Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
970–25K
2125–50K
1650–75K
475–100K
4100–150K
2150K+
144 reports with mileage · 187 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports32 fire reports13 injury reports
What owners actually said
331 reports
Mileage unknown · Sep 13, 2026
Tires
Cooper tires 225/65R17. Purchased 4 tires in June. From installation the tires were bouncy. The garage said it was the struts, so I replaced the struts, but the problem persists. 2 weeks later I took the car back. They said there was nothing wrong with t he tire. They rebalanced them. But that did not fix the problem. I took the…
Read full complaint
Cooper tires 225/65R17. Purchased 4 tires in June. From installation the tires were bouncy. The garage said it was the struts, so I replaced the struts, but the problem persists. 2 weeks later I took the car back. They said there was nothing wrong with t he tire. They rebalanced them. But that did not fix the problem. I took the car to a different garage and they told me the tires where bad and advised me to take them back to wherebI purchased them. I did. After they had my car for 6 hours they said there was nothing wrong with the tires. I insisted that they inspected them again. After 3 more hours they informed me that the tires were separating and they were defective. They replaced the tires with another brand.
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into To…
Read full complaint
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.
NHTSA ODI #11754574
40,000 miles · Jul 28, 2026
Back Over Prevention
The contact owns a 2018 Toyota Rav4. The contact stated that while in reverse(R), the rear-view camera was black and failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the camera was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was n…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact stated that while in reverse(R), the rear-view camera was black and failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the camera was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 40,000.
NHTSA ODI #11753295
Mileage unknown · Jul 10, 2026
Unknown Or Other
The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem…
Read full complaint
The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem I have 1. Tried speaking up (even yelling) 2. Turning off HVAC systems 3. Positioning my body closer to the microphone 4. Bringing the car to a slow or stop to reduce road noise. 5. Calling myself to see if I can hear myself. 6. Talked with someone who owns the same car (year/model/spec/trim) and they were hardly audible as they called me over their hands free system.
NHTSA ODI #11749459
Mileage unknown · Jul 5, 2026
Air BagsElectrical SystemExterior Lighting
While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the ele…
Read full complaint
While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the electrical systems and everything looks good according to their testing.
NHTSA ODI #11748370
Mileage unknown · Jun 27, 2026
Structure
My lift tailgate is malfunctioning. Continued forced opening can cause the hinges to crack and messes with the alignment and closing of the tail gate making it a safety issue.
NHTSA ODI #11746910
Mileage unknown · Jun 21, 2026
Air BagsCrash
We were part of a 4 car collision on the freeway. A Ford Expedition that was slammed into then slammed into our RAV. The airbags never deployed and an error code came up saying fail for airbags.
NHTSA ODI #11745520
Mileage unknown · May 28, 2026
Electrical SystemStructure
Severe, chronic rainwater intrusion through the vehicle's front cowl and body seams, resulting in catastrophic flooding of the passenger-side cabin floorboards. This issue occurs even when all sunroof drains are completely clear and functional. Toyota has issued Technical Service Bulletin 0055-24 acknowledging body seam and cowl…
Read full complaint
Severe, chronic rainwater intrusion through the vehicle's front cowl and body seams, resulting in catastrophic flooding of the passenger-side cabin floorboards. This issue occurs even when all sunroof drains are completely clear and functional. Toyota has issued Technical Service Bulletin 0055-24 acknowledging body seam and cowl leaks for this vehicle type. The passenger-side floorboard houses critical electrical wire harnesses and sits adjacent to the Supplemental Restraint System (SRS/Airbag) control module. Chronic standing water on the floorboard presents an immediate risk of electrical short-circuits, potentially causing sudden vehicle stalling, electrical component fires, or the uncommanded deployment/failure of the vehicle's airbag safety systems. Furthermore, the thick foam insulation beneath the carpet remains saturated, creating an immediate, toxic mold hazard within an enclosed passenger cabin, severely impacting occupant health and air quality. The manufacturer and dealership have left the vehicle unrepaired for over 30 days, refusing to remediate this safety hazard.
NHTSA ODI #11740651
54,968 miles · May 28, 2026
Electrical System
The contact owned a 2018 Toyota RAV4. The contact stated that the vehicle experienced a defect with the key fob and the door locks for the passenger doors. When starting the vehicle, the brake locking mechanism could not detect the key, and a message was displayed indicating that the key was not found. The contact stated that he…
Read full complaint
The contact owned a 2018 Toyota RAV4. The contact stated that the vehicle experienced a defect with the key fob and the door locks for the passenger doors. When starting the vehicle, the brake locking mechanism could not detect the key, and a message was displayed indicating that the key was not found. The contact stated that he had to open and close the door for the vehicle to engage and recognize the key. Additionally, the vehicle failed to lock automatically, which forced the contact to lock both the driver and passenger sides manually. Early corrections were made in an attempt to resolve these issues, but the problems persisted. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 54,968.
NHTSA ODI #11740582
Mileage unknown · Apr 18, 2026
Power Train
Malfunction: Mechanical failure of the Torque Converter Clutch. The vehicle exhibits a persistent transmission shudder during acceleration between 25–50 mph. Warning Signs: None. There were no dashboard warning lights or error messages prior to or during the failure. The only indicator was the physical shuddering of the vehicle.…
Read full complaint
Malfunction: Mechanical failure of the Torque Converter Clutch. The vehicle exhibits a persistent transmission shudder during acceleration between 25–50 mph. Warning Signs: None. There were no dashboard warning lights or error messages prior to or during the failure. The only indicator was the physical shuddering of the vehicle. Safety Risk: The malfunction causes unpredictable hesitation when merging or changing lanes, creating a dangerous speed differential and risk of rear-end collision. Documentation: Comprehensive maintenance records are available to prove the vehicle was serviced according to the manufacturer’s schedule at a third-party facility.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration