Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
700–25K
3725–50K
2750–75K
1875–100K
16100–150K
2150K+
170 reports with mileage · 133 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports41 fire reports21 injury reports
What owners actually said
303 reports
130,000 miles · Mar 21, 2024
Electrical System
The contact owns a 2015 Toyota Rav4. The contact stated that on several occasions while driving at various speeds, various unknown warning lights flashed and stalled. The vehicle was restarted but on several occasions, the vehicle would not start and required a jump start. Additionally, the contact stated that the vehicle was bu…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated that on several occasions while driving at various speeds, various unknown warning lights flashed and stalled. The vehicle was restarted but on several occasions, the vehicle would not start and required a jump start. Additionally, the contact stated that the vehicle was burning oil at a faster rate due to the oil being changed less than a month ago. The vehicle was taken to a dealer where it was diagnosed that the battery needed to be replaced and an oil change was needed. The vehicle was repaired but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.
NHTSA ODI #11578653
Mileage unknown · Mar 18, 2024
Power Train
Transmission shudder between approximately 25-40 mph. Toyota had a recall on some of the 2013-2015 RAV4 for this problem by the vin number. Car shakes and it has stopped running once at a red light
NHTSA ODI #11578167
Mileage unknown · Mar 6, 2024
Electrical System
I just called Toyota dealer at Grime City IA this morning to make an appointment for recall the battery hold-down clamp and the battery tray as I just knew yesterday. Unfortunately, the customer lady let me know they are unavailable to do that because they do not have enough parts for now. As I knew, the program just extended un…
Read full complaint
I just called Toyota dealer at Grime City IA this morning to make an appointment for recall the battery hold-down clamp and the battery tray as I just knew yesterday. Unfortunately, the customer lady let me know they are unavailable to do that because they do not have enough parts for now. As I knew, the program just extended until June 2024 then I asked her to put my case on the list, but she denied to do it too. So would you please give me your recommendation and email me back as a proof. After June 2024, if they continue to deny me as today, I will have proof to talk with them. Thank you very much and have a good day.
NHTSA ODI #11575819
Mileage unknown · Feb 26, 2024
Electrical SystemFire
My son was driving our RAV4 LE 2015 and took an exit. While driving, the car shut off, and the dashboard lights blinked. He turned the car on and moved about 40 feet in the exit when the car shut off again, and smoke came from the hood. A few minutes later, the car was on fire. The cause was a battery-induced short circuit. The …
Read full complaint
My son was driving our RAV4 LE 2015 and took an exit. While driving, the car shut off, and the dashboard lights blinked. He turned the car on and moved about 40 feet in the exit when the car shut off again, and smoke came from the hood. A few minutes later, the car was on fire. The cause was a battery-induced short circuit. The burned RAV4 LE 2015 is available for inspection. This incident put my son and a friend at serious risk. At this moment, the problem hasn't been confirmed by a dealer or independent service. However, months later, the manufacturer issued a recall on Nov 01, 2023. The vehicle has not been inspected by the manufacturer, police, or any other party. There were no warning lamps or messages, except for the first time it shut off when the dashboard lights blinked.
NHTSA ODI #11573992
Mileage unknown · Feb 4, 2024
Electrical SystemEngineFire
When I try to start up my car after a full month of parking as usual I knew already it has a dead battery so I jump started then once it started I heard a very small explosion with smoke coming from underneath the glove compartment then I found a very small fire started from the same place so I left the car and I called 911 who …
Read full complaint
When I try to start up my car after a full month of parking as usual I knew already it has a dead battery so I jump started then once it started I heard a very small explosion with smoke coming from underneath the glove compartment then I found a very small fire started from the same place so I left the car and I called 911 who came and extinguished the fire after the entire car was already engulfed and exploded in fire. The car closed the other two cars on both sides to melt partially as well. The picture attached has the incident number.
NHTSA ODI #11569829
112,000 miles · Jan 18, 2024
Power Train
The contact owns a 2015 Toyota Rav4. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle started to hesitate. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was repaired, but the dealer informed the contact that…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle started to hesitate. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was repaired, but the dealer informed the contact that if the failure reoccurred, the transmission would need to be replaced. The manufacturer was not notified of the failure. The failure mileage was 112,000.
NHTSA ODI #11566248
Mileage unknown · Jan 17, 2024
Fuel/propulsion SystemVehicle Speed Control
My friend was leaving church and cranked my vehicle engine. My friend proceeded to exit the church parking lot onto a main road. Prior to exiting the parking lot, she heard the engine "rev", where my vehicle began moving forward without her control. She was consistently pressing the brake pedal; to no avail. where my vehicle wa…
Read full complaint
My friend was leaving church and cranked my vehicle engine. My friend proceeded to exit the church parking lot onto a main road. Prior to exiting the parking lot, she heard the engine "rev", where my vehicle began moving forward without her control. She was consistently pressing the brake pedal; to no avail. where my vehicle was only stopped by careening into a nearby yard. She could hear my vehicle's engine continue rev until she turned it off.
NHTSA ODI #11566083
Mileage unknown · Jan 2, 2024
Electrical System
The contact owns a 2015 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware o…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration