NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
303 reports65,000 miles · Nov 14, 2025
Electrical System
The contact owns a 2015 Toyota Rav4. The contact stated that while the vehicle was parked or being driven, water was leaking into the vehicle from the roof, causing water damage to the electrical wiring to the air bags. A dealer was contacted. The vehicle was taken to the dealer, where it was determined that there was a hole in …
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated that while the vehicle was parked or being driven, water was leaking into the vehicle from the roof, causing water damage to the electrical wiring to the air bags. A dealer was contacted. The vehicle was taken to the dealer, where it was determined that there was a hole in the roof and that the roof needed to be removed for a proper investigation. The contact was informed that the air bags could unintendedly deploy unintentionally if not repaired. The vehicle was not repaired. The manufacturer was notified of the failure via letter and phone calls, and the contact was informed that the case had been closed. The approximate failure mileage was 65,000.
NHTSA ODI #11699388
Mileage unknown · Nov 10, 2025
Steering
While driving a 2015 Toyota Rav4 (w/AWD) the vehicle's steering wheel started to shake and the vehicle lost acceleration. The check engine, AWD, and traction (trac) control lights illuminated. After pulling the vehicle over I tried calling AAA. After about 30 minutes, the warning lights went out. I decided to try to drive it hom…
Read full complaint
While driving a 2015 Toyota Rav4 (w/AWD) the vehicle's steering wheel started to shake and the vehicle lost acceleration. The check engine, AWD, and traction (trac) control lights illuminated. After pulling the vehicle over I tried calling AAA. After about 30 minutes, the warning lights went out. I decided to try to drive it home. After about 5 miles the same thing happened. However, after slowing down the problem went away. I called a Toyota dealer and requested a recall service (to fix the power steering assist). They scheduled the appointment and I dropped the vehicle off. When the vehicle was ready I discovered that they only performed the recall for the battery terminal. They informed me that there was no other recall for my VIN number. This problem should be on recall as I've researched and discovered many other complaints similar to mine. These situations like mine, and many others, are safety issues and could easily lead to injury and/or death.
NHTSA ODI #11698564
Mileage unknown · Nov 6, 2025
Steering
There is an intermittent loss of the electric power steering assist. The car can't be steered during this loss of power, leading to an extremely high risk of a crash. Toyota issued a recall for the 2015 RAV4 for this exact problem, but they did not include my car's VIN in the recall. The problem has not been confirmed, as Toyo…
Read full complaint
There is an intermittent loss of the electric power steering assist. The car can't be steered during this loss of power, leading to an extremely high risk of a crash. Toyota issued a recall for the 2015 RAV4 for this exact problem, but they did not include my car's VIN in the recall. The problem has not been confirmed, as Toyota informed me that this could only be done at my expense. The vehicle or component has not been inspected for this problem. There have not been any warning lamps, but it's very obvious while driving that the power steering has failed.
NHTSA ODI #11697838
Mileage unknown · Aug 27, 2025
Unknown Or Other
Was driving on the freeway on my way to work and suddenly i heard this loud pop. I didn't know if a vehicle next to me had a tire blow out or if i had a tire blow out. I pulled over and i checked my car and then i looked on the roof as that is where the loud pop came from and i saw my sunroof broken with a hole in the middle.
NHTSA ODI #11683351
Mileage unknown · Aug 26, 2025
Unknown Or Other
I was driving on the freeway to work. It's a 40 minute commute I make every day Monday to Friday. Half way to my destination, I heard like a loud pop or explosion sound. There was an 18 wheeler on the middle lane to my right and I thought one of its tires exploded and a piece landed on my roof. It felt like something landed on …
Read full complaint
I was driving on the freeway to work. It's a 40 minute commute I make every day Monday to Friday. Half way to my destination, I heard like a loud pop or explosion sound. There was an 18 wheeler on the middle lane to my right and I thought one of its tires exploded and a piece landed on my roof. It felt like something landed on my roof or hit it hard, but not sure what. I also thought maybe my tire blew out, but my tires are all new and were fine. I pulled over to the side and put my emergency break lights on and checked the roof of my car and saw that my sun roof was broken. There is a hole in the middle. \n
NHTSA ODI #11683239
110,000 miles · Aug 25, 2025
Electrical System
The contact owns a 2015 Toyota Rav4. The contact stated that while operating the vehicle, the battery, ABS, and brake warning lights illuminated, and the vehicle stalled on several occasions. The vehicle was jump-started, and the vehicle operated normally. Additionally, the steering wheel became difficult to turn on several occa…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated that while operating the vehicle, the battery, ABS, and brake warning lights illuminated, and the vehicle stalled on several occasions. The vehicle was jump-started, and the vehicle operated normally. Additionally, the steering wheel became difficult to turn on several occasions. The vehicle was taken to the local Auto Zone which replaced the battery, but the failure persisted. The local dealer was notified of the failures, but no assistance was offered. The cause of the failure was not determined. The manufacturer was not contacted. The failure mileage was 110,000.
NHTSA ODI #11682771
Mileage unknown · Aug 22, 2025
Electrical System
See attached document for complaint. text from attached document: To my disappointment, the remedy was not perfo rmed totally. The reason for this was, "improper battery size" . Cont inuing with the message I was texted : "This means we cannot fully complete the recall without replacement of the battery. The recall is to replac…
Read full complaint
See attached document for complaint. text from attached document: To my disappointment, the remedy was not perfo rmed totally. The reason for this was, "improper battery size" . Cont inuing with the message I was texted : "This means we cannot fully complete the recall without replacement of the battery. The recall is to replace hardware that keeps the battery secure due to this happening, this smaller size battery which had been Installed in your car is not properly secured.
NHTSA ODI #11682364
Mileage unknown · Jul 23, 2025
Structure
Request for Resolution -Peeling Paint on 2025 Toyota RAV 4 I am writing to formally file a complaint regarding a paint peeling issue with my 2025 Toyota RAV 4 and Toyota's refusal to address the defect, despite timely reporting and documentation. The paint on my vehicle began peeling around February 2024 and significantly wors…
Read full complaint
Request for Resolution -Peeling Paint on 2025 Toyota RAV 4 I am writing to formally file a complaint regarding a paint peeling issue with my 2025 Toyota RAV 4 and Toyota's refusal to address the defect, despite timely reporting and documentation. The paint on my vehicle began peeling around February 2024 and significantly worsened by January 2025. I promptly filed two complaints with Toyota, and case numbers were opened. Per Toyota's request, I obtained a repair estimate from Toyota of Katy (attached) and submitted it through their system. However, Toyota has since closed both cases without resolving the issue, stating that the paint repair program expired in November 2024. This is particularly troubling because the issue was reported while the paint damage was progressing, I believe this reflects a serious quality defect that affects the appearance, durability, and resale value of the vehicle, and Toyota is failing to take appropriate responsibility. I respectfully request that NHTSA investigate this matter and consider whether similar complaints exist from other Toyota owners experiencing premature paint peeling. Thank you for your attention to this matter
NHTSA ODI #11675776
Mileage unknown · Jul 22, 2025
Electrical SystemFire
After a battery recall was performed on the vehicle at the dealership, a serious safety issue occurred. A short circuit in the battery cable caused a fire in the engine compartment. Fortunately, I was able to extinguish the fire with an extinguisher before it spread, but it happened very close to the gas line and posed a severe …
Read full complaint
After a battery recall was performed on the vehicle at the dealership, a serious safety issue occurred. A short circuit in the battery cable caused a fire in the engine compartment. Fortunately, I was able to extinguish the fire with an extinguisher before it spread, but it happened very close to the gas line and posed a severe danger. We believe the fire may be related to the recall service. The fire caused visible damage to the battery area, and we have documented it with photos and video. We are very concerned about the safety of this vehicle and potential negligence in the recall repair. We are requesting that NHTSA investigate this matter and take appropriate action.
NHTSA ODI #11675487
Mileage unknown · Jun 27, 2025
Electrical SystemPower TrainService Brakes
The battery is off . It does not work. The car does not start. It looks like the battery is not properly installed. I just left my car at the Toyota dealership in June 12 for maintenance services, for brake fluid and flush etc including the replacement of a battery mounting hardware however it does not look right. The car start…
Read full complaint
The battery is off . It does not work. The car does not start. It looks like the battery is not properly installed. I just left my car at the Toyota dealership in June 12 for maintenance services, for brake fluid and flush etc including the replacement of a battery mounting hardware however it does not look right. The car started to go off and today it does not start at all. Please advice Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11669832
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration