1,371 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
Reports by model year
Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
689 reports with mileage · 682 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
1,371 reportsElectrical SystemPower Train
TL*THE CONTACT OWNS A 2003 TOYOTA RAV4. SHE NOTICED THAT WHEN SHE STOPPED THE GEAR WILL FAIL IT WILL STAY IN DRIVE. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE DIAGNOSIS INDICATED THAT THE FAILURE WAS CAUSED BY THE ELECTRONIC CONTROL UNIT. THE DEALER REPLACED THE ECU AND THE FAILURE WAS CORRECTED. THE FAILURE MILEAGE WAS 102,00…
Read full complaint
TL*THE CONTACT OWNS A 2003 TOYOTA RAV4. SHE NOTICED THAT WHEN SHE STOPPED THE GEAR WILL FAIL IT WILL STAY IN DRIVE. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE DIAGNOSIS INDICATED THAT THE FAILURE WAS CAUSED BY THE ELECTRONIC CONTROL UNIT. THE DEALER REPLACED THE ECU AND THE FAILURE WAS CORRECTED. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 104,236. UPDATED 03/30/10. *LJ THE CONSUMER STATED WHEN SHE MADE A STOP, THE VEHICLE WOULD NOT GO INTO GEAR AND THE ENGINE REVVED, THEN SLIPPED INTO GEAR AND LURCHED FORWARD. THE CONSUMER WAS TOLD IT WAS A COMPUTER PROBLEM AND SENDING FAULTY SIGNALS TO THE TRANSMISSION. THE CONSUMER STATED THERE HAVE BEEN NO OTHER PROBLEMS SINCE. UPDATED 07/15/10*JB
NHTSA ODI #10312257
Electrical System
TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT THE ECU BOARD FAILED ON THE VEHICLE AND THAT THE DEALER SAID THAT THEY WERE AWARE OF THE FAILURE. THE DEALER STATED THAT THE ECU BOARD NORMALLY FAILED AT 75 MILES ON HIS YEAR, MAKE AND MODEL VEHICLE. AFTER THE ECU FAILED THE VEHICLE BEGAN TO LUNGE FORWARD WHEN IT SH…
Read full complaint
TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT THE ECU BOARD FAILED ON THE VEHICLE AND THAT THE DEALER SAID THAT THEY WERE AWARE OF THE FAILURE. THE DEALER STATED THAT THE ECU BOARD NORMALLY FAILED AT 75 MILES ON HIS YEAR, MAKE AND MODEL VEHICLE. AFTER THE ECU FAILED THE VEHICLE BEGAN TO LUNGE FORWARD WHEN IT SHIFTED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 105,000. UPDATED 05/10/10 *BF UPDATED 05/11/10. *JB
NHTSA ODI #10311821
Electrical System
AFTER HAVING AN OXYGEN SENSOR REPLACED IN THE EXHAUST SYSTEM OF MY 2002 TOYOTA RAV4 ON 02/02/10, I NOTICED THAT MY CAR BEGAN ACCELERATING SLUGGISHLY. APPROXIMATELY 50 MILES AFTER THE SERVICE WAS PERFORMED, I NOTICED MY CAR JERKED WHEN SHIFTING THROUGH GEARS 1-3 AND THE TACHOMETER WOULD REV TO 3000 RPMS. THE CAR THEN RAN FINE F…
Read full complaint
AFTER HAVING AN OXYGEN SENSOR REPLACED IN THE EXHAUST SYSTEM OF MY 2002 TOYOTA RAV4 ON 02/02/10, I NOTICED THAT MY CAR BEGAN ACCELERATING SLUGGISHLY. APPROXIMATELY 50 MILES AFTER THE SERVICE WAS PERFORMED, I NOTICED MY CAR JERKED WHEN SHIFTING THROUGH GEARS 1-3 AND THE TACHOMETER WOULD REV TO 3000 RPMS. THE CAR THEN RAN FINE FOR APP. 4 DAYS WITH NO GEAR SLIPPAGE. A WEEK LATER THE GEARS STARTED SLIPPING AGAIN WITHOUT WARNING AND THE CAR SEEMED TO HAVE NO POWER WHEN THE GAS PEDAL WAS FULLY ENGAGED DURING A RIGHT HAND TURN TO MERGE WITH ONCOMING TRAFFIC. THE CAR THEN BUCKED VIOLENTLY. THIS RESULTED WITH MY PASSENGER AND I BECOMING ANXIOUS/SCARED BECAUSE WE DIDN'T KNOW IF THE TRAFFIC COMING TOWARD US WOULD HAVE HIT US IF WE SUDDENLY LOST POWER. I IMMEDIATELY DROVE MY CAR HOME WHERE IT HAS REMAINED PARKED AND SET AN APPOINTMENT WITH A TOYOTA DEALER EXPLAINING THE PROBLEMS. ACCORDING TO SIMILAR STORIES FROM FELLOW RAV4 OWNERS, THERE IS A PROBLEM WITH THE ELECTRONIC CONTROL MODULE CAUSING IRREVERSIBLE DAMAGE TO THE TRANSMISSION. I AM TAKING THE CAR TO THE DEALER TO HAVE IT 'OFFICIALLY' DIAGNOSED ALTHOUGH IT ONLY CODES TO HAVE THE O2 SENSOR REPLACED, WHICH I DID. *TR
NHTSA ODI #10311123
Electrical SystemPower TrainVehicle Speed Control
COMPLAINT:SECOND COMPLAINT I PURCHASED MY TOYOTA RAV 4 2007 IN OCTOBER OF 2007. A FEW MONTHS AFTER I HAD THE CAR I STARTED NOTICING THAT THE CAR, FOR NO REASON WOULD HESITATE, LEAVING ME AT TIMES IN THE MIDDLE OF CROSSINGS AN INTERSECTIONS WITH NO POWER. AFTER OTHERS BEGAN MAKING COMMENTS THAT THERE WAS SOMETHING WRONG I BROUGH…
Read full complaint
COMPLAINT:SECOND COMPLAINT I PURCHASED MY TOYOTA RAV 4 2007 IN OCTOBER OF 2007. A FEW MONTHS AFTER I HAD THE CAR I STARTED NOTICING THAT THE CAR, FOR NO REASON WOULD HESITATE, LEAVING ME AT TIMES IN THE MIDDLE OF CROSSINGS AN INTERSECTIONS WITH NO POWER. AFTER OTHERS BEGAN MAKING COMMENTS THAT THERE WAS SOMETHING WRONG I BROUGHT IT INTO LEITH TOYOTA. THE FIRST TIME WAS APRIL 24TH 2008. I EXPLAINED TO THE SERVICE ADVISOR I WAS HAVING INTERMITTENT PROBLEMS WITH THE CAR. I TOLD HIM I WOULD START ACROSS AN INTERSECTION (4 LANES) AND ALL OF A SUDDEN THE CAR HESITATED, THERE WAS NO POWER. I WOULD PRESS THE GAS PEDAL TO THE FLOOR AND APPROXIMATELY 10-15 SECONDS LATER THE CAR WOULD LUNGE FORWARD. I TOLD THEM IT CONCERNED AND SCARED ME. I WAS TOLD THAT THEY COULD NOT FIND ANY PROBLEMS. APRIL 28TH 2008 I RETURNED AGAIN TO THE DEALERSHIP ADVISING THEM THERE WAS A PROBLEM, I WAS AFRAID TO DRIVE THE CAR AND WANTED IT FIXED. I AGAIN WAS TOLD THERE WAS NOT ANY PROBLEM WITH THE CAR. THIS TIME I REFUSED TO LEAVE UNTIL THE PROBLEM WAS FIXED. THEY FINALLY BROUGHT THE CAR BACK IN AND TOLD ME THE MODELS HAVE A PROBLEM WITH THE ECM SYSTEM. I WAS TOLD THEY REFLASHED THE ECM SYSTEM WITH AN UPDATE SENT BY CORPORATE AND THINGS SHOULD BE FINE. YESTERDAY I RETURNED TO THE DEALERSHIP. I TOLD THEM THE CAR WAS OK FOR A NUMBER OF MONTHS BUT AGAIN THIS WEEK I WAS ALMOST IN AN ACCIDENT BECAUSE THE CAR HAD STARTED TO HESITATE AGAIN, AND I AM LEFT IN THE INTERSECTION WITHOUT POWER AND ON-COMING TRAFFIC. THEY TOOK THE CAR OUT AND OF COURSE THE PROBLEM IS INTERMITTENT SO THEY WERE UNABLE TO FIND ANYTHING ABNORMAL. THEY TOLD ME THEY WOULD CHECK TO SEE IF THERE WERE ANY ADDITIONAL COMPUTER UPDATES FOR THE PROBLEM. THE CAR ALSO LOOSES POWER ON HIGHWAY AT 60 MPH, SHUTS DOWN AFTER A WHILE. THEY ADVISED ME THERE WERE NO ADDITIONAL UPDATES. I TOLD THEM THE PROBLEM IS PUTTING ME IN DANGER OF HAVING AN ACCIDENT. THEY TOLD ME TOYOTA DOES NOT FEEL THIS IS A PROBLEM. *TR UPDATED IVOQ 07/15/10.*JB
NHTSA ODI #10310470
Electrical System
WAS DRIVING IN A 55 MILE HIGHWAY CAR FELT LIKE WAS DRIVING THROUGH SLUDGE. ENGINE LIGHT CAME ON. THEN CAR STARED JERKING GOT TO SIDE OF ROAD AND HAD TOWED TO TOYOTA DEALER SHIP SAID THE TRANSMISSION CHIP WAS BAD COST AROUND $1300.. AND NEW TRANSMISSION ALTOGETHER WOULD COST ME $6000.*TR
NHTSA ODI #10308513
Electrical SystemPower Train
TOYOTA ISSUED A SECRET BULLETIN ON 3/3/2006 (TC006-02), BUT FAILED TO NOTIFY OWNERS OF 2001-2003 RAV4 VEHICLES REGARDING THEIR HARD SHIFTING, ECM PROBLEMS, AND TRANSMISSION FAILURES. DESPITE MY REPORTING THIS PROBLEM WITHIN WARRANTY PERIOD AT 54,000 MILES IN 2006, AND AGAIN IN 2007, TOYOTA CLAIMED UNABLE TO DUPLICATE PROBLEM. …
Read full complaint
TOYOTA ISSUED A SECRET BULLETIN ON 3/3/2006 (TC006-02), BUT FAILED TO NOTIFY OWNERS OF 2001-2003 RAV4 VEHICLES REGARDING THEIR HARD SHIFTING, ECM PROBLEMS, AND TRANSMISSION FAILURES. DESPITE MY REPORTING THIS PROBLEM WITHIN WARRANTY PERIOD AT 54,000 MILES IN 2006, AND AGAIN IN 2007, TOYOTA CLAIMED UNABLE TO DUPLICATE PROBLEM. THEY ARE NOW CHARGING ME 1/2 THE COST OF A NEW TRANSMISSION AT APPROXIMATELY $2,000 INCLUDING THE COST OF FLUSHING THE OLD ONE AND DIAGNOSING THE PROBLEM. *TR
NHTSA ODI #10306557
Electrical SystemPower Train
PURCHASED 2002 TOYOTA RAV4 NEW FROM TOYOTA DEALER IN OCTOBER 2001. EXPERIENCED HARD SHIFTING SEVERAL YEARS AGO WHEN TRAVELING UPHILL AND A HIGHWAY SPEEDS. TOLD THAT THE CAR WAS SHIFTING FINE. NOW THE ENGINE CONTROL MODULE NEEDS TO BE REPLACED AND POSSIBLY THE COMPLETE TRANSMISSION. TOYOTA ISSUED A TSB IN 2008 BUT I WAS NEVER IN…
Read full complaint
PURCHASED 2002 TOYOTA RAV4 NEW FROM TOYOTA DEALER IN OCTOBER 2001. EXPERIENCED HARD SHIFTING SEVERAL YEARS AGO WHEN TRAVELING UPHILL AND A HIGHWAY SPEEDS. TOLD THAT THE CAR WAS SHIFTING FINE. NOW THE ENGINE CONTROL MODULE NEEDS TO BE REPLACED AND POSSIBLY THE COMPLETE TRANSMISSION. TOYOTA ISSUED A TSB IN 2008 BUT I WAS NEVER INFORMED. THIS IS A VERY DANGEROUS SITUATION SINCE THE CAR CAN STOP AT ANY TIME. *TR
NHTSA ODI #10304602
Electrical SystemPower Train
EVENT 1: 1. SHORTLY AFTER BUYING CAR, NOTED ENGINE REVS WOULD SOAR BY 700 TO 800 RPMS BETWEEN GEARS WHILE SHIFTING MANUAL TRANSMISSION. FOUND THIS HAPPENED BY JUST DISENGAGING THE CLUTCH WITHOUT SHIFTING EVEN WITH FOOT NOT ON THE ACCELERATOR PEDAL. 2. THE REV SOARING HAPPENED CONSISTENTLY. NO CONSEQUENCES EXCEPT FOR AN UNP…
Read full complaint
EVENT 1: 1. SHORTLY AFTER BUYING CAR, NOTED ENGINE REVS WOULD SOAR BY 700 TO 800 RPMS BETWEEN GEARS WHILE SHIFTING MANUAL TRANSMISSION. FOUND THIS HAPPENED BY JUST DISENGAGING THE CLUTCH WITHOUT SHIFTING EVEN WITH FOOT NOT ON THE ACCELERATOR PEDAL. 2. THE REV SOARING HAPPENED CONSISTENTLY. NO CONSEQUENCES EXCEPT FOR AN UNPLEASANT DRIVING EXPERIENCE. 3. COMPUTER WAS REPROGRAMMED BY THE DEALER FROM WHOM I BOUGHT THE CAR. REV JUMPS REDUCED TO ABOUT 400 RPM. A SECOND REPROGRAMMING REDUCED IT TO ABOUT 200 RPM. THIS BEHAVIOR STILL EXISTS. EVENT #2. 1. ABOUT SIX MONTHS AFTER PURCHASING THE CAR, NOTED THAT WHEN CRUISING WITH RPMS ABOVE 2800 RPM IN 5TH GEAR WITH CRUISE CONTROL ENGAGED AND FOOT NOT ON ACCELERATOR PEDAL, ON DISENGAGING THE CLUTCH, THE ENGINE REVS WOULD SOAR TO 3,200 RPM TO 3,500 RPMAND REMAIN THERE FOR PERIODS RANGING BETWEEN 5 SECONDS TO OVER A MINUTE. THIS OCCURRED WHILE THE CAR WAS COASTING AND SLOWING WHILE NOT UNDER POWER. 2. THIS BEHAVIOR FREQUENTLY OCCURRED UNDER THE ABOVE CONDITIONS. NO CONSEQUENCES EXCEPT AS A PROFESSION ENGINEER AND FORMER SPORTS CAR RACING DRIVER, I KNEW THIS BEHAVIOR WAS NOT NORMAL. 3. BEHAVIOR EXAMINED BY MY LOCAL TOYOTA DEALER. MECHANIC HOOKED UP RECORDING BOX TO CAR, BUT I WAS UNABLE TO REPLICATE THE BEHAVIOR ON THIS OCCASION. DATA EXAMINED BY A TOYOTA ENGINEER WHO PRONOUNCED THERE WAS NOT A PROBLEM. LATER, I WAS AGAIN ABLE TO REPLICATE THE BEHAVIOR. AFTER YET ANOTHER COMPUTER REPROGRAMMING, THIS BEHAVIOR OF REMAINING AT A HIGH RPM SEEMS TO HAVE STOPPED. HOWEVER, THE ENGINE REVS STILL WILL SURGE TO ABOUT 3,400 RPM BEFORE DROPPING OFF. *TR
NHTSA ODI #10303576
Electrical SystemPower Train
ENGINE CONTROL MODULE AND AUTO TRANSMISSION FAILURE. BOUGHT RAV USED JULY 2007 WITH 109,230 MI. CHECK ENGINE LIGHT WAS ON (HAS REMAINED ON) BUT WAS DIAGNOSED AS O2 SENSOR & RAV OPERATED PERFECTLY (LIVE WHERE EMISSIONS CHECK NOT REQUIRED). MAY 2009 TRANNY STARTED ALTERNATING BETWEEN WORKING GOOD, SHIFTING ROUGH, SLIPPING BETWEEN …
Read full complaint
ENGINE CONTROL MODULE AND AUTO TRANSMISSION FAILURE. BOUGHT RAV USED JULY 2007 WITH 109,230 MI. CHECK ENGINE LIGHT WAS ON (HAS REMAINED ON) BUT WAS DIAGNOSED AS O2 SENSOR & RAV OPERATED PERFECTLY (LIVE WHERE EMISSIONS CHECK NOT REQUIRED). MAY 2009 TRANNY STARTED ALTERNATING BETWEEN WORKING GOOD, SHIFTING ROUGH, SLIPPING BETWEEN GEARS, AND NOT DOWNSHIFTING AT SLOW DOWN OR STOP. HAD MECHANIC WITH OVER 15 YRS EXPERIENCE AT TOYOTA DEALERSHIP CHECK IT (AFTER HOURS). HE WAS UNAWARE OF CONNECTION TO FAULTY ECM SO WE THOUGHT TRANY WAS BAD & HE FLUSHED TRANNY. THAT REDUCED FREQUENCY OF SYMPTOMS BUT DID NOT STOP THEM. WE STILL THOUGHT PROBLEM WAS MECHANICAL & TRANNY REBUILD/REPLACE WAS INEVITABLE & I DROVE IT LONGER TO SAVE UP MONEY FOR REPAIRS. I LIVE ON A SEMI-RURAL OHIO STATE ROUTE WITH 55MPH POSTED LIMIT & 65MPH AVERAGE SPEED. I HAD NUMEROUS NEAR MISSES WHEN THE VEHICLE WOULD NOT ACCELERATE PROPERLY OR BEGAN TO ACCELERATE NORMALLY THEN SLIPPED, HESITATED, OR REFUSED TO SHIFT. MY 18YR OLD SON DROVE THE RAV IN DEC & PULLED OUT OF OUR DRIVEWAY IN FRONT OF A SEMI TRACTOR TRAILER RIG WITH WHAT WOULD HAVE BEEN SAFE DISTANCE EXCEPT THAT THE RAV DECIDED NOT TO ACCELERATE. THE TRUCK WAS ABLE TO PASS, BUT HAD THERE BEEN ONCOMING TRAFFIC, IT WOULD NOT HAVE BEEN ABLE TO SLOW ENOUGH IN TIME. INTERMITTENT SYMPTOMS CONTINUED UNTIL 12/14/09 WHEN 2ND & 3RD GEAR BURNED OUT & I DROVE HOME 20 MILES IN 1ST. JUST PARTS THRU TOYOTA WILL COST $2000 FOR REBUILT TRANNY PLUS $1000 FOR ECM. INDEPENDENT REPAIRMEN CAN FIX THE ECM FOR $65. HAD I AT LEAST KNOWN ROOT CAUSE OF THE SYMPTOMS WAS ECM NOT TRANNY (TOYOTA'S KNOWN SINCE 2006 OR BEFORE) I COULD HAVE SAVED $4-5K & AVOIDED 7 MONTHS OF RISKY DRIVING. I CHALLENGE ANYONE WHO THINKS THIS IS NOT A SAFETY ISSUE TO DRIVE ONE OF THESE AND RELY ON IT WHEN IT FAILS IN 65MPH TRAFFIC. OR WE CAN WAIT UNTIL SOMEONE IS KILLED WHERE THERE IS ENOUGH EVIDENCE TO SHOW THIS PROBLEM WAS THE CAUSE OF THE ACCIDENT AND NOT POOR DRIVER JUDGMENT. *TR
NHTSA ODI #10303397
Electrical SystemPower Train
I BOUGHT MY 2001 TOYOTA RAV 4 IN 2004. IN JULY 2009, MY TRANSMISSION STARTED SLIPPING AND BUCKING. I HAVE DONE SOME RESEARCH AND IT SEEMS THAT THIS HAS BEEN AN ISSUE FOR MANY OTHERS WITH A 2001-2003 RAV4. IT IS TERRIFYING TO DRIVE THIS VEHICLE BUT IT'S ALL I HAVE. IT WOULD COST ME MORE TO REPLACE THE TRANSMISSION THAN IT WOULD T…
Read full complaint
I BOUGHT MY 2001 TOYOTA RAV 4 IN 2004. IN JULY 2009, MY TRANSMISSION STARTED SLIPPING AND BUCKING. I HAVE DONE SOME RESEARCH AND IT SEEMS THAT THIS HAS BEEN AN ISSUE FOR MANY OTHERS WITH A 2001-2003 RAV4. IT IS TERRIFYING TO DRIVE THIS VEHICLE BUT IT'S ALL I HAVE. IT WOULD COST ME MORE TO REPLACE THE TRANSMISSION THAN IT WOULD TO JUST PAY IT OFF. I AM CONCERNED THAT I WILL HAVE AN ACCIDENT, AS I DO A LOT OF COMMUTING. I AM SO DISAPPOINTED THAT I HAVE INVESTED SO MUCH MONEY IN THE MAINTENANCE OF THIS UNRELIABLE VEHICLE. I HEARD ABOUT TOYOTA'S RECALL ON THE NEWS YESTERDAY AND I AM DISGUSTED THAT TOYOTA HAS NOT ADDRESSED THIS ISSUE. THIS SHOULD BE AS PERTINENT AS A FAULTY ACCELERATOR. I BOUGHT MY TOYOTA BECAUSE I HAD HEARD THAT THEY HAD A REPUTATION FOR SAFE, WELL-MADE VEHICLES. MY LIFE IS PUT ON THE LINE EVERYTIME I HAVE TO DRIVE THAT CONTRAPTION, AND I EXPECT THAT IF NOTHING IS DONE ABOUT THIS ISSUE TO ENSURE A COMPENSATION OR EXTENDED WARRANTY OF SOME KIND, TOYOTA WILL LOSE MY BUSINESS( AMONG MANY, MANY OTHERS, I'M SURE.). MORE IMPORTANTLY, EVERYTIME ANYONE WHO IS HAVING THIS ISSUE WITH A TOYOTA RAV 4 GETS IN THE CAR, THEY ARE INCREASING THE RISK OF INJURY OR DEATH CAUSED BY AN ACCIDENT FROM THIS CHEAP, FAULTY, UNRELIABLE TRANSMISSION. PLEASE CONSIDER THIS ISSUE WHEN REVIEWING TOYOTA'S LACK OF CONCERN FOR THEIR DRIVER'S SAFETY. I AM SURE THAT SOME BIGWIG IS SITTING IN AN OFFICE SOMEWHERE, PROFITING FROM THE MONEY THAT TOYOTA SAVED BY USING DEFECTIVE PARTS. *TR
NHTSA ODI #10303145
Related Official recalls
3Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Oct 19, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
5DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.