NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
12 reportsClear category filterMileage unknown · Jan 17, 2024
Fuel/propulsion SystemVehicle Speed Control
My friend was leaving church and cranked my vehicle engine. My friend proceeded to exit the church parking lot onto a main road. Prior to exiting the parking lot, she heard the engine "rev", where my vehicle began moving forward without her control. She was consistently pressing the brake pedal; to no avail. where my vehicle wa…
Read full complaint
My friend was leaving church and cranked my vehicle engine. My friend proceeded to exit the church parking lot onto a main road. Prior to exiting the parking lot, she heard the engine "rev", where my vehicle began moving forward without her control. She was consistently pressing the brake pedal; to no avail. where my vehicle was only stopped by careening into a nearby yard. She could hear my vehicle's engine continue rev until she turned it off.
NHTSA ODI #11566083
Mileage unknown · May 27, 2022
Fuel/propulsion SystemVehicle Speed Control
My vehicle has a problem with torque converter shudder that has gotten worse over time. At first it was shuddering and now vehicle bulks and momentarily slows down at the speed of 20mph thus creating an unsafe situation. Toyota has a Torque Converter Shudder Warranty Enhancement Program (ZH1) for vehicles of my age and mileage, …
Read full complaint
My vehicle has a problem with torque converter shudder that has gotten worse over time. At first it was shuddering and now vehicle bulks and momentarily slows down at the speed of 20mph thus creating an unsafe situation. Toyota has a Torque Converter Shudder Warranty Enhancement Program (ZH1) for vehicles of my age and mileage, but my specific VIN number does not fall under this warranty enhancement. I spoke to Toyota Brand Engagement Center senior adviser Drew and explained to him that it is a safety issue due to my vehicle unexpectedly slowing down in traffic. But he refused to do anything to mitigate this safety concern.
NHTSA ODI #11466414
Mileage unknown · Jun 23, 2021
Fuel/propulsion SystemUnknown Or Other
A. Mileage indicator: Full thank gives any where from 325-365 miles. But indicator goes down precipitously. If it indicates 20 miles, it will go down to 0 or 8 miles after only a 5 miles drive. B: The only safety I feel is put at risk is where it can leave me when my anticipated mileage suddenly goes below what was indicated. C:…
Read full complaint
A. Mileage indicator: Full thank gives any where from 325-365 miles. But indicator goes down precipitously. If it indicates 20 miles, it will go down to 0 or 8 miles after only a 5 miles drive. B: The only safety I feel is put at risk is where it can leave me when my anticipated mileage suddenly goes below what was indicated. C: Have reported to dealer a couple of times but always informed nothing defective could be detected D: Never received any warning signals. Just happens.
NHTSA ODI #11421998
50,493 miles · May 7, 2021
Fuel/propulsion SystemUnknown Or Other
ONGOING ISSUES WITH MY FUEL SYSTEM. CAR WILL DISPLAY ONE OF THESE MANY SYMPTOMS: -MISFIRE, HARD START, STALL OR SHUTOFF. OTHER SYMPTOMS INCLUDE CAR STUTTERING AND STALLING OUT WHILE DRIVING. THIS LAST SYMPTOM IS VERY DANGEROUS AS IT OFTEN COMES WITH NO WARNING. WHEN THE CAR STALLS OUT, THE CAR IS DRIVING UP STRAIGHT UP A MEDIUM…
Read full complaint
ONGOING ISSUES WITH MY FUEL SYSTEM. CAR WILL DISPLAY ONE OF THESE MANY SYMPTOMS: -MISFIRE, HARD START, STALL OR SHUTOFF. OTHER SYMPTOMS INCLUDE CAR STUTTERING AND STALLING OUT WHILE DRIVING. THIS LAST SYMPTOM IS VERY DANGEROUS AS IT OFTEN COMES WITH NO WARNING. WHEN THE CAR STALLS OUT, THE CAR IS DRIVING UP STRAIGHT UP A MEDIUM GRADE HILL. I HAVE EXPERIENCED THIS ON SEVERAL DIFFERENT DATES AND TIMES ALONG W 24TH ST. AUSTIN, TX NEAR 1106 W 24TH ST. THIS WILL HAPPEN IF I'M EITHER STOPPING AT A LIGHT OR WHILE IN MOTION. I DON'T HAVE THE EXACT MPH I AM DRIVING, BUT IT WOULD BE AROUND 20 - 40 MPH WHEN THIS OCCURS. IVE TAKEN THE CARE TO BOTH ROUND ROCK TOYOTA AND CHRISTIAN AUTO BROTHERS TO ADDRESS THE ISSUE. SO FAR, NEITHER HAVE BEEN ABLE TO DIAGNOSE THE PROBLEM. ON 5/22/20, CHRISTIAN AUTO BROTHERS REPLACED THE EVAPORATIVE EMISSIONS SYSTEM LEAK DETECTION UNIT R&R, THE FUEL EVAPORATIVE CANISTER R&R, THE EVAPORATIVE EMISSIONS SYSTEM LEAK DETECTION PUMP, AND THE VAPOR CANISTER PURGE SOLENOID. THIS DID NOT RESOLVE THE ISSUE. CURRENT CODES: P0441, P0455, P1604, P1605, P0171. WHILE NO DIAGNOSTIC PROOF HAS BEEN ESTABLISHED, IT IS HYPOTHESIZED BY THE MECHANICS THAT THERE IS AN ISSUE WITH EITHER THE FUEL PUMP OR THE FUEL LINE. AFTER READING ABOUT THE 2020 TOYOTA FUEL PUMP RECALL, I BELIEVE MY 2015 RAV4 HAS BEEN EXPERIENCING SIMILAR ISSUES. HOWEVER, IT IS NOT PART OF THE RECALL. THEREFORE I AM SUBMITTING THIS INCIDENT INFO TO DOCUMENT THE CURRENT SITUATION. IF I LEARN MORE, I WILL TRY TO UPDATE.
NHTSA ODI #11415574
49,000 miles · Apr 21, 2020
Fuel/propulsion System
CAR WILL NOT START ON 1ST TRY. IT MAY START 2ND OR 3RD TIME WHILE HOLDING GAS PEDDLE TO THE FLOOR. LOUD POPPING SOUND FROM UNDERNEATH THE CAR. SOUNDS LIKE CHANGING GEARS ON A MANUAL. CAR HAS LESS THAN 50K MILES
NHTSA ODI #11321859
25,600 miles · Jan 23, 2017
Fuel/propulsion System
HI, I HAVE A 2015 RAV 4 PURCHASED 9/2015, NEW AND ONLY OWNER...OUT OF NOWHERE JAN. 2017...THE CAR WOULD NOT ACCELERATE PROPERLY...ON HWY AT SPEEDS BETWEEN 60-70MPH AND WHEN I PRESSED THE GAS NOTHING...HAD TO REMOVE FOOT AND PRESS THE GAS AGAIN FOR THE CAR TO ENGAGE AND STAY AT ITS PROPER SPEED. TOYOTA DEALER COULD NOT FIND AN IS…
Read full complaint
HI, I HAVE A 2015 RAV 4 PURCHASED 9/2015, NEW AND ONLY OWNER...OUT OF NOWHERE JAN. 2017...THE CAR WOULD NOT ACCELERATE PROPERLY...ON HWY AT SPEEDS BETWEEN 60-70MPH AND WHEN I PRESSED THE GAS NOTHING...HAD TO REMOVE FOOT AND PRESS THE GAS AGAIN FOR THE CAR TO ENGAGE AND STAY AT ITS PROPER SPEED. TOYOTA DEALER COULD NOT FIND AN ISSUE. JAN. 14TH....THE ISSUE STARTED AGAIN AND I RETURNED IT TO DEALER 1/21 AND STATED ISSUE WAS NOT FIXED...NOW HAPPENING BETWEEN 20-40MPH TOO. DOES NOT OCCUR ALL OF THE TIME AND YET CONSIST ENOUGH THAT IT IS SCARY TO DRIVE.
NHTSA ODI #10946948
Mileage unknown · Aug 12, 2016
Fuel/propulsion System
POOR FUEL ECONOMY GETTING 17MPG
NHTSA ODI #10895323
Mileage unknown · Jul 18, 2016
Fuel/propulsion System
ON JUNE 13, 2016, I NOTICED MY GAS TANK WAS FULL, AFTER IT WAS TANK THE DAY BEFORE. SO, I THOUGHT MY HUSBAND HAD FILLED IT UP BEFORE HE LEFT FOR HIS BUSINESS TRIP THAT MORNING. TOWARDS THE END OF THE WEEK, I NOTICED THE TANK WAS STILL FULL, SO I KNEW SOMETHING WAS NOT RIGHT. SPOKE TO MY HUSBAND WHO HAD THEN CONFIRMED THAT HE …
Read full complaint
ON JUNE 13, 2016, I NOTICED MY GAS TANK WAS FULL, AFTER IT WAS TANK THE DAY BEFORE. SO, I THOUGHT MY HUSBAND HAD FILLED IT UP BEFORE HE LEFT FOR HIS BUSINESS TRIP THAT MORNING. TOWARDS THE END OF THE WEEK, I NOTICED THE TANK WAS STILL FULL, SO I KNEW SOMETHING WAS NOT RIGHT. SPOKE TO MY HUSBAND WHO HAD THEN CONFIRMED THAT HE DID NOT FILL UP THE TANK BEFORE HE LEFT. WENT TO THE GAS STATION AND IT COST ME $34.00 DOLLARS TO FILL IT UP, I ALMOST RAN OUT OF GAS! I COULD HAVE GOTTEN INTO A BAD ACCIDENT IF THIS WOULD HAVE HAPPENED WHILE DRIVING ON THE HIGHWAY! TOOK THE CAR INTO THE DEALERSHIP AND WAS TOLD THAT IT COULD BE EITHER THE FLOATER OR IT COULD HAVE BEEN RODENTS NIBBLING AT THE WIRES, BECAUSE SOMEONE HAD HAD THAT EXPERIENCE ALREADY. ANYWAY, OF COURSE IT ENDS OF BEING THE RODENTS. SO, I SEARCHED THE INTERNET TO GET MORE FAMILIAR WITH THIS PROBLEM AND FOUND A LOAD OF INFORMATION. APPARENTLY, THIS IS CONTRIBUTED TO TOYOTA'S MOVE TO ECO-FRIENDLY ORGANIC WIRING INSULATOR COMPOUNDS THAT ATTRACT RODENTS AS A FOOD SOURCE! THIS IS CAUSING A PROBLEM WITH TOYOTA CAR OWNERS. I HAVE A RAV4 2010 WHICH IS KEPT INSIDE AND THIS SITUATION HAS NEVER HAPPENED. THIS 2015 RAV4, WHICH IS GARAGE KEPT, RODENTS SEEM TO ENJOY. THIS IS A SERIOUS ISSUE BECAUSE PEOPLE HAVE EXPERIENCED WIRING DAMAGE BY MUNCHING RODENTS, WHICH IS NOT COVERED UNDER TOYOTA WARRANTY - A VERY EXPENSIVE PROPOSITION. NOT TO MENTION A SAFETY HAZARD, HAD I RAN OUT OF GAS ON THE HIGHWAY! LAST WEEK, IT COST ME $611.51, HOW MUCH WILL IT COST ME THE NEXT TIME WHEN THEY MUNCH ON ANOTHER PART OF THE CAR?
NHTSA ODI #10885439
5,700 miles · Dec 11, 2015
Electrical SystemFuel/propulsion SystemUnknown Or Other
PURCHASED THIS CAR DEALER CERTIFIED AFTER BEING LEASED FOR 9 MONTHS BY SOMEONE ELSE, FROM NEW ROCHELLE TOYOTA. HAD 5700 MILES ON IT AT THE TIME OF PURCHASE. SINCE PURCHASE IT DOES NOT ALWAYS START THE FIRST TIME, SOMETIMES TAKING 3-4 TIMES TO START, AND MAKING STRANGE NOISES, IT SOUNDS LIKE ITS GOING TO START AND THEN DIES. HAS …
Read full complaint
PURCHASED THIS CAR DEALER CERTIFIED AFTER BEING LEASED FOR 9 MONTHS BY SOMEONE ELSE, FROM NEW ROCHELLE TOYOTA. HAD 5700 MILES ON IT AT THE TIME OF PURCHASE. SINCE PURCHASE IT DOES NOT ALWAYS START THE FIRST TIME, SOMETIMES TAKING 3-4 TIMES TO START, AND MAKING STRANGE NOISES, IT SOUNDS LIKE ITS GOING TO START AND THEN DIES. HAS BEEN TO THE SHOP 3 TIMES AND GOING IN FOR THE 4TH TIME TODAY, ON 12/4 A NEW FUEL PUMP RELAY WAS INSTALLED, STARTS BETTER BUT STILL UNKNOWN REASON WHY IT AT TIMES IT STILL TAKES 3-4 TIMES TO START IT. IS A MYSTERY , NOTHING SHOWS UP ON THE TECH COMPUTERS AFTER IT HAPPENS OVER AND OVER AGAIN. HAVE OWNED TOYOTAS FOR OVER 17 YEARS NEVER EXPECTED AN ISSUE LIKE THIS. ALSO LIGHTS FLICKER AND THERE ARE STRANGE NOISES WHEN ATTEMPTING TO START AND UNSUCCESSFUL. NO RHYME OR REASON TO THIS ISSUE.TOOK POSSESSION OF THE CAR 10-13-15 I THINK IT IS A LEMON. I HAVE A VIDEO OF WHAT HAPPENS DONT THINK I CAN UPLOAD TO THIS WEBSITE.
NHTSA ODI #10809611
Mileage unknown · Dec 5, 2015
Fuel/propulsion System
AFTER FUELING, GAS SPLATTERED ALL OVER ME AND RUINED MY CLOTHING. THIS IS A RENTAL CAR.
NHTSA ODI #10808539
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration