1,371 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
Reports by model year
Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
689 reports with mileage · 682 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
1,371 reportsElectrical SystemEngine
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE ATTEMPTING TO MAKE A TURN FROM A STOP, THE VEHICLE LOST POWER. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED WITHIN TWO SECONDS, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO GETTEL TOYOTA OF LAKEWOOD (941-567-1080, LOCATED AT 5959 E. STATE RD 64, BRADENTON,…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE ATTEMPTING TO MAKE A TURN FROM A STOP, THE VEHICLE LOST POWER. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED WITHIN TWO SECONDS, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO GETTEL TOYOTA OF LAKEWOOD (941-567-1080, LOCATED AT 5959 E. STATE RD 64, BRADENTON, FL 34208) WHERE IT WAS DETERMINED THAT THE VEHICLE WAS PERFORMING AS DESIGNED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND DID NOT ASSIST. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.
NHTSA ODI #11184350
Electrical SystemStructureUnknown Or OtherFire
I WAS DRIVING TO WORK AROUND 740AM ON 287 SOUTH JUST PAST RT 24. DASHBOARD HAS "4WD" WARNING AND SMOKE COMING OUT FROM HOOD. I QUICKLY MOVED TO THE SHOULDER AND FIRE BROKE OUT BEFORE CAR CAME TO FULL STOP, ALL WITHIN ONE MINUTE. I BARELY ESCAPE THE CAR AND CALLED POLICE AND FIRE DEPT. THEY CAME AND PUT OFF THE FIRE. THERE ARE TW…
Read full complaint
I WAS DRIVING TO WORK AROUND 740AM ON 287 SOUTH JUST PAST RT 24. DASHBOARD HAS "4WD" WARNING AND SMOKE COMING OUT FROM HOOD. I QUICKLY MOVED TO THE SHOULDER AND FIRE BROKE OUT BEFORE CAR CAME TO FULL STOP, ALL WITHIN ONE MINUTE. I BARELY ESCAPE THE CAR AND CALLED POLICE AND FIRE DEPT. THEY CAME AND PUT OFF THE FIRE. THERE ARE TWO EXPLOSIONS BEFORE THE FIRE WAS PUT OFF.
NHTSA ODI #11183106
Electrical SystemElectronic Stability Control (esc)Service Brakes
TL* THE CONTACT OWNS A 2018 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 65 MPH IN SNOW AND ICY CONDITIONS, THE WARNING MESSAGES SUDDENLY DISPLAYED INDICATING THAT THE BRAKES AND SAFETY FEATURES WERE NOT AVAILABLE, AND INSTRUCTED THE DRIVER NOT TO DRIVE THE VEHICLE. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RESUMED NORMAL OP…
Read full complaint
TL* THE CONTACT OWNS A 2018 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 65 MPH IN SNOW AND ICY CONDITIONS, THE WARNING MESSAGES SUDDENLY DISPLAYED INDICATING THAT THE BRAKES AND SAFETY FEATURES WERE NOT AVAILABLE, AND INSTRUCTED THE DRIVER NOT TO DRIVE THE VEHICLE. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT RESUMED NORMAL OPERATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. LOVE TOYOTA (215 E. FAIRMOUNT AVE, LAKEWOOD, NY) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 7,000. *BF CONSUMER LET THE CAR SIT FOR 15", CLEARED THE ICE OFF. THE TECHNICIAN STATED FEATURE WERE SATELLITE ENABLED AND PROBABLY THE ICE INTERSECTED WITH THE SIGNALS.*JB
NHTSA ODI #11181327
Electrical System
ON 01/31/19 I WAS DRIVING MY 2017 RAV4 ON FREEWAY ABOUT 4 MILES THEN LOCAL ABOUT 5 BLOCKS I HEARD NOISE ON MY CAR SO I STOPPED. IT TURNED OUT I HAD A FLAT ON MY FRONT PASSENGER TIRE. I REPLACED IT WITH SPARE AND THE 'LOW TIRE PRESSURE' LIGHT JUST CAME ON. I THEN REALIZED WHY THE LTP LIGHT NEVER CAME ON BEFORE I REPLACED WITH SP…
Read full complaint
ON 01/31/19 I WAS DRIVING MY 2017 RAV4 ON FREEWAY ABOUT 4 MILES THEN LOCAL ABOUT 5 BLOCKS I HEARD NOISE ON MY CAR SO I STOPPED. IT TURNED OUT I HAD A FLAT ON MY FRONT PASSENGER TIRE. I REPLACED IT WITH SPARE AND THE 'LOW TIRE PRESSURE' LIGHT JUST CAME ON. I THEN REALIZED WHY THE LTP LIGHT NEVER CAME ON BEFORE I REPLACED WITH SPARE. I TOOK THE RAV4 TO PASADENA TOYOTA TO RUN THE DIAGNOSTIC CHECK TO FIND OUT WHY LTP LIGHT NEVER CAME ON WHEN I WAS DRIVING ON A FLAT. THE DIAGNOSTIC FOUND 'NOTHING WRONG' AND THE SYSTEM DIDN'T RECORD ANYTHING. THEY ALSO TOLD ME THE TIRE SUFFERED 'RUN FLAT DAMAGE' AND NOT REPAIRABLE. I THEN CALLED TOYOTA CUSTOMER SVC. CASE # 1902010530, CASE MANAGER DEREK. DEREK JUST INFORMED ME ON 2/11/19 THAT THE LTP LIGHT WILL NOT COME ON WHEN THE TIRE SUDDEN LOST PRESSURE AND TURN FLAT (OWNER'S MANUAL PG 571). I ASKED HIM WHY THE LIGHT DIDN'T COME ON WHEN I DROVE IT ON FLAT FOR A WHILE TO CAUSE THE RUN FLAT DAMAGE. WASN'T THE TIRE PRESSURE LOW ENOUGH WHEN IT'S FLAT? HE SAID THE LIGHT WILL NOT COME ON WHEN IT'S FLAT. THIS SOUNDS VERY DANGEROUS IF THE WARNING LIGHT DOESN'T SEND OUT SIGNAL EVEN WHEN IT'S FLAT. HOWEVER PASADENA TOYOTA SVC ADVISOR TOLD ME THE SYSTEM IS SUPPOSED TO CHECK THE PRESSURE EVERY 30 SECONDS. THIS CONFLICTS WITH WHAT DEREK TOLD ME. IF I ONLY DROVE WITH FLAT FOR 30 SECONDS LOCALLY IT WOULD NOT HAVE CAUSED 'RUN FLAT DAMAGE'. I WAS ESPECIALLY DRIVING SLOW LOCALLY ON 1/31/19 BECAUSE OF THE TRAFFIC. I MUST HAVE DRIVEN IT MORE THAN 30 SECONDS (TO CAUSE THE RUN FLAT DAMAGE) BUT THE SYSTEM FAILED TO DETECT IT AND SENT ME THE WARNING. I KEEP THE DAMAGE TIRE IN CASE FURTHER INVESTIGATION IS NEEDED. WE ALSO HAD ANOTHER ELECTRICAL ISSUE WITH THIS 2017 RAV4 WHEN IT WAS ONLY 6 MONTHS OLD. A WARNING LIGHT CAME ON FOR NO REASON SO WE BROUGHT IT TO DEALER TO CHECK ON 10/30/17. AGAIN, THE DIAGNOSTIC FOUND NOTHING. CAN I TRUST MY DASHBOARD?
NHTSA ODI #11176309
Electrical SystemEngine
WHILE DRIVING THE CAR JUST SHUT DOWN AND THE CODE READ CHARGING SYSTEM MALFUNCTION, WE HAD IT TOWED TO THE DEALERSHIP AND THEY ERASED THE CODES BUT THEY ACKNOWLEDGED THEY EXISTED HOWEVER THEY SAID THERE IS NOTHING WRONG AND WANT US TO CONTINUE DRIVING THIS VEHICLE WITH NO ASSURANCE IT WILL NOT HAPPEN AGAIN
NHTSA ODI #11176121
Electrical SystemPower Train
POWER TRANSMISSION, SAFETY ISSUE, THE POWER TRANSMISSION WILL NOT SHIFT IN A TIMELY MANNER TO PROPER GEARS,IN COLD WEATHER, THIS IS A SAFETY ISSUE, WHEN ENTERING THE FREEWAY AFTER LEAVING WORK, THE CAR WILL ONLY GO 30 MPH AT 3,500 RPM. UNTIL THE CAR WARMS UP, THIS HAS NEVER HAPPENED BEFORE, AND NOW IT IS. TOYOTA DEALER CONFIRME…
Read full complaint
POWER TRANSMISSION, SAFETY ISSUE, THE POWER TRANSMISSION WILL NOT SHIFT IN A TIMELY MANNER TO PROPER GEARS,IN COLD WEATHER, THIS IS A SAFETY ISSUE, WHEN ENTERING THE FREEWAY AFTER LEAVING WORK, THE CAR WILL ONLY GO 30 MPH AT 3,500 RPM. UNTIL THE CAR WARMS UP, THIS HAS NEVER HAPPENED BEFORE, AND NOW IT IS. TOYOTA DEALER CONFIRMED THAT THE SHIFT POINTS ARE HIGHER THAN NORMAL, WHEN FIRST STARTED IN THE MORNING, AND PER THE DEALER WELL IT TAKES AWHILE FOR THE CAR TO WARM UP BEFORE IT WILL GO TO NORMAL SHIFT POINTS, AND ALLOW THE TRANSMISSION TO FUNCTION NORMALLY. WELL 30 MPH AT 3500 RPM, THIS IS NOT NORMAL, AND THIS IS A SAFETY ISSUE, SO WHEN YOU LEAVE WORK YOUR CAR WILL ONLY GO 30 MPH ON A 60 MPH FREEWAY. THE DEALERS RESPONSE IS AFTER IT HAS BEEN RUNNING AND WARMED UP IT WILL WORK NORMALLY. THERE IS NOTHING NORMAL ABOUT THIS ISSUE, NEVER HAD THIS ISSUE LAST WINTER NOW ALL OF A SUDDEN HAVING THIS ISSUE THIS WINTER.
NHTSA ODI #11173469
Electrical SystemPower Train
THE TRANSMISSION, IS NOT SHIFTING PROPERLY IN EVEN MILDLY COLD WEATHER. HAD THE CAR FOR TWO YEARS, AND NOW THE TRANMISSION, IS NOT SHIFTING PROPERLY WHEN YOU FIRST START IT UP. THE ENGINE RPMS ARE AT 3,500, WHEN DOING 30 MPH DOWN THE ROAD,AND PUSHING ALL THE WAY DOWN ON THE ACCELERATOR, THE CAR WILL NOT GO, THERE ARE NO ERROR L…
Read full complaint
THE TRANSMISSION, IS NOT SHIFTING PROPERLY IN EVEN MILDLY COLD WEATHER. HAD THE CAR FOR TWO YEARS, AND NOW THE TRANMISSION, IS NOT SHIFTING PROPERLY WHEN YOU FIRST START IT UP. THE ENGINE RPMS ARE AT 3,500, WHEN DOING 30 MPH DOWN THE ROAD,AND PUSHING ALL THE WAY DOWN ON THE ACCELERATOR, THE CAR WILL NOT GO, THERE ARE NO ERROR LIGHTS, THERE IS AN TRANMISSION SHIFT ISSUE WITH ACCELERATION ISSUE. THIS IS DANGEROUS BECAUSE WHEN GOING DOWN A 35 MPH ROAD, THERE ARE CARS THAT CAN ACCELERATE AND THIS CAR GOES NOWHERE. START THE CAR AFTER BEING PARKED OUTSIDE IN COLD WEATHER, WAITED 5 MINUTES BEFORE DRIVING THE CAR, AND IT IS STILL NOT RESPONDING PROPERLY. THERE HAVE BEEN ELECTRICAL ISSUES WITH THIS CAR, AND NOW THE TRANSMISSION WILL NOT SHIFT AND GO INTO GEAR PROPERLY, NOT SURE IF ITS THE COMPUTER PROGRAM, OR GEAR ISSUE. NEVER HAD THIS PROBLEM UNTIL THE SECOND YEAR OF OWNERSHIP. OWNED THE CAR SINCE IT WAS BRAND NEW. THIS IS A SAFETY ISSUE, WITH THE CAR NOT BEING ABLE TO GO THE PROPER SPEED LIMIT, AND THE DEALER IS TRYING TO SAY OH, IT TAKES A WHILE FOR THE CAR TO WARM UP, DID NOT HAVE THAT PROBLEM LAST WINTER BEING LEFT OUT ALL DAY AND NIGHT. THERE IS AN ELECTRONIC CONTROL MODULE FOR THE TRANSMISSION, AND THE GEARS THIS IS A SAFETY ISSUE THAT TOYOTA NEEDS TO ADDRESS, THE CAR WILL NOT EVEN ACCELERATE PROPERLY BECAUSE OF THIS TRANSMISSION ISSUE AND IF YOU DO ACCELERATE YOU CAN END UP RUINNING THE ENGINE.
NHTSA ODI #11173462
Electrical System
WHEN IT IS RAINING, OR SNOWING AND FOR SOME REASON, THE SENSORS GET WET FROM THE BUMPER, CROSSTRAFFIC ALERT OR BACKUP OR SIDE WARNING, THE WHOLE SYSTEM SHUTS DOWN. DRIVING ON THE FREEWAY AND IT IS RAINING AND THE WHOLE COMPUTER JUST FROZE, AND LOST ALL SENSORS AND A FAILURE ALERT SHOWED UP ON THE DASHBOARD, ALONG WITH THE CARS T…
Read full complaint
WHEN IT IS RAINING, OR SNOWING AND FOR SOME REASON, THE SENSORS GET WET FROM THE BUMPER, CROSSTRAFFIC ALERT OR BACKUP OR SIDE WARNING, THE WHOLE SYSTEM SHUTS DOWN. DRIVING ON THE FREEWAY AND IT IS RAINING AND THE WHOLE COMPUTER JUST FROZE, AND LOST ALL SENSORS AND A FAILURE ALERT SHOWED UP ON THE DASHBOARD, ALONG WITH THE CARS TRANSMISSION HAVE A HARD TIME SHIFTING AS EXITING THE FREE WAY. THIS IS TOTAL COMPUTER FAILURE BUT AFTER EXITING THE FREEWAY AND DRIVING DOWN A ROAD, AND AT A STOP LIGHT PUT THE TRANSMISSION IN NEUTRAL AND SHIFTING BACK TO DRIVE, ALL THE COMPUTER ERRORS CLEARED. TOOK IT TO THE DEALER AND OF COURSE THEY FOUND NOTHING. THIS IS DANGEROUS FOR BLIND SPOT WARNING SENSORS TO GO OUT THE PBM SENSOR SAID FAILURE AND THERE IS AN ELECTRIC HARNESS ISSUE WITH THIS CAR WHERE THE WIRES EITHER WERE NOT INSULATED OR NICK ALONG WITH THE COMPUTER MODEL TO THE TRANSMISSION. THERE IS FAULTY INSULATION, THIS HAPPENS ONLY ON OCCASION AND NOT ALL THE TIME, AND EVERY NOW AND THEN THERE IS A COMPUTER ISSUE, THE CLEARS ITSELF. ALSO THE CLOCK WAS LOSING TIME. DUE TO THE ELECTRICAL ISSUES THIS IS A SAFETY ISSUE,. WHEN EVERYTHING SHUTS DOWN WHEN THE CAR IS BEING DRIVEN IS A SAFETY ISSUE. YET, SHIFTING THE TRANSMISSION CLEARED THE ERRROS OFF THE DASH.
NHTSA ODI #11173461
Electrical SystemSteering
STEERING FROZE UP WHILE LEAVING MY DRIVEWAY AND P/S LIGHT CAME ON. SHUT ENGINE OFF AND BACK ON, BUT DID NOT RESOLVE. I RECALL AT LEAST ONE OTHER TIME THAT STEERING LOCKED UP TEMPORARILY WHILE AT A STOP. TOOK TO DEALERSHIP FOR DIAGNOSTIC AS MANUAL RECOMMENDS. DIAGNOSTIC SHOWS DTCS U0105 AND U0121. FOUND TAB ST005-06 RELATED TO …
Read full complaint
STEERING FROZE UP WHILE LEAVING MY DRIVEWAY AND P/S LIGHT CAME ON. SHUT ENGINE OFF AND BACK ON, BUT DID NOT RESOLVE. I RECALL AT LEAST ONE OTHER TIME THAT STEERING LOCKED UP TEMPORARILY WHILE AT A STOP. TOOK TO DEALERSHIP FOR DIAGNOSTIC AS MANUAL RECOMMENDS. DIAGNOSTIC SHOWS DTCS U0105 AND U0121. FOUND TAB ST005-06 RELATED TO THIS ISSUE AND "UPDATED POWER STEERING ECU AVAILABLE". DIAGNOSTIC $150, PARTS AND LABOR $1600+ CLEARY THIS IS A SAFETY ISSUE REQUIRING A RECALL. PLEASE INVESTIGATE THERE ARE MANY MORE SIMILAR COMPLAINTS.
NHTSA ODI #11173531
Electrical SystemService BrakesSteering
CAR WON'T START. PANEL TURNS ON BUT IT WON'T ENGAGE THE STARTER. CAN HEAR A BUZZ NOISE, LIKE A MAGNETIZED COIL GOING OFF. SHIFTER IS LOCKED. STEERING WHEEL IS LOCKED. BRAKE IMPOSSIBLE TO PUSH DOWN. ONLY WAY I CAN START THE CAR IS WITH THE EMERGENCY PROCEDURE PUSHING THE START BUTTON FOR 15 SECONDS. BUT STILL THE SHIFTER IS BLOCK…
Read full complaint
CAR WON'T START. PANEL TURNS ON BUT IT WON'T ENGAGE THE STARTER. CAN HEAR A BUZZ NOISE, LIKE A MAGNETIZED COIL GOING OFF. SHIFTER IS LOCKED. STEERING WHEEL IS LOCKED. BRAKE IMPOSSIBLE TO PUSH DOWN. ONLY WAY I CAN START THE CAR IS WITH THE EMERGENCY PROCEDURE PUSHING THE START BUTTON FOR 15 SECONDS. BUT STILL THE SHIFTER IS BLOCKED IN PARKING AND TO BE ABLE TO DRIVE THE CAR I NEED TO USE THE LITTLE SWITCH UNDER THE BUTTON SIZE COVER NEXT TO THE SHIFTER. TOYOTA HAS NO CLUE WHAT IS GOING ON. VEHICLE HAS 45K MILES
NHTSA ODI #11172318
Related Official recalls
3Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Oct 19, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
5DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.