Cs Traction Light Is On Cause INTERNAL OPEN IN STEERING ANGLE SENSPR MODULE THE STEERING ANGLE SENSOR TRANSMITS THE STEERING WHEEL'S RATE OF TURN, WHEEL ANGLE, AND OTHER IMPORTANT DATA TO THE SPECIFIC VEHICLE'S COMPUTER. IF THERE IS A FAULT IN THE SIGNAL, THE COMPUTER CAN DISABLE THE VEHICLE'S STABILITY CONTROL. Correction REP…
Read full complaint
Cs Traction Light Is On Cause INTERNAL OPEN IN STEERING ANGLE SENSPR MODULE THE STEERING ANGLE SENSOR TRANSMITS THE STEERING WHEEL'S RATE OF TURN, WHEEL ANGLE, AND OTHER IMPORTANT DATA TO THE SPECIFIC VEHICLE'S COMPUTER. IF THERE IS A FAULT IN THE SIGNAL, THE COMPUTER CAN DISABLE THE VEHICLE'S STABILITY CONTROL. Correction REPLACE STEERING ANGEL SENSOR MODULE
NHTSA ODI #11479597
Mileage unknown · Jun 8, 2022
Steering
Toyota informed me That my 2015 Rav4 is not eligible for Recall no. 15V144000, it does not apply to my VIN. However my Electric Power steering has malfunctioned with 82k miles on the Vehicle
NHTSA ODI #11468235
Mileage unknown · May 23, 2022
Electrical SystemEngineSteering
Power to the vehicle was lost while making a turn under a stop light. Emergency flashers were used. All dashboard lights came on at the time the vehicle lost power. Radio stopped. The car was turned off and was able to be restarted after several seconds. The danger was having a vehicle stopped under a stop light for several seco…
Read full complaint
Power to the vehicle was lost while making a turn under a stop light. Emergency flashers were used. All dashboard lights came on at the time the vehicle lost power. Radio stopped. The car was turned off and was able to be restarted after several seconds. The danger was having a vehicle stopped under a stop light for several seconds. The problem has yet to be repeated. It happened just this morning 5/23/22. No other warnings were given before loss of power. We have not yet had an inspection by any other parties but will plan on it as we are aware there had been an issue with a 12 volt battery case in the past on this model.
NHTSA ODI #11465757
Mileage unknown · Feb 28, 2022
Steering
Power steering suddenly failed (and dash lights came on) when my wife and 6 year old son were driving down the road at highway speeds nearly causing accident. After turning car off and back on, it was restored. NHTSA Campaign ID: 15V144000 addresses this exact issue, but our VIN falls outside those included, even though its the …
Read full complaint
Power steering suddenly failed (and dash lights came on) when my wife and 6 year old son were driving down the road at highway speeds nearly causing accident. After turning car off and back on, it was restored. NHTSA Campaign ID: 15V144000 addresses this exact issue, but our VIN falls outside those included, even though its the same model year. Opened case with Toyota Corporate. Dealer says they have to reproduce issue to do anything, but being an ECU flaw, it nearly impossible to reproduce on demand.
NHTSA ODI #11454413
77,000 miles · Feb 22, 2022
Steering
The contact owns a 2015 Toyota Rav4. The contact stated that while his wife was driving at approximately 50 MPH, the steering wheel seized while the power steering warning light was illuminated intermittently. The contact mentioned that the vehicle lost power steering functionality. The contact stated that the vehicle was restar…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated that while his wife was driving at approximately 50 MPH, the steering wheel seized while the power steering warning light was illuminated intermittently. The contact mentioned that the vehicle lost power steering functionality. The contact stated that the vehicle was restarted and operated as designed. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and provided a case number. The VIN was not included in NHTSA Campaign Number: 15V144000 (Steering). The approximate failure mileage was 77,000.
NHTSA ODI #11453350
Mileage unknown · Dec 18, 2021
Steering
The pump failed
NHTSA ODI #11444248
Mileage unknown · Aug 3, 2021
Steering
The power steering has recently stopped working while driving. When the car is started, the power steering works fine, but within a few minutes, it will stop working and steering has to be done manually.
NHTSA ODI #11427561
20 miles · Mar 3, 2021
Electrical SystemEngineSteering
CAR RANDOMLY SHUT OFF ON MONDAY OF THIS YEAR.ALSO THE RADIO IS DEFECTIVE AND CAR TRY'S TO SWITCH GEARS WHILE DRIVING
NHTSA ODI #11398917
34,000 miles · Feb 10, 2021
Electrical SystemSteering
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CANNOT GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR A FEW DAYS, HAPPENS AGAIN, …
Read full complaint
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CANNOT GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR A FEW DAYS, HAPPENS AGAIN, ENGINE RESTARTS AGAIN RANDOMLY WHILE MAKING A RIGHT TURN, SAME EXACT DESCRIPTION AS DESCRIBED PREVIOUSLY. MULTIPLE DATES OF OCCURENCE
NHTSA ODI #11395581
25 miles · Jan 24, 2021
Electrical SystemEngineSteering
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CAN'T GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR 2 DAYS AND ON THE 3RD DAY, E…
Read full complaint
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CAN'T GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR 2 DAYS AND ON THE 3RD DAY, ENGINE RESTARTS AGAIN RANDOMLY WHILE MAKING A RIGHT TURN, SAME EXACT DESCRIPTION AS DESCRIBED PREVIOUSLY. DRIVEN CAR FOR A DAY AND INCIDENT HASN'T REPEATED YET. BUT, NOW NOT SURE IF THIS AFFECTED IT, SENSORS OF CAR DOOR OPEN SIGN IS ON WHEN CAR IS TURNED OFF AND ALL DOORS AND WINDOWS ARE IN PLACE FOR LOCKING. ONLY WHEN CAR IS OFF AND I CANNOT FIX IT.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration