NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
349 reports75,000 miles · Apr 21, 2004
Electrical System
MY 1999 JETTA IV (GLS VR6) NEEDED A NEW COIL PACK AT 75,000 MILES (ROUGH OPERATION IN WET WEATHER; ENGINE LIGHT FINALLY TURNED-ON). I HAVE READ THAT THE REPLACEMENT OF THE COIL PACK ON THE 1999 JETTA'S IS EXTREMELY COMMON. A RECALL ON THIS PART HAS BEEN ISSUED FOR THE 2000 AND 2001 VEHICLES, BUT NOT FOR THE 1999. I ALSO READ T…
Read full complaint
MY 1999 JETTA IV (GLS VR6) NEEDED A NEW COIL PACK AT 75,000 MILES (ROUGH OPERATION IN WET WEATHER; ENGINE LIGHT FINALLY TURNED-ON). I HAVE READ THAT THE REPLACEMENT OF THE COIL PACK ON THE 1999 JETTA'S IS EXTREMELY COMMON. A RECALL ON THIS PART HAS BEEN ISSUED FOR THE 2000 AND 2001 VEHICLES, BUT NOT FOR THE 1999. I ALSO READ THAT SOME INDIVIDUALS MAY BE IN PURSUIT OF OBTAINING LEGAL ACTIONS TO RESOLVE MATTERS. THE PART AND LABOR IS EXPENSIVE. PLEASE ADVISE ON WHETHER A RECALL FOR THE 1999 COIL PACK OF JETTA VEHICLES WILL BE ACKNOWLEDGED?*A
NHTSA ODI #10067566
Mileage unknown · Apr 16, 2004
Vehicle Speed Control
WHILE DRIVING 75 MPH VEHICLE STALLED. THROTTLE SPEED SENSOR LIGHT FLASHED ON THE DASHBOARD FOR A MINUTE AND WENT OFF. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE THROTTLE SPEED SENSOR NEEDED CLEANING. *AK
NHTSA ODI #10067281
Mileage unknown · Apr 9, 2004
Electrical System
THE COIL PACK ON THE 1999 JETTA'S ON MORE THAN A NUMBER OF VEHICLES HAVE NEEDED TO BE REPLACED. A RECALL ON THIS PART HAS BEEN ISSUED FOR THE 2000 AND 2001 VEHICLES. MORE THAN A DOZEN OF INDIVIDUALS I HAVE PERSONALLY SPOKEN TO HAVE HAD THE SAME PROBLEM WITH THE 1999 JETTA AND MAY BE IN PURSUIT OF OBTAINING LEGAL ACTIONS TO RES…
Read full complaint
THE COIL PACK ON THE 1999 JETTA'S ON MORE THAN A NUMBER OF VEHICLES HAVE NEEDED TO BE REPLACED. A RECALL ON THIS PART HAS BEEN ISSUED FOR THE 2000 AND 2001 VEHICLES. MORE THAN A DOZEN OF INDIVIDUALS I HAVE PERSONALLY SPOKEN TO HAVE HAD THE SAME PROBLEM WITH THE 1999 JETTA AND MAY BE IN PURSUIT OF OBTAINING LEGAL ACTIONS TO RESOLVE MATTERS. THE PART AND LABOR CAN EASILY COST OVER $600 TO REPLACE. PLEASE ADVISE ON WHETHER A RECALL FOR THE 1999 COIL PACK OF JETTA VEHICLES WILL BE ACKNOWLEDGED?*AK
NHTSA ODI #10065828
Mileage unknown · Apr 8, 2004
Visibility
BOTH MY PASSEGER SIDE WINDOW AND THE REAR WINDOW OF THE PASSENGER SIDE DOES NOT WORK - I HEARD THERE WAS A RECALL BUT I CAN NOT FIND ANY INFORMATION. *AK
NHTSA ODI #10065755
50,090 miles · Mar 14, 2004
Seat Belts
THE CENTER REAR SEATBELT LOCKED UP AND WILL NOT RELEASE, WAS TOLD BY DEALER AND VW CUSTOMER SERVICE THAT THIS IS EXTREMELY COMMON, I WAS ADVISED I CAN EITHER PAY THE $200 + TO GET IT REPAIRED OR ELSE CUT IT AND NOT USE IT. *AK
NHTSA ODI #10062158
Mileage unknown · Mar 12, 2004
Electrical SystemExterior LightingVisibility
WHILE DRIVING TO WORK, MY HEADLIGHTS, DASHLIGHTS, HEATER/DEFROST, ALL WENT OUT AND MY E-BRAKE LIGHT CAME ON. DO TO THE CONDITIONS AND THE COLD, MY WINDSHIELD FOGGED UP EXTEMEMLY QUICKLY AND MADE IT DIFFICULT TO DRIVE. THIS HAS HAPPENED MANY TIMES SINCE, ALMOST ON A DAILY BASIS. I FIGURED OUT LATER ON, THAT BY MOVING THE IGNI…
Read full complaint
WHILE DRIVING TO WORK, MY HEADLIGHTS, DASHLIGHTS, HEATER/DEFROST, ALL WENT OUT AND MY E-BRAKE LIGHT CAME ON. DO TO THE CONDITIONS AND THE COLD, MY WINDSHIELD FOGGED UP EXTEMEMLY QUICKLY AND MADE IT DIFFICULT TO DRIVE. THIS HAS HAPPENED MANY TIMES SINCE, ALMOST ON A DAILY BASIS. I FIGURED OUT LATER ON, THAT BY MOVING THE IGNITION SWITCH AROUND, EVERYTHING WENT BACK TO NORMAL. I HAVE NOT CONTACTED THE DEALER ABOUT THIS DUE TO MY MILITARY SCHEDULE. I AM DEPLPYED RIGHT NOW AND AM PLANNING TO CONTACT THE DEALER IN FARGO AS SOON AS I RETURN.*AK
NHTSA ODI #10062053
65,000 miles · Jan 23, 2004
Vehicle Speed Control
I WAS DRIVING MY 1999 VW JETTA AT HIGHWAY SPEEDS, AND IT SUDDENLY BEGAN TO ACCELERATE. I SHIFTED THE CAR INTO NEUTRAL, AND THE ENGINE CONTINUED TO REV TO THE REDLINE. I THEN TAPPED THE GAS PEDAL AND THE THROTTLE RELEASED. MY WIFE HAD THE SAME PROBLEM ON A SIDE ROAD. THE CAR BEGAN TO ACCELERATE, AND SHE APPLIED THE BRAKES BUT…
Read full complaint
I WAS DRIVING MY 1999 VW JETTA AT HIGHWAY SPEEDS, AND IT SUDDENLY BEGAN TO ACCELERATE. I SHIFTED THE CAR INTO NEUTRAL, AND THE ENGINE CONTINUED TO REV TO THE REDLINE. I THEN TAPPED THE GAS PEDAL AND THE THROTTLE RELEASED. MY WIFE HAD THE SAME PROBLEM ON A SIDE ROAD. THE CAR BEGAN TO ACCELERATE, AND SHE APPLIED THE BRAKES BUT COULD NOT STOP THE CAR. SHE TURNED THE IGNITION OFF AND WAS ABLE TO STOP SAFELY USING THE EMERGENCY BRAKE. *LA
NHTSA ODI #10054779
43,000 miles · Jan 21, 2004
Vehicle Speed Control
WHILE DRIVING VEHICLE STALLED UNEXPECTEDLY AND THEN ENGINE REVVED. *AK
NHTSA ODI #10055608
53,000 miles · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicVisibilityCrash
2 DAYS AFTER WE PURCHASE THE CAR A BRAKE SHOE BRAKET CAME OFF AND WAS RUBBING THE REAR ROTOR. JULY, 3 WINDOWS WENT BAD, 2 WERE THE WIRING AND 1 WAS THE MOTOR. OCTOBER THE FRONT WHEEL BEARING NEEDED REPLACED PLUS WHEEL ALIGNMENT. SEPTEMBER THE EXHUAST BROKE OFF BEHIND THE CATALYTIC CONVERTER I HAD IT FIXED MYSELF. THE EXHUAST HAD…
Read full complaint
2 DAYS AFTER WE PURCHASE THE CAR A BRAKE SHOE BRAKET CAME OFF AND WAS RUBBING THE REAR ROTOR. JULY, 3 WINDOWS WENT BAD, 2 WERE THE WIRING AND 1 WAS THE MOTOR. OCTOBER THE FRONT WHEEL BEARING NEEDED REPLACED PLUS WHEEL ALIGNMENT. SEPTEMBER THE EXHUAST BROKE OFF BEHIND THE CATALYTIC CONVERTER I HAD IT FIXED MYSELF. THE EXHUAST HAD ALSO BROKE OFF 6 MONTHS EARLIER IN FRONT OF THE MUFFLER BUT I FIXED IT. ONE WINDOW THAT THEY FIXED IN JULY 2002 WENT BAD AGAIN IN JUNE OF 2003 AND NEEDED FIXED. THE REAR BRAKE ON THE SAME WHEEL THAT THEY FIXED IN JANUARY OF 2001 HAS GONE BAD NOW. I'M DONE WITH THIS CAR. IT'S BEEN IN THE SHOP MORE THEN I HAVE EVER HAD ANY CAR COMBINED. THANKS
NHTSA ODI #10070800
Mileage unknown · Jan 6, 2004
Seat Belts
REAR PASSENGER'S SEAT BELT BROKE. AFTER PUTTING THE SEAT IN THE RECLINING POSITION A PIN BROKE WHICH CONTROLLED THE RELEASING OF THE SEAT BELT, SAID THE DEALER. *AK
NHTSA ODI #10053472
Official recalls
6May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Apr 23, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
Feb 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.
Illustration