Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1325–50K
2650–75K
2175–100K
18100–150K
4150K+
88 reports with mileage · 261 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports9 fire reports21 injury reports
What owners actually said
349 reports
20,000 miles · Jun 24, 2004
Structure
WHEN IT RAINED THE FLOOR OF THE VEHICLE BECAME WET. THE OWNER TOOK THE VEHICLE TO THE DEALER. THEY FIXED IT AND TOLD THE OWNER THERE WAS NO GUARANTEE THAT THE REPAIR WOULD RESOLVE THE PROBLEM. *JB THE VEHICLE WAS RETURNED TO THE DEALER BECAUSE THE FLOORBOARD CONTINUED TO GET WET WHEN IT RAINED. THE DEALER HAS NOT PROVIDED …
Read full complaint
WHEN IT RAINED THE FLOOR OF THE VEHICLE BECAME WET. THE OWNER TOOK THE VEHICLE TO THE DEALER. THEY FIXED IT AND TOLD THE OWNER THERE WAS NO GUARANTEE THAT THE REPAIR WOULD RESOLVE THE PROBLEM. *JB THE VEHICLE WAS RETURNED TO THE DEALER BECAUSE THE FLOORBOARD CONTINUED TO GET WET WHEN IT RAINED. THE DEALER HAS NOT PROVIDED A PERMANENT SOLUTION. *NM
NHTSA ODI #10073843
74,274 miles · Jun 8, 2004
Exterior Lighting
RECALL NOTICE FOR CHECK/ REPLACE BRAKE LIGHT SWITCH.*MR THE FAULTY BRAKE LIGHT SWITCH CAUSED THE EMERGENCY BRAKE LIGHT TO REMAIN ON. THE VEHICLE WAS TAKEN TO A REPAIR SHOP THREE TIMES BUT THEY WERE UNABLE TO FIX THE PROBLEM (VOLKSWAGEN JETTA). THE DEALER WAS FINALLY ABLE TO IDENTIFY THE PROBLEM AND INFORMED THE CONSUMER IT W…
Read full complaint
RECALL NOTICE FOR CHECK/ REPLACE BRAKE LIGHT SWITCH.*MR THE FAULTY BRAKE LIGHT SWITCH CAUSED THE EMERGENCY BRAKE LIGHT TO REMAIN ON. THE VEHICLE WAS TAKEN TO A REPAIR SHOP THREE TIMES BUT THEY WERE UNABLE TO FIX THE PROBLEM (VOLKSWAGEN JETTA). THE DEALER WAS FINALLY ABLE TO IDENTIFY THE PROBLEM AND INFORMED THE CONSUMER IT WOULD COST $6000. THE CONSUMER TOOK THE VEHICLE ELSEWHERE FOR REPAIRS BECAUSE THE SERVICE DEALER'S STAFF SUDDENLY BECAME RUDE. *NM
NHTSA ODI #10076032
Mileage unknown · Jun 8, 2004
Air BagsExterior Lighting
CONSUMER RECEIVED NHTSA RECALL 04V096000 CONCERNING BRAKE LIGHT SWITCH. AFTER HAVING THE REPAIRS DONE VEHICLE STALLED, AND THE AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON.*AK
NHTSA ODI #10075926
Mileage unknown · Jun 4, 2004
Engine And Engine Cooling
THE THERMOSTAT HOUSING NEEDED TO BE REPLACED DUE TO COOLANT LEAKAGE. THIS PART HAD TO BE REPLACED TO PREVENT COOLANT LOSS. I HAD TO PURCHASE THE PART AND PAY TO HAVE IT REPLACED.*AK
NHTSA ODI #10074806
117,700 miles · Jun 1, 2004
Visibility
I WAS DRIVING HOME FROM WORK. IT WAS A NICE DAY SO I HAD THE FRONT WINDOWS OPEN PART WAY. WHEN I HIT THE EXPRESSWAY, I DECIDED TO PUT THE WINDOWS UP. WHEN I HIT THE SWITCH FOR THE PASSENGER WINDOW, I HEARD THE SOUND OF PLASTIC BREAKING. I LOOKED OVER AND SAW THE PASSENGER WINDOW FALL INTO THE DOOR. I DROVE HOME AND REMOVED …
Read full complaint
I WAS DRIVING HOME FROM WORK. IT WAS A NICE DAY SO I HAD THE FRONT WINDOWS OPEN PART WAY. WHEN I HIT THE EXPRESSWAY, I DECIDED TO PUT THE WINDOWS UP. WHEN I HIT THE SWITCH FOR THE PASSENGER WINDOW, I HEARD THE SOUND OF PLASTIC BREAKING. I LOOKED OVER AND SAW THE PASSENGER WINDOW FALL INTO THE DOOR. I DROVE HOME AND REMOVED THE PANEL TO FIND A COUPLE OF BROKEN PLASTIC CLIPS IN THE BOTTOM OF THE DOOR. I HAVE NOT CONTACTED VOLKWAGEN YET, BUY APPARENTLY THIS IS AN ONGOING PROBLEM THAT VOLKSWAGEN REFUSES TO RECALL.*AK
NHTSA ODI #10074634
20,000 miles · May 28, 2004
Suspension
STRUTS (FRONT) NEEDED TO BE REPLACED AT OWNERS EXPENSE AFTER WARRANTY EXPIRED IN SPITE OF THE FACT THAT THE PROBLEM WAS REPORTED TO THE DEALER AT THE TIME OF DELIVERY OF THE CAR (WELL WITHIN THE WARRANTY PERIOD). THE REPORT OF PROBLEMS WAS IGNORED BY THE DEALER AND NOT EVEN RECORDED AS A COMPLAINT UNTIL AFTER THE WARRANTY HAD E…
Read full complaint
STRUTS (FRONT) NEEDED TO BE REPLACED AT OWNERS EXPENSE AFTER WARRANTY EXPIRED IN SPITE OF THE FACT THAT THE PROBLEM WAS REPORTED TO THE DEALER AT THE TIME OF DELIVERY OF THE CAR (WELL WITHIN THE WARRANTY PERIOD). THE REPORT OF PROBLEMS WAS IGNORED BY THE DEALER AND NOT EVEN RECORDED AS A COMPLAINT UNTIL AFTER THE WARRANTY HAD EXPIRED. WHEN THE DEALER DIAGNOSED THE PROBLEM (AFTER THE WARRANTY HAD EXPIRED) THEY INDICATED THAT THE CAR MUST BE IMMEDIATELY REPAIRED FOR SAFETY REASONS. THIS SAFETY PROBLEM EXISTED BEGINNING FROM THE TIME OF DELIVERY. THE DEALER AND VW HAVE REFUSED TO ADDRESS THE COST RELATED TO THIS ISSUE. *LA
NHTSA ODI #10073287
69,950 miles · May 27, 2004
Power Train
THE CARS TRANSMISSION DID NOT LOCK IN THE PARK POSITION AND ROLLED IN THE CURB JUST MISSING ANOTHER CAR. THE AUTOMATIC TRANSMISSION SAFETY(FOR THE PARK POSITION) LOCK FAILED AND WILL NOT ALLOW ME TO PLACE THE CAR IN PARK. *MR
NHTSA ODI #10073254
Mileage unknown · May 21, 2004
EquipmentVisibility
I OWN A 1999 VOLKSWAGEN JETTA. I HAVE NOW HAD TO REPLACE THE WINDOW REGULATOR ON 2 OCCASIONS. A QUICK SURVEY OF THE INTERNET SHOWS THAT THIS IS NOT AN UNUSUAL REPAIR.*AK
NHTSA ODI #10072970
101,000 miles · May 15, 2004
Engine And Engine Cooling
I HAVE A NEW 1999 VW JETTA TDI AND I KEEP HAVING PROBLEMS WITH BREAKING OIL PANS. THERE IS A PROBLEM WITH THE GROUNG CLEARANCE WITH THE CAR. I AM ON MT 3RD OIL PAN AND GOING ON THE 4TH. *AK
NHTSA ODI #10072672
75,500 miles · Apr 21, 2004
Vehicle Speed Control
WHILE DRIVING AT VARIOUS SPEEDS: THE VEHICLE LOSES SPEED CONTROL (ACCELERATION PEDAL NON-RESPONSIVE), THE EPC SENSOR LIGHT TURNS ON, AND THE ENGINE LIGHT TURNS ON. WITHOUT SPEED CONTROL I MUST QUICKLY MANEUVER TO THE SHOULDER TO AVOID OBSTRUCTION OF FREE-FLOWING TRAFFIC. IF I SHUT THE ENGINE OFF AND TURN IT ON AGAIN, THE VEHIC…
Read full complaint
WHILE DRIVING AT VARIOUS SPEEDS: THE VEHICLE LOSES SPEED CONTROL (ACCELERATION PEDAL NON-RESPONSIVE), THE EPC SENSOR LIGHT TURNS ON, AND THE ENGINE LIGHT TURNS ON. WITHOUT SPEED CONTROL I MUST QUICKLY MANEUVER TO THE SHOULDER TO AVOID OBSTRUCTION OF FREE-FLOWING TRAFFIC. IF I SHUT THE ENGINE OFF AND TURN IT ON AGAIN, THE VEHICLE REGAINS SPEED CONTROL UNTIL THE NEXT OCCURRENCE (THERE IS NO PATTERN). MY MECHANICS HANDHELD COMPUTER HAS IDENTIFIED AN INTERMITTENT PROBLEM WITH THE THROTTLE BODY , WHICH IS A BY-WIRE SPEED CONTROL SYSTEM. HAVING READ SIMILAR COMPLAINTS ON THE WEB, I SUSPECT THAT THIS MAY BE A COMMON PROBLEM WITH THIS SPEED CONTROL DEVICE THAT COSTS ALMOST $700 TO REPLACE (EXCLUDING LABOR).*AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.
1999 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration