS THE THIRD TIME THAT HE'D SEEN THIS FAILURE. IT APPARENTLY USUALLY RESULTS IN THE CAR COMING TO A STOP ALTHOUGH THERE ARE OTHER CASES CUSTOMERS REPORTED THAT RESULTED IN THE UNCONTROLLED ACCELERATION THAT I EXPERIENCES. THE BREAKS AND OTHER INTERNAL COMPONENTS WERE SIGNIFICANTLY DAMAGED AS A RESULT OF THE ACCIDENT/THROTTLE BODY FAILURE, AND THE VEHICLE HAD TO BE SCRAPPED. SOMEONE SHOULD RESEARCH THIS FURTHER AS THIS IS A POTENTIALLY FATAL ISSUE. PLEASE CONTACT ME IF ANY FURTHER INFORMATION IS REQUIRED TO INVESTIGATE. *TR
1999 VW PASSAT GLX ACCELERATED ON ITS OWN AND WOULD NOT STOP WHEN BRAKES WERE PRESSED OR CAR WAS PUT INTO NEUTRAL. CAR ACCELERATED ON ITS OWN AND SPEED KEPT INCREASING. EXTREMELY DANGEROUS AND I WAS UNABLE TO STOP THE VEHICLE BY PRESSING THE BRAKES. CAR ACCELERATED ON ITS OWN. *TR
WINTER 2008-2009 HAD SEVERAL TIMES WHEN CAR WOULD ACCELERATE ON IT'S OWN. BRAKES DID NOT HELP. ONLY WAY TO STOP IS TO APPLY BRAKES WITH BOTH FEET AND SLOW DOWN ENOUGH TO PULL OVER AND PUT IN NEUTRAL, WHICH MAKES TAC GO OVER 7000 RPM'S. HAD THROTTLE BODY CLEANED AND RESET IN SPRING OF 2009 BUT PROBLEM RECURRED AGAIN THIS YEAR. ON…
Read full complaint
WINTER 2008-2009 HAD SEVERAL TIMES WHEN CAR WOULD ACCELERATE ON IT'S OWN. BRAKES DID NOT HELP. ONLY WAY TO STOP IS TO APPLY BRAKES WITH BOTH FEET AND SLOW DOWN ENOUGH TO PULL OVER AND PUT IN NEUTRAL, WHICH MAKES TAC GO OVER 7000 RPM'S. HAD THROTTLE BODY CLEANED AND RESET IN SPRING OF 2009 BUT PROBLEM RECURRED AGAIN THIS YEAR. ON MONDAY, FEB. 8, 2010 TEMPERATURE WAS IN LOW TEENS. WARMED CAR FOR APPROX. 7 MIN. DROVE SLOWLY DUE TO BAD ROAD CONDITIONS AND AT APPROX. 3 MILES INTO DRIVE CAR STARTED ACCELERATING AGAIN ON ITS OWN AND NO PLACE TO PULL OFF. HAD TO STOP IN EXTREMELY DANGEROUS POSITION AND PRAY I WASN'T HIT BEFORE I COULD SAFELY START CAR AGAIN. FINALLY ABLE TO RESTART ENGINE AFTER APPROX. 5 MIN. WITHOUT REVVING PROBLEM BUT APPROX. 2 MILES LATER CAR AGAIN ACCELERATED ON IT'S OWN. TOOK TO DEALER AND THEY DID A GENERAL DIAGNOSIS WHICH SHOWED NOTHING. THIS IS AN EXTREMELY DANGEROUS SITUATION AND MAKES ME EXTREMELY NERVOUS TO DRIVE MY CAR. VW OF AMERICA STATES THAT MY CAR WAS NOT IN ANY RECALL AND THEY ARE UNAWARE OF ANY PROBLEM WITH MY CAR AND COULD NOT DIVULGE IF THEY RECEIVED ANY OTHER COMPLAINTS. *TR
2PM IN SOUTHERN CALIFORNIA WITH PERFECT DRIVING CONDITIONS.... DRIVING ABOUT 30 MPH DOWN CITY SURFACE STREET - WHEN ALL OF THE SUDDEN THE CAR ACCELERATED TO 60MPH - VERY SCARY - 1999 VW PASSAT GLX CAR IS A BIT OVER 115K MILES IN EXCELLENT CONDITION. CAR WAS PULLED OVER AFTER BRAKING AND PULLING UP EMERGENCY BRAKE - CAR CONTINU…
Read full complaint
2PM IN SOUTHERN CALIFORNIA WITH PERFECT DRIVING CONDITIONS.... DRIVING ABOUT 30 MPH DOWN CITY SURFACE STREET - WHEN ALL OF THE SUDDEN THE CAR ACCELERATED TO 60MPH - VERY SCARY - 1999 VW PASSAT GLX CAR IS A BIT OVER 115K MILES IN EXCELLENT CONDITION. CAR WAS PULLED OVER AFTER BRAKING AND PULLING UP EMERGENCY BRAKE - CAR CONTINUED REVVING UNTIL CAR WAS QUICKLY TURNED OFF. POPPED HOOD - LET ENGINE COOL FOR 10 - 15 MINUTES - TRIED TO RESTART BUT CAR REVVED AGAIN SO SHUT IT OFF AND WILL HAVE REPAIR SHOP RETRIEVE IT & BRING TO SHOP TO GET LOOKED AT. TOO SCARED TO DRIVE AGAIN. FIRST TIME IT HAPPENED SINCE PURCHASING CAR A FEW MONTHS AGO. *TR
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 65 MPH ON NORMAL ROAD CONDITIONS, THE ACCELERATOR PEDAL BECAME STUCK WHEN IT WAS DEPRESSED. THERE WAS UNINTENDED ACCELERATION AND THE ENGINE REVVED EXCESSIVELY HIGH AND UNCONTROLLABLY. THE VEHICLE CAME TO A COMPLETE STOP WHEN THE CONTACT APPLIED BOTH FE…
Read full complaint
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 65 MPH ON NORMAL ROAD CONDITIONS, THE ACCELERATOR PEDAL BECAME STUCK WHEN IT WAS DEPRESSED. THERE WAS UNINTENDED ACCELERATION AND THE ENGINE REVVED EXCESSIVELY HIGH AND UNCONTROLLABLY. THE VEHICLE CAME TO A COMPLETE STOP WHEN THE CONTACT APPLIED BOTH FEET ON THE BRAKE PEDAL. THE VEHICLE RESUMED NORMAL OPERATION AND WAS DRIVEN WITH CAUTION. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 160,000 AND THE CURRENT MILEAGE WAS UNAVAILABLE. UPDATED 3/19/09 *CN UPDATED 03/23/09.*JB
CAR ACCELERATOR PEDAL LOCKS UP WHEN DECELERATE AND ACCELERATING WHEN MAKING A "U" TURNS. *TR
TL* - THE CONTACT CALLED REGARDING THE 1999 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE BEGAN TO ACCELERATE ON ITS OWN AND THE CONTACT WAS UNABLE TO STOP THE VEHICLE BY BRAKING. THE CONTACT STATED THAT THE DRIVER HAD TO WEAVE IN AND OUT OF TRAFFIC TO AVOID HITTING OTHER VEHICLES. THE VEHICLE EVENTUALLY JUMPED THE…
Read full complaint
TL* - THE CONTACT CALLED REGARDING THE 1999 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE BEGAN TO ACCELERATE ON ITS OWN AND THE CONTACT WAS UNABLE TO STOP THE VEHICLE BY BRAKING. THE CONTACT STATED THAT THE DRIVER HAD TO WEAVE IN AND OUT OF TRAFFIC TO AVOID HITTING OTHER VEHICLES. THE VEHICLE EVENTUALLY JUMPED THE CURB AND STRUCK A FENCE. THERE WERE NO INJURIES. THE SIDE AIR BAG DEPLOYED. THE FAILURE MILEAGE WAS 120,000. THERE WAS NO POLICE REPORT FILED. *AK UPDATED 04/05/07.*J
IN SEPTEMBER OF 2006 I PURCHASED A 1999 VOLKSWAGEN PASSAT FROM SUBURBAN COLLECTIONS AT THE TROY MOTOR MALL IN TROY, MICHIGAN. ABOUT TWO WEEKS AGO I EXPERIENCED SEVERE PROBLEMS AS I WAS ON MY WAY INTO WORK. MY CAR TOOK ON A MIND OF IT'S OWN. AS I TURNED THE CORNER ONTO W. 13 MILE ROAD IN ROYAL OAK, MICHIGAN MY CAR STARTED TO ACCE…
Read full complaint
IN SEPTEMBER OF 2006 I PURCHASED A 1999 VOLKSWAGEN PASSAT FROM SUBURBAN COLLECTIONS AT THE TROY MOTOR MALL IN TROY, MICHIGAN. ABOUT TWO WEEKS AGO I EXPERIENCED SEVERE PROBLEMS AS I WAS ON MY WAY INTO WORK. MY CAR TOOK ON A MIND OF IT'S OWN. AS I TURNED THE CORNER ONTO W. 13 MILE ROAD IN ROYAL OAK, MICHIGAN MY CAR STARTED TO ACCELERATE RATHER QUICKLY. BEFORE I KNEW IT WAS GOING 60 MPH, WITHOUT EVEN HITTING THE GAS AT ALL. THE MOST FRIGHTENING PART OF ALL OF THIS WAS THAT MY BRAKES WOULDN'T WORK DO TO THE FACT THAT THE ENGINE WAS STILL ACCELERATING. AS I PULLED OFF THE ROAD AND PUT THE CAR INTO PARK THE RPM'S IMMEDIATELY RED LINED AND THE ENGINE WAS REVING. NEEDLESS TO SAY I TOOK THE VEHICLE TO THE VOLKSWAGEN DEALERSHIP AT THE TROY MOTOR MALL. THE DEALERSHIP TWO DAYS LATER THEN TOLD ME THAT I NEEDED TO HAVE THE THROTTLE BODY REPLACED. ODDLY ENOUGH, AFTER THIS OCCURRED TWO HOURS LATER MY CAR WAS FINISHED? I PICKED THE CAR UP THAT FRIDAY AND DROVE IT FOR EXACTLY ONE WEEK WITHOUT ANY FURTHER PROBLEMS. WELL, I GOT INTO MY CAR ON FRIDAY AS I USUALLY DO AND ONCE AGAIN MY CAR BEGAN TO FUN BY ITSELF. I WAS EXTREMELY FRIGHTENED DRIVING DOWN ROCHESTER ROAD GOING 70 MPH WITH NO AVAILABLE WAY TO STOP MY CAR. I MADE IT HOME SAFELY AND CONTACTED MY DEALERSHIP ONCE AGAIN. THE STRANGE THING IS THAT THE SAME DAY I RECEIVED A NOTICE IN THE MAIL ON FRIDAY SAYING THAT MY PART (THROTTLE BODY) WAS IN AT THE DEALERSHIP READY FOR REPLACEMENT. SO ALL IN ALL, THE VOLKSWAGEN DEALERSHIP PRESENTED ME WITH FALSE DOCUMENTATION STATING THAT MY THROTTLE BODY HAD BEEN REPLACED WHEN IN FACT IT HADN'T BEEN AND TO BOOT, THOSE PEOPLE AT THE DEALERSHIP SENT ME AWAY DRIVING A RECKLESS VEHICLE KNOWING FULL WELL THAT THE PROBLEM HAD NOT BEEN RESOLVED. I HIT CURBS, EXPERIENCED EXTREME EMOTIONAL ANXIETY ATTEMPTING TO DRIVE, STOP AND CONTROL MY CAR. DUE TO THE LACK OF PROMPT REMEDIATION OF MY VEHICLE THERE HAVE PROBABLY BEEN MORE PROBLEMS ADDED TO THE VEHICLE BECAUSE THE ORIGINAL PROBLEM WAS NEVER FIXED BUT WAS KNOWN ABOUT. *JB
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1999 VOLKSWAGEN PASAAT WITH 113000 FAILURE MILEAGE AT 60 MPH THE VEHICLE BEGAN TO ACCELERATE ON ITS OWN. THE VEHICLE ACCELERATED UP TO 75 MILES. THE CONTACT RODE THE BRAKES FOR APPROXIMATELY 5 MILES, THEN NOTICED A SAFE PLACE TO PULL OVER. THE CONTACT WAS JAMMING ON THE BRAKES T…
Read full complaint
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1999 VOLKSWAGEN PASAAT WITH 113000 FAILURE MILEAGE AT 60 MPH THE VEHICLE BEGAN TO ACCELERATE ON ITS OWN. THE VEHICLE ACCELERATED UP TO 75 MILES. THE CONTACT RODE THE BRAKES FOR APPROXIMATELY 5 MILES, THEN NOTICED A SAFE PLACE TO PULL OVER. THE CONTACT WAS JAMMING ON THE BRAKES TO GET THE VEHICLE TO STOP. THE VEHICLE CAME TO A COMPLETE STOP , AND THE CONTACT TURNED THE VEHICLE OFF. THE VEHICLE WAS RESTARTED TWICE, BUT THE VEHICLE WAS STILL REVVING HIGH. THE CONTACT WAS TOLD TO PULL UP ON THE BRAKE PEDAL, AND THAT WAS THE REMEDY TO GET THE VEHICLE TO IDLE PROPERLY. THE VEHICLE WAS TAKEN TO THE SHOP, AND THEY COULD NOT DUPLICATE THE PROBLEM. THE CONTACT WAS AFRAID TO DRIVE THE VEHICLE. *AK
Official recalls
508V156000 · Fuel System, Gasoline:delivery
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
00V414000 · Steering:linkages:rod:relay:connecting
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V248000 · Steering:linkages:rod:relay:connecting
Sep 13, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V131001 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.
Remedy: DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
DP05003 · Alleged Premature Tie Rod Failure
Opened Aug 8, 2005 · Closed Dec 9, 2005
Status: closed (inferred from source dates) · Steering:linkages:tie Rod Assembly
ON AUGUST 2, 2005, ODI RECEIVED A PETITION SUBMITTED BY MS. MIRIAM SCHNEIDER OF OLNEY, MD, REQUESTING AN INVESTIGATION OF ALLEGEDLY DEFECTIVE TIE RODS IN CERTAIN MODEL YEAR (MY) 1999 VOLKSWAGEN PASSAT VEHICLES NOT INCLUDED IN TWO PREVIOUS SAFETY RECALL CAMPAIGNS (IDENTIFIED HENCEFORTH AS THE SUBJECT VEHICLES).IN A SEPTEMBER 1999 LETTER, VOLKSWAGEN OF AMERICA, INC. (VW) NOTIFIED THE AGENCY THAT AN UNDETERMINED PERCENTAGE OF MY 1998-1999 VOLKSWAGEN PASSAT AND AUDI A4, A6, AND A8 VEHICLES CONTAINED A SAFETY-RELATED DEFECT AFFECTING ALUMINUM TIE ROD ENDS IN THE STEERING SYSTEM.VW INDICATED THAT IT WAS POSSIBLE THAT SOME TIE RODS WOULD NOT SEAL PROPERLY WHICH COULD ALLOW MOISTURE AND DUST PARTICLES TO ENTER THE SWIVEL BEARING MECHANISM, RESULTING IN PREMATURE WEAR.THE APPROXIMATELY 22,200 VOLKSWAGEN AND 29,700 AUDI VEHICLES AFFECTED BY THIS RECALL (IDENTIFIED BY NHTSA RECALL NO. 99V-248) WERE BUILT FROM JANUARY 1998 THROUGH JULY 1998 AND FELL WITHIN A SPECIFIC VEHICLE IDENTIFICATION NUMBER (VIN) RANGE.IN NOVEMBER 2000, VW CHOSE TO EXPAND THE SCOPE OF THE RECALL (IDENTIFIED BY NHTSA RECALL NO. 00V-414) AFTER IT DETERMINED THAT SOME POTENTIALLY DEFECTIVE ALUMINUM TIE ROD ENDS MAY HAVE BEEN INSTALLED IN AN ADDITIONAL 44,000 VOLKSWAGEN AND 39,000 AUDI VEHICLES BUILT FROM AUGUST 1998 THROUGH APRIL 1999.THESE SUBJECT RECALL ACTIONS WERE NOT INFLUENCED BY ODI.INSTEAD, VW MADE AN INDEPENDENT DETERMINATION TO CONDUCT A RECALL AFTER GERMAN VEHICLE INSPECTION AUTHORITIES NOTIFIED IT OF ?WORN? TIE RODS AND FACTORY INSPECTION OF SOME ?WORN? TIE RODS REVEALED IMPROPER SEALING.ACCORDING TO A DECEMBER 2004 REPORT, THE PETITIONER BROUGHT HER MY 1999 PASSAT TO AN AUTHORIZED VOLKSWAGEN DEALER FOR AN UNRELATED RECALL REPAIR WHERE SHE WAS NOTIFIED BY SERVICE PERSONNEL THAT, AFTER 59,000 MILES TRAVELED, THE TIE RODS ?HAVE TOO MUCH PLAY,? AND THE RECOMMENDED REPAIRS WOULD NOT BE COVERED FREE OF CHARGE BECAUSE HER VIN (WVWNA63B1XE499116) WAS OUTSIDE THE RECALL RANGE.IN JUNE 2005, AFTER 65,400 MILES TRAVELED, THE PETITIONER PAID $588.59 TO REPLACE WORN INNER AND OUTER TIE ROD ENDS ON BOTH SIDES OF THE VEHICLE.THE PETITION LETTER SPECIFICALLY REQUESTS THAT THE SCOPE OF VW?S RECALL BE EXPANDED TO INCLUDE THE PETITIONER?S VEHICLE AND THAT SHE BE REIMBURSED FOR THE COST OF THE REPAIRS.THERE ARE A TOTAL OF 191 NON-DUPLICATIVE COMPLAINTS TO ODI AND VW THAT ALLEGE PREMATURE WEAR OF EITHER ONE OR BOTH OUTER TIE ROD ENDS IN THE SUBJECT VEHICLES.AS OF NOVEMBER 18, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS OF TIE ROD SEPARATIONS RESULTING IN A LOSS OF VEHICLE CONTROL, CRASH OR INJURY IN THE SUBJECT VEHICLES.THE PETITIONER?S VEHICLE WAS MANUFACTURED ON JUNE 8, 1999 USING REVISED STEEL TIE ROD ENDS AND THEREFORE WAS ALREADY EQUIPPED WITH THE TIE ROD ENDS USED TO REMEDY DEFECTIVE VEHICLES IN THE SUBJECT RECALLS.ANALYSIS INDICATES THAT THERE DOES NOT APPEAR TO BE A SAFETY-RELATED DEFECT TREND WITH RESPECT TO THE STEEL TIE ROD ENDS USED IN THE SUBJECT VEHICLES.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA04017 · STUCK-OPEN Throttle
Opened Jun 30, 2004 · Closed Feb 10, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
RQ99008 · Power Brake Booster Vacuum BY-PASS
Opened Jun 1, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available