1,371 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
Reports by model year
Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
689 reports with mileage · 682 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
1,371 reportsElectrical System
WITH NO WARNING, THE THREE LIGHTS CAME ON: 4WD, VSC, ENGINE. NOW THE DEALER TELLS ME THAT COIL #5 FAILED AND NEEDS TO BE REPLACED FOR A STAGGERING $350 PARTS AND LABOR. AMAZING, BECAUSE THE PART COSTS ONLY $40, WHAT IS THERE WORTH LABOR FOR $310? I RESEARCHED THIS ISSUE AND IT TURNS OUT THAT THIS IS A VERY COMMON ISSUE WITH THES…
Read full complaint
WITH NO WARNING, THE THREE LIGHTS CAME ON: 4WD, VSC, ENGINE. NOW THE DEALER TELLS ME THAT COIL #5 FAILED AND NEEDS TO BE REPLACED FOR A STAGGERING $350 PARTS AND LABOR. AMAZING, BECAUSE THE PART COSTS ONLY $40, WHAT IS THERE WORTH LABOR FOR $310? I RESEARCHED THIS ISSUE AND IT TURNS OUT THAT THIS IS A VERY COMMON ISSUE WITH THESE TOYOTA RAV4 CARS. I FIXED IT AND TWO WEEKS LATER, COIL #4 FAILED, THIS ONE FOR ANOTHER $350! WHAT IS GOING ON WITH THIS CAR. IT IS A BIG PROBLEM WITH COILS FAILING.
NHTSA ODI #10485586
Electrical SystemVisibility
ON 10/13/2012 WE PURCHASED THIS VEHICLE. WE HEADED SOUTH ON A BUSY FREEWAY AND HAD THE DRIVER'S SIDE WINDOW DOWN AS WE PROCEEDED UP THE ENTRANCE RAMP GAINING SPEED TO SAFELY MOVE ON THE FREEWAY WE ATTEMPTED TO CLOSE THE POWER WINDOW BY PULLING UP ON THE DESIGNATED SWITCH AND EXPERIENCED THIS WINDOW AS SOON AS IT CLOSED WOULD INS…
Read full complaint
ON 10/13/2012 WE PURCHASED THIS VEHICLE. WE HEADED SOUTH ON A BUSY FREEWAY AND HAD THE DRIVER'S SIDE WINDOW DOWN AS WE PROCEEDED UP THE ENTRANCE RAMP GAINING SPEED TO SAFELY MOVE ON THE FREEWAY WE ATTEMPTED TO CLOSE THE POWER WINDOW BY PULLING UP ON THE DESIGNATED SWITCH AND EXPERIENCED THIS WINDOW AS SOON AS IT CLOSED WOULD INSTANTLY GO BACK DOWN. REPEATED ATTEMPTS SAME OUTCOME. CARS WERE ON ALL SIDES, THE GUST OF RAIN HITTING MY FACE MADE IT HARD TO SEE WHILE MY ATTENTION WAS FOCUSED ON GETTING THIS WINDOW TO STAY CLOSED AND AT THE SAME TIME AVOID COLLISIONS DUE TO THE DISTRACTION OF A WINDOW THAT WOULD NOT STAY SHUT. *TR
NHTSA ODI #10484982
Electrical SystemPower Train
I WAS DRIVING MY 2002 TOYOTA RAV4 DOWN THE INTERSTATE WHEN THE CHECK ENGINE LIGHT CAME ON AT THE SAME TIME THAT THE RPM'S OF THE VEHICLE BEGAN ESCALATING FAR BEYOND WHERE THEY NORMALLY WOULD. AFTER TESTING THE VEHICLE AT DIFFERENT SPEEDS, I DETERMINED THAT THE CAR WOULD NOT SHIFT FROM FOURTH TO FIFTH GEAR. TOOK IT TO MY LOCAL …
Read full complaint
I WAS DRIVING MY 2002 TOYOTA RAV4 DOWN THE INTERSTATE WHEN THE CHECK ENGINE LIGHT CAME ON AT THE SAME TIME THAT THE RPM'S OF THE VEHICLE BEGAN ESCALATING FAR BEYOND WHERE THEY NORMALLY WOULD. AFTER TESTING THE VEHICLE AT DIFFERENT SPEEDS, I DETERMINED THAT THE CAR WOULD NOT SHIFT FROM FOURTH TO FIFTH GEAR. TOOK IT TO MY LOCAL MECHANIC, WHO DETERMINED THAT THERE IS NOTHING WRONG WITH MY TRANSMISSION. WHAT'S WRONG IS THAT THE ELECTRONIC CONTROL MODULE (ECM) THAT CONTROLS THE TRANSMISSION HAD FAILED. HE CONTACTED A LOCAL TOYOTA DEALER TO SEE IF HE COULD SOURCE THE PART AND DISCOVERED THAT IT WAS A KNOWN FAILURE AND WE NEEDED TO TAKE THE CAR TO THE DEALERSHIP. WE DID SO, WHERE WE WERE TOLD BECAUSE WE PURCHASED THE CAR NEW IN MAY OF 2002 (TEN YEARS, FIVE MONTHS AGO) THAT THEY WERE REFUSING TO REPAIR THE CAR'S ECM AS IT FELL OUTSIDE OF THEIR 'ADJUSTED' WARRANTY PERIOD. I CONTACTED TOYOTA'S CORPORATE CUSTOMER ASSISTANCE, WHERE I WAS TOLD THAT YES, TOYOTA KNOWS THAT THE PART IS GOING TO FAIL. THEY EXTENDED THE WARRANTY TO COVER MORE OF THE CARS THAT WOULD BE AFFECTED. HOWEVER, SINCE I PURCHASED MY CAR FIVE MONTHS LONGER THAN THEIR ARBITRARY TEN YEAR COVERAGE PERIOD REGARDLESS OF THE FACT THAT THE MILEAGE OF THE CAR FALLS FAR BELOW THE LISTED COVERAGE THAT THEY ARE NOT GOING TO DO ANYTHING TO REPAIR MY VEHICLE. NOT ONLY THAT, BUT THE DEALERSHIP QUOTED $1400 FOR THE ECM REPAIR AND ANOTHER $4800 FOR THE TRANSMISSION - SAYING THAT THE TRANSMISSION HAD TO BE REPLACED, EVEN THOUGH THEY HADN'T INSPECTED IT (I ASKED!!) AND I HAD ALREADY HAD AN INDEPENDENT MECHANIC CHECK IT OUT AND SAID THAT IT WAS FINE. I DO NOT UNDERSTAND HOW IT IS OKAY FOR TOYOTA TO SELL MILLIONS OF PEOPLE CARS WITH KNOWN SAFETY DEFECTS AND SAY THAT THEY ARE NOT RESPONSIBLE FOR THE REPAIR - KNOWING THAT IF THE REPAIR ISN'T MADE, THAT PEOPLE WILL BE KILLED DRIVING THESE CARS. *TR
NHTSA ODI #10482331
Electrical System
THE CLIPS SECURING THE ELECTRICAL CONSOLE ON THE DRIVER'S DOOR GAVE WAY AND FELL INTO THE DOOR, FOR NO APPARENT REASON. NOW THE CONSOLE IS LOOSE AND KEEPS RIDING UP FROM IT'S POSITION. I'M CONCERNED THIS IS GOING TO CAUSE AN ELECTRICAL SHORTAGE OR WILL GET WET WHEN DOOR OR WINDOW IS OPENED DURING RAIN, SNOW ETC. I HAD SOMEONE L…
Read full complaint
THE CLIPS SECURING THE ELECTRICAL CONSOLE ON THE DRIVER'S DOOR GAVE WAY AND FELL INTO THE DOOR, FOR NO APPARENT REASON. NOW THE CONSOLE IS LOOSE AND KEEPS RIDING UP FROM IT'S POSITION. I'M CONCERNED THIS IS GOING TO CAUSE AN ELECTRICAL SHORTAGE OR WILL GET WET WHEN DOOR OR WINDOW IS OPENED DURING RAIN, SNOW ETC. I HAD SOMEONE LOOK AT IT AT A NEARBY TOYOTA DEALER AND WAS TOLD THE WHOLE ELECTRICAL CONSOLE ON THE DRIVER'S DOOR NEEDS TO BE REPLACED BECAUSE IT'S ONE UNIT....NO WAY TO JUST REPLACE THE CLIPS. THE COST OF THE PART ALONE WAS QUOTED AS $514.00, WITH LABOR EXTRA. IF THIS WAS CAUSED BY NEGLIGENCE ON MY PART I WOULDN'T MIND, HOWEVER I DID NOTHING TO IT. I JUST HEARD A NOISE AND SOMETHING FELL INTO THE DOOR, THEN SAW WHAT HAD HAPPENED. I FEEL THIS SHOULD BE A RECALL SO TOYOTA ABSORBS THE COST, NOT ME. THE VEHICLE HAD LESS THAN 98,000 MILES ON IT WHEN IT HAPPENED AND IT HAS BEEN WELL CARED FOR. PLEASE LET ME KNOW WHAT, IF ANYTHING, CAN BE DONE FOR ME. THANK YOU FOR YOUR TIME AND CONSIDERATION. *TR
NHTSA ODI #10479980
Electrical SystemEnginePower Train
OCTOBER 11, 2012. ON OR ABOUT OCTOBER 8 2012 I BEGAN HAVING HESITATION AND JUMPING INTO GEAR AS I AM DRIVING MY 2001 RAV4. THIS HAPPENS MAINLY WHEN ACCELERATING FROM A STOP SIGN/LIGHT. I AM AWARE THERE HAS BEEN A RECALL ON MANY 2001 RAV4 VEHICLES. I BOUGHT MY RAV4 FROM CARMAX IN NORTH ATTLEBORO MASS ON APRIL 19 2012. SO, I HAV…
Read full complaint
OCTOBER 11, 2012. ON OR ABOUT OCTOBER 8 2012 I BEGAN HAVING HESITATION AND JUMPING INTO GEAR AS I AM DRIVING MY 2001 RAV4. THIS HAPPENS MAINLY WHEN ACCELERATING FROM A STOP SIGN/LIGHT. I AM AWARE THERE HAS BEEN A RECALL ON MANY 2001 RAV4 VEHICLES. I BOUGHT MY RAV4 FROM CARMAX IN NORTH ATTLEBORO MASS ON APRIL 19 2012. SO, I HAVE NOT EVEN HAD MY VEHICLE FOR 5 MONTHS YET. ON THURSDAY OCTOBER 11 2012 I TOOK MY RAV4 BACK TO CARMAX IN ATTLEBORO WITH MY COMPLAINT--I WILL BE LEAVING THE VEHICLE WITH THEM ON FRIDAY OCTOBER 12 2012 SO THEY CAN DIAGNOSE THE TRANSMISSION AND THE TCM (THE TRANSMISSION MODULE WHICH HAS HAD THE RECALL). IF IT IS FOUND THAT MY RAV4 IS ONE OF MANY UNDER THIS RECALL, I WILL HOPE THAT TOYOTA WILL HONOR ITS' COMMITMENT AND FIX MY RAV. I DO HOPE THAT LODGING THIS COMPLAINT WITH YOU WILL HELP ME IN THIS PLIGHT, AS I DO NOT HAVE THE MONEY TO FIX THIS PROBLEM AND NOR SHOULD I HAVE TO AS TO THE ABOVE, AND DUE TO THE FACT THAT IS WAS A RECALL WITH TOYOTA. THANK YOU. *TR
NHTSA ODI #10479841
Air BagsElectrical SystemStructure
I WAS DRIVING DOWN FOREST AVE IN BROCKTON, MA, THE DRIVER SIDE DOOR STATED SMOKING, I QUICKLY TURNED THE ENGINE OFF, GOT ME AND MY SON OUT OF THE CAR AND CALLED THE FIRE DEPARTMENT WHO DISCONNECTED THE BATTERY AND SUGGESTED THAT I GOT IT TOWED TO A REPAIR SHOP. SO I DID, TO COPLAND TOYOYTA WHERE IT WAS TROUBLESHOOT TO A MASTER S…
Read full complaint
I WAS DRIVING DOWN FOREST AVE IN BROCKTON, MA, THE DRIVER SIDE DOOR STATED SMOKING, I QUICKLY TURNED THE ENGINE OFF, GOT ME AND MY SON OUT OF THE CAR AND CALLED THE FIRE DEPARTMENT WHO DISCONNECTED THE BATTERY AND SUGGESTED THAT I GOT IT TOWED TO A REPAIR SHOP. SO I DID, TO COPLAND TOYOYTA WHERE IT WAS TROUBLESHOOT TO A MASTER SWITCH ASS. IT WAS REPAIRED AND I HAD TO PAY $580.70 BECAUSE THEY SAID ITS NOT COVERED BY WARRANTY. *TR
NHTSA ODI #10478657
Electrical SystemSteering
I WAS MAKING A SLOW SPEED TURN WHEN, WITHOUT WARNING, IT BECAME VERY DIFFICULT TO STEER, AS IF THE POWER STEERING QUIT WORKING. AS I ACCELERATED THE STEERING STARTED WORKING AGAIN. A FEW DAYS LATER IT HAPPENED AGAIN AND THIS TIME THE BATTERY WARNING LIGHT CAME ON. BOTH TIMES THIS HAPPENED IT ALMOST CAUSED A COLLISION. I ENDED UP…
Read full complaint
I WAS MAKING A SLOW SPEED TURN WHEN, WITHOUT WARNING, IT BECAME VERY DIFFICULT TO STEER, AS IF THE POWER STEERING QUIT WORKING. AS I ACCELERATED THE STEERING STARTED WORKING AGAIN. A FEW DAYS LATER IT HAPPENED AGAIN AND THIS TIME THE BATTERY WARNING LIGHT CAME ON. BOTH TIMES THIS HAPPENED IT ALMOST CAUSED A COLLISION. I ENDED UP TAKING IT TO THE DEALER AND LEARNED THE ALTERNATOR WAS GOING BAD. AN ALTERNATOR ON A FOUR YEAR OLD VEHICLE WITH 60K MILES SHOULD LAST LONGER. I'VE SINCE LEARNED, FROM SAFETY SITES, THAT THIS IS A COMMON SAFETY ISSUE WITH THE RAV AS THE STEERING IS ELECTRICALLY POWERED. THERE IS ALSO SOME INDICATION THE ALTERNATORS ARE FAILING TOO SOON. *TR
NHTSA ODI #10478526
Electrical SystemService BrakesVehicle Speed Control
TRAVELING APPROXIMATELY 45 MPH ON DRY PAVEMENT. WENT TO APPLY BRAKES PRIOR TO APPROACHING TURN LANE AND COULD NOT STOP. BRAKES WERE THERE (PEDAL WAS FIRM AND DID NOT GO TO FLOOR) BUT ACCELERATOR SEEM TO OVERRIDE THE BRAKING SYSTEM. PROCEEDED TO STAND ON BRAKES TO ATTEMPT TO STOP AS THERE WERE THREE LANES OF STOPPED TRAFFIC AN…
Read full complaint
TRAVELING APPROXIMATELY 45 MPH ON DRY PAVEMENT. WENT TO APPLY BRAKES PRIOR TO APPROACHING TURN LANE AND COULD NOT STOP. BRAKES WERE THERE (PEDAL WAS FIRM AND DID NOT GO TO FLOOR) BUT ACCELERATOR SEEM TO OVERRIDE THE BRAKING SYSTEM. PROCEEDED TO STAND ON BRAKES TO ATTEMPT TO STOP AS THERE WERE THREE LANES OF STOPPED TRAFFIC AND NO WHERE ELSE TO GO. SHIFTED CAR INTO PARK TO COME TO AN ABRUPT STOP TO AVOID HITTING 8+ CARS AND PUSHING THEM INTO A VERY LARGE INTERSECTION. CAR HAD APPROXIMATELY 46000 MILES ON IT AND HAD NEW BRAKES INSTALLED 8 MONTHS PRIOR. CAR HAD BEEN SERVICED 1 MONTH PRIOR FOR GENERAL SERVICE POINT CHECKS. TOOK CAR TO DEALERSHIP SAME DAY OF THIS INCIDENT - THEY COULD NOT FIND NOTHING WRONG WITH THE CAR. OFFERED TO SERVICE BASED ON A PREVIOUS RECALL TO REMOVE THE CURRENT FLOORMAT AND ADJUST ACCELERATOR. ONE MONTH PRIOR TO THIS INCIDENT THE RADIO STOPPED WORKING FOR A COUPLE OF DAYS THEN STARTED WORKING INTERMITTENTLY SOMETIMES DISPLAYING GARBLED TEXT ON THE RADIO DISPLAY. *TR
NHTSA ODI #10477102
Electrical SystemFire
MY WIFE LEFT HOME TO DRIVE TO THE STORE - A 3-MILE TRIP, ALL IN-TOWN DRIVING. AFTER TRAVELING ABOUT 1/2 MILE, SMOKE STARTED COMING INTO THE CAR FROM BEHIND THE PANEL ON THE INSIDE OF THE DRIVER'S DOOR. SHE STOPPED THE CAR. THE VOLUME OF SMOKE ACCUMULATING IN THE CAR INCREASED. A PASSER-BY STOPPED, CALLED 911, REPORTED THE FIR…
Read full complaint
MY WIFE LEFT HOME TO DRIVE TO THE STORE - A 3-MILE TRIP, ALL IN-TOWN DRIVING. AFTER TRAVELING ABOUT 1/2 MILE, SMOKE STARTED COMING INTO THE CAR FROM BEHIND THE PANEL ON THE INSIDE OF THE DRIVER'S DOOR. SHE STOPPED THE CAR. THE VOLUME OF SMOKE ACCUMULATING IN THE CAR INCREASED. A PASSER-BY STOPPED, CALLED 911, REPORTED THE FIRE, AND ASSISTED MY WIFE, WHO CLIMBED INTO THE FRONT PASSENGER SEAT AND EXITED THE CAR OUT THE FRONT, RIGHT PASSENGER DOOR. BY THE TIME THE FIREMEN AND POLICE ARRIVED, APPROXIMATELY 3-5 MINUTES LATER, SMOKE WAS DENSE AND FLAMES WERE SURROUNDING THE EDGES OF THE DOOR PANEL. FIREMEN SPRAYED WATER ON THE PANEL, PULLED THE PANEL OFF THE DOOR, AND CONTINUED TO APPLY WATER UNTIL THE FIRE WAS EXTINGUISHED. THANKFULLY, MY WIFE WAS ABLE TO STOP AND EXIT THE CAR QUICKLY. HAD SHE BEEN IN HEAVY, FAST-MOVING TRAFFIC, IT COULD HAVE BEEN A LIFE-THREATENING SITUATION. ALSO, THE NON-AVAILABILITY OF FIREMEN WOULD HAVE RESULTED IN MUCH MORE FIRE- DAMAGE TO THE CAR AND POSSIBLY AN EXPLOSION. *TR
NHTSA ODI #10476921
Electrical System
I WAS DRIVING THE RAV4 IN APRIL 2011 AND AGAIN ON SEPTEMBER 14, 2012 WHEN THE SAME INCIDENT OCCURRED.THE FIRST TIME THERE WAS NO WARNING, THE BATTERY LIGHT DID NOT COME ON, FIRST THE RADIO QUIT PLAYING AND THEN THE CAR WENT DEAD AS I WAS MOVING IN TRAFFIC. NEEDLESS TO SAY IT WAS VERY STRESSFUL BEING STRUCK IN TRAFFIC. THANKS TO…
Read full complaint
I WAS DRIVING THE RAV4 IN APRIL 2011 AND AGAIN ON SEPTEMBER 14, 2012 WHEN THE SAME INCIDENT OCCURRED.THE FIRST TIME THERE WAS NO WARNING, THE BATTERY LIGHT DID NOT COME ON, FIRST THE RADIO QUIT PLAYING AND THEN THE CAR WENT DEAD AS I WAS MOVING IN TRAFFIC. NEEDLESS TO SAY IT WAS VERY STRESSFUL BEING STRUCK IN TRAFFIC. THANKS TO SOME KIND LADIES, THE CAR WAS PUSHED OUT OF THE WAY. WE SUSPECTED IT WAS A BATTERY MALFUNCTION, ALTHOUGH THE BATTERY WAS ONLY 8 MONTHS OLD. WE TOOK THE BATTERY TO PLACE OF PURCHASE AND THEY TRIED TO CHARGE IT, IT WOULD NOT CHARGE SO THEY REPLACED THE BATTERY FOR FREE BECAUSE IT WAS STILL UNDER WARRANTY. ON FRIDAY, SEPTEMBER 14 I WAS DRIVING IN HEAVY TRAFFIC AND THIS TIME THE BATTERY LIGHT CAME ON FOR A FEW MINUTES, THEN THE RADIO WENT OUT AND THE CAR DIED. THIS WAS EXTREMELY STRESSFUL AS TRAFFIC WAS SPEEDING BEHIND ME AND I WAS AFRAID I WOULD GET REAR ENDED. ONCE AGAIN THERE WERE TWO FEMALES THAT HELPED ME PUSH THE CAR OUT OF TRAFFIC. ONCE AGAIN THE BATTERY WAS REPLACED AS IT WAS STILL UNDER WARRANTY, HOWEVER THIS TIME THE BATTERY LIGHT WILL NOT GO OUT. AFTER DOING SOME INVESTIGATING, I BELIEVE THE PROBLEM STEMS FROM THE RAV 4 'S ELECTRICAL STEERING AND THE FACT THAT IT PULLS TO MUCH POWER. THERE IS NOT REASON WHY THE CAR SHOULD JUST QUIT WHILE YOUR DRIVING IN TRAFFIC. IT IS HARD TO TRUST THE VEHICLE WHEN IT SUDDENLY STOPS IN TRAFFIC AND WILL NOT START AGAIN. *TR
NHTSA ODI #10475522
Related Official recalls
3Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Oct 19, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
5DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.