1,371 distinct owner reports with an electrical-system component in this snapshot.
Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.
Reports by model year
Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.
When problems were reported
Mileage at the reported incident
689 reports with mileage · 682 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What owners actually said
1,371 reportsElectrical System
ON 08/09/14 WE WERE DRIVING IN PARKING LOT WITH 5 PEOPLE IN CAR. STARTED DRIVING AND ENGINE SUDDENLY STOPPED. CAR GLIDED TO A STOP WITH GEARS AND STEERING WHEEL LOCKED. CAR WOULD NOT RESTART. CALLED AAA FOR A TOW 20+ MILES AWAY TO CLOSEST TOYOTA DEALERSHIP AND THEN GOT TRANSPORT FOR OURSELVES TO HOTEL FOR THE NIGHT. NEXT MORNING…
Read full complaint
ON 08/09/14 WE WERE DRIVING IN PARKING LOT WITH 5 PEOPLE IN CAR. STARTED DRIVING AND ENGINE SUDDENLY STOPPED. CAR GLIDED TO A STOP WITH GEARS AND STEERING WHEEL LOCKED. CAR WOULD NOT RESTART. CALLED AAA FOR A TOW 20+ MILES AWAY TO CLOSEST TOYOTA DEALERSHIP AND THEN GOT TRANSPORT FOR OURSELVES TO HOTEL FOR THE NIGHT. NEXT MORNING GOT RENTAL CAR TO DRIVE TO TOYOTA DEALER WHERE CAR HAD BEEN TOWED TO. REPAIR WAS SIMPLY A BLOWN FUSE FOR VEHICLE REMOTE STARTER WHICH WAS ODDLY LOCATED UNDER STEERING WHEEL. SIMILAR INCIDENT HAPPENED (03/12/08) WHILE DIVING IN CANADA AND REPAIRED THEN AT A TOYOTA DEALER AT 12,101 KM. THE REMOTE STARTER WAS PART OF ORIGINAL EQUIPMENT ON THE NEW CAR. NOW, WE FEAR DRIVING RAV4 ON HIGHWAY AT ANY SPEED FOR FEAR CAR WILL SUDDENLY STOP AND STEERING WILL LOCK UP. REMOTE STARTER NEEDS TO BE REMOVED OR FIXED AT IT IS NOT SAFE. *TR
NHTSA ODI #10625986
Electrical SystemPower Train
ECM WAS REPLACED IN 2007. NO PROBLEMS AT THAT TIME. IN MAY 2014 BRAKES PLUS MISDIAGNOSED PROBLEM AND FIXED ALMOST EVERYTHING POSSIBLE. CHECK ENGINE LIGHT NEVER WENT ON UNTIL THE DAY BEFORE THE PROBLEM. TRANSMISSION STARTED ACTING UP AND WHEN I WENT TO PASS A PERSON ON A BICYCLE SLIPPED INTO NEUTRAL. THEN IT JUMPED BACK AND FORTH…
Read full complaint
ECM WAS REPLACED IN 2007. NO PROBLEMS AT THAT TIME. IN MAY 2014 BRAKES PLUS MISDIAGNOSED PROBLEM AND FIXED ALMOST EVERYTHING POSSIBLE. CHECK ENGINE LIGHT NEVER WENT ON UNTIL THE DAY BEFORE THE PROBLEM. TRANSMISSION STARTED ACTING UP AND WHEN I WENT TO PASS A PERSON ON A BICYCLE SLIPPED INTO NEUTRAL. THEN IT JUMPED BACK AND FORTH LIKE TRYING TO GO FROM ONE GEAR TO ANOTHER, WITH NOTHING HAPPENING. I COULD HAVE BEEN HIT BY A TRUCK AT THIS POINT, BUT AVOIDED. TOOK THE RAV BACK TO BRAKES PLUS. THEY SAID IT WAS THE TRANSMISSION. WOULD COST $4500-5000 REPAIR. THEY NEVER EVEN CHECKED THE DIAGNOSIS - WHICH WHEN WE TOOK TO AUTO ZONE (WHICH WILL READ THE PROBLEM AS ECM). THEN TOWED THE CAR TO THE DEALER. THEY SAID THE TRANSMISSION IS "SMOKE." CALLED THE TOYOTA REP AND ONLY GOT A CASE NUMBER. OF COURSE THE CAR IS 13 YEARS OLD AND WE HAVE HAD IT 12. IT IS AT 175,000 MILES. WE CAN'T PUT ANOTHER $4,500 IN THIS CAR. THE ECM SHOULD NOT HAVE GONE OUT AGAIN. THE CHECK ENGINE LIGHT SHOULD HAVE GONE ON IN MAY FROM WHAT WE ASSESS CONSIDERING THE PROBLEMS WE EXPERIENCED AT THAT TIME. I WOULD NOT ADVISE ANYONE TO PURCHASE A 2001-2003 RAV4. I AM NOT SURE I'D EVERY PURCHASE ANOTHER TOYOTA. IT LOOKS LIKE TOYOTA HAS STUCK US WITH A NEARLY $5000 REPAIR IF WE WANT A NEW TRANS. AND WE JUST PUT $2,700 INTO IT IN MAY. *TR
NHTSA ODI #10625812
Electrical SystemEngine
THIS INCIDENT OCCURRED ON A TUES NITE IN NOV2012 AT 930EST. I HAD BEEN PLAYING BRIDGE AT A CLUB HOUSE . I ATTEMPTED TO START CAR(THIS IS A KEYLESS IGNITION SYSTEM)BY NORMAL PROCEDURE. PRESS BRAKE, THEN PRESS START BUTTON.NOTHING HAPPENED!I WAITED A FEW SECONDS, TRIED AGAIN,NO JOY. I GOT OUT TO MAYBE HITCH A RIDE, BUT ALL OTHERS…
Read full complaint
THIS INCIDENT OCCURRED ON A TUES NITE IN NOV2012 AT 930EST. I HAD BEEN PLAYING BRIDGE AT A CLUB HOUSE . I ATTEMPTED TO START CAR(THIS IS A KEYLESS IGNITION SYSTEM)BY NORMAL PROCEDURE. PRESS BRAKE, THEN PRESS START BUTTON.NOTHING HAPPENED!I WAITED A FEW SECONDS, TRIED AGAIN,NO JOY. I GOT OUT TO MAYBE HITCH A RIDE, BUT ALL OTHERS HAD LEFT. I OPENED AND CLOSED ALL DOORS PLUS THETAILGATE. I GOT BACK IN AT THE CAR STARTED OK. ABOUT 5 MONTHS LATER AFTER ATTENDING A PIZZA PARTY AT WALMART PARKING LOT 3PM HOT DAY, THE PROBLEM RECURRED. I SLAMMED ALL DOORS AGAIN AND THE CAR STARTED.I DON'T KNOW IF SLAMMING DOORS IS ELECTRICALLY INVOLVED, MAYBE A TIME DELAY IS THE ANSWER.THE NEXT TIME WAS ON JULY 18 2013. IHAD BEEN PLAYING BRIDGE AT THE CLUBHOUSE AT 1PM, I FINISHED AT4PM (ANOTHER HOT DAY) THE CAR WOULD NOT START I NOTICED THEWINDOWS WOULD NOT WORK, IN FACTNOTHING ELECTRICAL WOULD WORK. ICALLED MY ROAD SERVICE AND THEY VERIFIED BAT WAS LOW, THEY CHARGED FOR JUST A FEW MINUTES AND CAR STARTED.I DROVE IMMEDIATELY TO THE LOCAL TOYOTA DEALER. THEY COULD NOT MAKE THE PROBLEM REAPPEAR.THEY KEPT THE CAR OVERNITE AND SUPPOSEDLY WENT OVERTHE CIRCUITS.BY THE WAY THE MILEAGE ON THE CAR WAS 3947 MILES AND CAR WAS 14 MONTHS OLD!THEY TOLD ME TO HAVE IT TOWED TO THEM THE NEXT TIME BUT THAT'S NO ALWAYS CONVENIENT. MY 2 YR WARRANTY EXPIRED IN MAY OF 2014 AND I HAVE HAD 2 ADDITIONAL OCCURRENCES ,ONE IN JUNE 2014 AND ONEIN JULY2014. IM AFRAID TO GO ON ANY TRPS OUT OF TOWN FOR FEAR IT WILL HAPPEN AGAIN. I WOULD LIKE FOR TOYOTA TO FURNISH ME A SCHEMATIC OFTHE CIRCUITRY INVOLVED OR PROVIDE A BYPASS SWITCH SO THAT THE RF CIRCUITRY CAN BE DISABLED AND THE CAR COULD BE STARTED LIKE A NORMAL CAR! BY THE WAY,THIS FAILURE HAS OCCURRED 6 TIMES,4 TIMES WHILE IN WARRANTY! *TR
NHTSA ODI #10617477
Electrical SystemLatches/locks/linkagesInjury
TL* THE CONTACT OWNS 2014 TOYOTA RAV4. THE CONTACT STATED THAT THE DEALER ADVISED THAT THE ON AND OFF BUTTON TO THE BLUETOOTH THAT WAS STANDARD WITH THE VEHICLE SHOULD SHUT ON AND OFF BY USING THE POWER BUTTON. THE CONTACT STATED THAT THE POWER BUTTON WAS DEFECTIVE AND WOULD NOT TURN THE BLUETOOTH OFF WHEN IT WAS ENGAGED. THE CO…
Read full complaint
TL* THE CONTACT OWNS 2014 TOYOTA RAV4. THE CONTACT STATED THAT THE DEALER ADVISED THAT THE ON AND OFF BUTTON TO THE BLUETOOTH THAT WAS STANDARD WITH THE VEHICLE SHOULD SHUT ON AND OFF BY USING THE POWER BUTTON. THE CONTACT STATED THAT THE POWER BUTTON WAS DEFECTIVE AND WOULD NOT TURN THE BLUETOOTH OFF WHEN IT WAS ENGAGED. THE CONTACT'S HEART ALSO BEGAN TO FUNCTION ABNORMALLY AND SHE BECAME EXTREMELY WEAK, NEARLY COLLAPSING AFTER EXITING THE VEHICLE DUE TO THE INABILITY TO TURN THE BLUETOOTH OFF AND ON IN ORDER TO PREVENT IT FROM INTERFERING WITH HER PACEMAKER. THE CONTACT ALSO STATED THAT SHE ADVISED THE DEALER PRIOR TO PURCHASING THE VEHICLE THAT SHE HAD A PACEMAKER. THE CONTACT WAS CONCERNED ABOUT THE SAFETY HAZARD OF DRIVING THE VEHICLE BECAUSE THE OWNER'S MANUAL INDICATED CAUTION IF THE OPERATOR OF THE VEHICLE HAD MEDICAL DEVICES SUCH AS PACEMAKERS. THE GENERAL MANAGER WAS NOTIFIED THAT THE CONTACT BECAME ILL AND STATED THAT SHE SHOULD HAVE BEEN CAREFUL. ADDITIONALLY, THE VEHICLE COULD NOT BE LOCKED OR UNLOCKED USING THE REMOTE KEY FOB. INSTEAD, THE VEHICLE WOULD EXHIBIT AN ABNORMAL SOUND AND THE LIGHTS ILLUMINATED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10610930
Electrical SystemEquipment Adaptive/mobility
TRYING TO USE THE 'HANDS FREE' FEATURE OF THE BLUETOOTH FEATURE IN THE RAV4 TOYOTA, I RAN INTO A CURB TRYING TO FIND A TELEPHONE NUMBER IN THE PHONE BOOK. I HAD TO PURCHASE A NEW TIRE FOR OVER $200. AND I JUST HAD THE CAR FOR APPROX 2 OR 3 DAYS. I CAN'T BELIEVE TOYOTA WOULD EVEN HAVE A BLUETOOTH FEATURE THAT REQUIRES YOU TO …
Read full complaint
TRYING TO USE THE 'HANDS FREE' FEATURE OF THE BLUETOOTH FEATURE IN THE RAV4 TOYOTA, I RAN INTO A CURB TRYING TO FIND A TELEPHONE NUMBER IN THE PHONE BOOK. I HAD TO PURCHASE A NEW TIRE FOR OVER $200. AND I JUST HAD THE CAR FOR APPROX 2 OR 3 DAYS. I CAN'T BELIEVE TOYOTA WOULD EVEN HAVE A BLUETOOTH FEATURE THAT REQUIRES YOU TO USE THE ROTARY TUNER TO FIND A TELEPHONE NUMBER. THE SALESPERSON TOLD ME TO GET A SMART PHONE AND IT MAY HELP, BUT IT DID NOT. THE BLUETOOTH IN MY RAV4 IS ALMOST USELESS! WHO WOULD DESIGN OR PUT INTO A CAR A FEATURE THAT WOULD ALMOST INSURE ACCIDENTS IF USED AS DESIGNED? I THOUGHT I WAS GETTING A BLUETOOTH THAT WOULD ALLOW VOICE COMMANDS. AS IT IS, I CAN ONLY USE VOICE COMMANDS USING MY PHONE AND ONLY TALK USING BLUETOOTH. -- SOME HANDS FREE FEATURE!!! MY 1999 CAMRY HAD A BETTER INTERFACE WITH MY FLIP PHONE THAN MY 2012 RAV4. I FEEL THE FEATURE WAS MIS-REPRESENTED. I HAVE SPENT THE LAST TWO YEARS TRYING TO GET MY SAMSUNG GALAXY S3 TO WORK WITH THE RAV4 BLUETOOTH. IT IS USELESS. I THINK TOYOTA SHOULD UPDATE THE SOFTWARE OR WHATEVER IS NEEDED IN MY RADIO TO GET THE HANDS-FREE FEATURE MORE USABLE. *TR
NHTSA ODI #10596877
Electrical SystemElectronic Stability Control (esc)
CAR STARTED ACTIN G UP ON MAY 4TH. DIDN'T WANT START RIGHT AWAY IT STATED AFTER 4 5 TIRES AFTER 3 DAYS OF THAT I TOOK THE CAR TO LOCAL DEALER THEY TOLD ME BATTERY WAS LOW AND THEY CHARGED IT. I BROUGHT THIS CAR BRAND NEW IT HAS ONLY 14 MILE AND I BROUGHT IN MARCH 31 2014. THIS PROBLEM STARTED AGAIN YESTERDAY ( 05/18/2014). *…
Read full complaint
CAR STARTED ACTIN G UP ON MAY 4TH. DIDN'T WANT START RIGHT AWAY IT STATED AFTER 4 5 TIRES AFTER 3 DAYS OF THAT I TOOK THE CAR TO LOCAL DEALER THEY TOLD ME BATTERY WAS LOW AND THEY CHARGED IT. I BROUGHT THIS CAR BRAND NEW IT HAS ONLY 14 MILE AND I BROUGHT IN MARCH 31 2014. THIS PROBLEM STARTED AGAIN YESTERDAY ( 05/18/2014). *JS
NHTSA ODI #10592352
Back Over PreventionElectrical System
WHEN VEHICLE IS STARTED AND PUT INTO REVERSE THE BACKUP CAMERA IS DIM AND UNVIEWABLE FOR 15 SEC. BACKING UP DURING THIS PERIOD IS OBVIOUSLY HAZARDOUS AND IT IS VERY ANNOYING TO HAVE TO WAIT UNTIL IT BECOMES VISIBLE. THIS IS RELATED TO THE WHOLE DISPLAY CONSOLE AS THE RADIO, NAV SYSTEM, AND BU CAMERA ALL COME ON AFTER 15 SEC. T…
Read full complaint
WHEN VEHICLE IS STARTED AND PUT INTO REVERSE THE BACKUP CAMERA IS DIM AND UNVIEWABLE FOR 15 SEC. BACKING UP DURING THIS PERIOD IS OBVIOUSLY HAZARDOUS AND IT IS VERY ANNOYING TO HAVE TO WAIT UNTIL IT BECOMES VISIBLE. THIS IS RELATED TO THE WHOLE DISPLAY CONSOLE AS THE RADIO, NAV SYSTEM, AND BU CAMERA ALL COME ON AFTER 15 SEC. THIS DOES NOT HAPPEN ON MY WIFE'S 2007 PRIUS ALTHOUGH OCCASIONALLY IT DOES NOT SWITCH TO THE BU CAMERA AT ALL. *TR
NHTSA ODI #10587235
Electrical SystemSteering
AT FIRST 3 WARNING LIGHTS WERE ON WHERE I WAS DRIVING AT SPEED AROUND 10MPH: CHECK, 4WD, TRAC OFF. THEN SUDDENLY I COULD NOT TURN THE STEERING WHEEL EASILY, AND I REALIZED I WAS LOOSING CONTROL OF THE VEHICLE. I MADE A DECISION TO MOVE OUT OF THE BUSY ROAD AND TURN INTO A SMALL STREET. THIS I DID, BUT ONLY WAS ABLE TO STOP …
Read full complaint
AT FIRST 3 WARNING LIGHTS WERE ON WHERE I WAS DRIVING AT SPEED AROUND 10MPH: CHECK, 4WD, TRAC OFF. THEN SUDDENLY I COULD NOT TURN THE STEERING WHEEL EASILY, AND I REALIZED I WAS LOOSING CONTROL OF THE VEHICLE. I MADE A DECISION TO MOVE OUT OF THE BUSY ROAD AND TURN INTO A SMALL STREET. THIS I DID, BUT ONLY WAS ABLE TO STOP THE CAR ON THE OTHER SIDE OF THE STREET. AS THERE WERE NO CAR DRIVING ON THE STREET, I DID NOT CRASH MY CAR. AFTER THE CAR WAS STOPPED, I NOTICED THAT AN ADDITIONAL WARNING WAS ON: ELECTRIC POWERING STEERING SYSTEM WARNING LIGHT. THE CAR WAS TOWED TO TOYOTA DEALERSHIP. *TR
NHTSA ODI #10586314
Electrical System
WHILE I WAS DRIVING, THE CAR'S ELECTRIC SYSTEM STARTED REBOOTING ITSELF A FEW TIMES, AND THE CAR EVENTUALLY STALLED ON A BUSY STREET! THE POWER WAS COMPLETELY SHUTDOWN AND I COULDN'T EVEN TURN THE FLASH LIGHT ON. I HAD TO HAVE POLICE OFFICER COME TO THE LOCATION WHERE THE CAR STOPPED TO PROTECT OTHER DRIVERS (UNTIL A TOWING TRAC…
Read full complaint
WHILE I WAS DRIVING, THE CAR'S ELECTRIC SYSTEM STARTED REBOOTING ITSELF A FEW TIMES, AND THE CAR EVENTUALLY STALLED ON A BUSY STREET! THE POWER WAS COMPLETELY SHUTDOWN AND I COULDN'T EVEN TURN THE FLASH LIGHT ON. I HAD TO HAVE POLICE OFFICER COME TO THE LOCATION WHERE THE CAR STOPPED TO PROTECT OTHER DRIVERS (UNTIL A TOWING TRACK ARRIVED). THIS INCIDENT APPENDED ON 4/24/12 ON EASTBOUND CARMEL VALLEY ROAD RIGHT BEFORE THE INTERSECTION WITH EL CAMINO REAL. I HAD A SIMILAR ISSUE WITH THE ELECTRIC SYSTEM TWO MONTHS PRIOR, AND HAD A TOYOTA DEALER LOOK AT THE ISSUE. HOWEVER, THEY COULDN'T IDENTIFY THE ROOT CAUSE AND SIMPLY UPDATED THE SYSTEM SOFTWARE. AS OF TODAY, 4/25/14, THE CAR IS STILL AT A TOYOTA DEALER AND BEING REPAIRED. *TR
NHTSA ODI #10584988
Electrical SystemStructure
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT THE IGNITION BUTTON FAILED TO SHUT THE ENGINE OFF. THE CONTACT ALSO MENTIONED THAT THE DOOR LOCKS FAILED TO FUNCTION. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT THE IGNITION BUTTON FAILED TO SHUT THE ENGINE OFF. THE CONTACT ALSO MENTIONED THAT THE DOOR LOCKS FAILED TO FUNCTION. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 60,342. UPDATED 6/10/14*CN
NHTSA ODI #10583445
Related Official recalls
3Sep 11, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.
Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Oct 19, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Related NHTSA investigations
5DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.