I BOUGHT THE CAR IN AUGUST 2003, I NOTICED A REPAIR DOCKET FROM PREVIOUS OWNER FOR LEFT LOWER BALL JOINT AND LEFT TIE ROD ASSEMBLE W FRONT END ALIGNMENT ON 5/29/03 AT 34383 MILES. I HAD A LOT OF NOISE UNDER THE ENGINE. VW CAPISTRANO CHECKED IT OUT AND SAID IT WAS DRIVER SIDE BALL JOINT. I BOUGHT CAR FROM A FORD DEALER WHO DID …
Read full complaint
I BOUGHT THE CAR IN AUGUST 2003, I NOTICED A REPAIR DOCKET FROM PREVIOUS OWNER FOR LEFT LOWER BALL JOINT AND LEFT TIE ROD ASSEMBLE W FRONT END ALIGNMENT ON 5/29/03 AT 34383 MILES. I HAD A LOT OF NOISE UNDER THE ENGINE. VW CAPISTRANO CHECKED IT OUT AND SAID IT WAS DRIVER SIDE BALL JOINT. I BOUGHT CAR FROM A FORD DEALER WHO DID NOT WANT ANYTHING TO DO WITH IT. FINALLY, VW CAPISTRANO FORCED THEIR HAND AND PROCESSED IT THROUGH MY THEN CURRENT WARRANTY. AT THE TIME, I HAD 45K MILES ON THE CAR. I THOUGHT IT SHOCKING THAT A CAR SO YOUNG SHOULD HAVE SUCH A MAJOR PROBLEM (FOR THE SECOND TIME). WHEN I PICKED CAR UP, A COUPLE OF DAYS LATER, I HEARD A LOUD CRUNCHING NOISE IN THE FRONT LEFT HAND SIDE OF THE MOTOR OR WHEEL. I THOUGHT NOTHING OF IT, DROVE IT ANOTHER 5000 MILES, HAD TO REPLACE 4 TIRES, AND ASKED THE TIRE TECH TO CHECK IT OUT. HE SAID IT WAS THE STEERING KNUCKLE AND IT WAS IN BAD SHAPE. I CONTACTED VW WHO SAID, BAD LUCK, IT'S ONLY COVERED FOR 24K MILES OR 2YEARS. I AGAIN AM SHOCKED, FIRSTLY BECAUSE THAT'S IMPOSSIBLE ONE OF THESE SHOULD GO OUT SO EARLY, ADDED TO THAT, IF THE BALL JOINT WAS REPLACED, THEN ISN'T THE STEERING KNUCKLE, MOVED IN SOME WAY SHAPE OR FORM, SO THERE SHOULD BE SOME SORT OF RECOURSE. THIS CAR IS A LEMON, HOWEVER, CA LAW STATES IT ISN'T. I WAS RIPPED OFF BY THEODORE ROBBINS IN COSTA MESA AND WOULDN'T RECOMMEND ANYONE BUY FROM THEM, THEY WERE SUSPECT FROM DAY ONE ONCE I DROVE MY CAR FROM THEIR LOT. ALSO, THE BACK RIGHT SEAT BELT IS FIXED TO THE SEAT AND IS UNUSABLE, I COMPLAINED IT WAS DANGEROUS, FORD SAID TOO BAD, YOU BOUGHT IT THAT WAY FIX IT. SINCE THEN MY HORN HAS GONE OUT BECAUSE THE CAR 'LOST' IT'S UNDER WHEEL COVER AND WATER GOT INTO THE HORN. THIS CAR REPORTEDLY HAD A 100 POINT INSPECTION, WHICH I BELIEVE TO BE NOT TRUE. THE RADIO HAS NEVER WORKED A DAY, IT'S ALWAYS 'FUZZY'. *AK
NHTSA ODI #10080543
61,258 miles · Aug 1, 2003
Steering
ENGINE SHUT OFF COMPLETELY WHILE DRIVING ABOUT 45 MPH WITH NO WARNING. LOST POWER ASSISTED STEERING.*AK
NHTSA ODI #10030571
64,150 miles · Aug 1, 2003
Steering
ENGINE SHUT OFF COMPLETELY WHILE DRIVING ABOUT 40 MPH WITH NO WARNING. LOST POWER ASSISTED STEERING. *AK
NHTSA ODI #10030570
Mileage unknown · Jul 18, 2001
Engine And Engine CoolingService Brakes, HydraulicSteering
CAR DIES WHILE DRIVING AT ANY SPEEDS NO POWER-BRAKES OR STEERING. *AK
NHTSA ODI #748711
Mileage unknown · May 21, 2001
SteeringSuspensionUnknown Or Other
THIS CAR WAS PURCHASED NEW IN JULY 2000. IT IS THE NEWLY REDESIGNED JETTA. SINCE IT'S PURCHASE THE CAR HAS BEEN IN THE SHOP 9 TIMES FOR WATER/AIR LEAKS, TWICE FOR FAILED DRIVERS SIDE FRONT SUSPENSION STEERING FAILURE, NAMELY THE SHOCK, BEARING, SPACER, RETAINER (STRUTS). IN ADDITION SEVERAL PIECES OF THE INSIDE MOLDING HAVE DETA…
Read full complaint
THIS CAR WAS PURCHASED NEW IN JULY 2000. IT IS THE NEWLY REDESIGNED JETTA. SINCE IT'S PURCHASE THE CAR HAS BEEN IN THE SHOP 9 TIMES FOR WATER/AIR LEAKS, TWICE FOR FAILED DRIVERS SIDE FRONT SUSPENSION STEERING FAILURE, NAMELY THE SHOCK, BEARING, SPACER, RETAINER (STRUTS). IN ADDITION SEVERAL PIECES OF THE INSIDE MOLDING HAVE DETACHED. ONE OF THE LARGEST SAFETY ISSUES FOR ME, OTHER THAN THE STRUT, IS THE POORLY DESIGNED FLOOR MATS WHICH POP LOOSE, SLIP FORWARD , AND CATCH THE GAS PETAL CAUSING ACCERLARATION. THE AIR CONDITIONER HAS MOLDED OVER TWICE. I HAVE INFORMED BOTH THE SELLER AND THE MANUFACTURING OF MY COMPLAINTS AND HAVE DEMANDED A REFUND OR A LEMON LAW TAKE BACK. I AM NOT SURE WHAT TO DO BUT FEEL VW HASN'T BEEN HONEST ABOUT ALL THE PROBLEMS THE "NEW" VW HAS HAD. I JUST WANTED TO FILE THIS COMPLAINT IN CASE OTHER OWNERS OUT THERE ARE EXPERIENCEING THE SAME PROBLEMS I AM AND HAVE NOT RECEIVED ANY HELP FROM VW ALSO.*AK
NHTSA ODI #745619
Mileage unknown · May 7, 2001
Steering
REAR CENTER SEATBELTS JAM, AND WILL NOT COME LOOSE AT ALL. DEALERSHIP IS AWARE OF PROBLEM.*AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.
1999 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration