2019 Toyota Highlander

The dealership recommended transmission fluid exchange services for my 2019 Highlander SE after the recommended mileage for this service. I wasn’t able to get this service completed because of timing, however later on the service was completed and after three weeks the vehicle started jerking upon acceleration. Took the Benchley back to the mechanic to diagnose the problem. Per the diagnostic test the issue was determined by this code transmission P0745-7F | Pressure Control Solenoid "A" Actuator Stuck Off - Pending DTC.

My Toyota Highlander 2019 began to produce a whining noise that orginates in the transmission at about 89000 miles. An independent mechanic examined the vehicle and deteremined that the noise is well documented. After conducting research, I found that the issue is caused by improper assembly and the only repair is a complete replacement of the transmission. I also discovered that there is a recall on the 2017-2019 Toyota Highlander due to the 8 speed transmission which is also used in my vehicle. The idea that the 2019-2022 Toyota Highlanders are NOT included in this recall is completely unreasonable. These vehicles utilize the same 8-speed transmission and the whining noise tends to surface after 60, 000 miles - about four to five years based on useage. The whining noise began without warning or symptoms. The vehicle drove without issues and we intended on driving this vehicle into retirement considering the reputation Toyota had on building reliable vehicles. I will never purchase or recommend the purchase of a Toyota vehicle! The idea that repeated transmission failures, without an univeral recall for all years affected, shows that the comsumer is not respected. I would enjoy understanding the logic and data that enabled Toyota to limit the recall to just three production year when the 8-speed transmission spanned six years of production (2017-2022). I am now forced to look into replacing the transmission with potentionally another faulty, improperly assembled 8-speed transmission.

The rear air conditioning refrigerant lines on a 2019 Toyota Highlander SE failed due to excessive rust/corrosion, causing the A/C system to leak refrigerant and stop holding a charge. The failure affected the rear A/C lines that run to the rear of the vehicle. The problem was first diagnosed by an independent repair shop and then confirmed by a Toyota dealer. The Toyota dealer documented that the rear A/C lines were leaking due to excessive rust/corrosion. The dealer recommended replacing the rear A/C lines/cooling lines as a set, evacuating and recharging the A/C system, adding dye, and checking system operation. The repair was completed by the Toyota dealer but not covered or reimbursed. The vehicle/component was inspected by an independent service center and by a Toyota dealer. Toyota corporate customer support was also informed of the dealer diagnosis. The failed component may no longer be available for inspection because the repair has been completed, but repair records, dealer diagnosis, invoice, and related documentation are available. Safety concern: The A/C system failure can affect occupant safety and visibility because air conditioning is used for windshield defogging/defrosting and cabin humidity control. Loss of A/C can reduce the ability to clear the windshield in humid or rainy conditions. It can also create a risk to rear passengers, including children, during hot weather because the rear A/C system is no longer functioning as designed. The failure also involved leaking refrigerant from corroded lines. Toyota will not accept that this is a premature and dangerous parts failure. There were no warning lamps or dashboard messages before the failure. The symptom was that the A/C stopped cooling and would not hold refrigerant. The cause was later confirmed, by Toyota, as leaking rear A/C lines due to excessive rust/corrosion. Toyota has refused goodwill repair even after NUMEROUS persons have reported the same issue online.

I am reporting a potential premature transmission failure in my 2019 Toyota Highlander AWD. At approximately 89,000 miles, the vehicle developed a noticeable and persistent whining noise coming from the transmission/drivetrain area. The noise continued despite transmission service and has progressed to the point where the vehicle requires a transmission replacement. I have had the vehicle evaluated by three separate repair facilities, including transmission specialists. All three independently determined that the transmission has failed and requires replacement. Repair estimates range from approximately $7,200 to $12,000. A complete transmission failure at approximately 89,000 miles is unexpected and raises concerns about a possible design or manufacturing defect. A transmission failure while driving could cause loss of power, inability to accelerate, reduced control of the vehicle, or create a dangerous situation while merging, entering traffic, or traveling at highway speeds. The vehicle has been maintained and used normally. I am submitting this complaint because I believe this issue may affect other Toyota Highlander owners and should be investigated for a potential safety-related defect.

My 2019 Toyota Highlander XLE V6 developed a serious transmission-related safety problem that ultimately resulted in a sudden loss of propulsion while driving. For some time before the failure, I had noticed an unusual startup noise during cold starts and mentioned this concern during routine service visits at an authorized Toyota dealership. I was advised that the condition was normal. Prior to the major failure, the vehicle otherwise remained drivable. On December 2, 2025, the vehicle underwent scheduled maintenance at an authorized Toyota dealership, including a transmission fluid service. Within the following days, during cold weather conditions (approximately 35°F), the vehicle began exhibiting transmission shudder, RPM flare, harsh torque converter engagement, and illuminated both the Check Engine and Traction Control warning lights. I immediately returned the vehicle to the servicing dealership and reported that these symptoms had appeared following the maintenance visit. After inspection, I was informed that the torque converter clutch actuator had failed and that the transmission would require replacement or rebuilding. The vehicle was released to me, and I was not advised that it was unsafe to drive or that it should not be operated. On the morning of December 11, 2025, while driving home from work in approximately 31°F temperatures, the vehicle suddenly lost propulsion. The engine RPM increased, but the vehicle would not move under its own power. I narrowly avoided being rear-ended by a truck traveling behind me. I believe this created a significant risk of a serious collision. The vehicle was towed and remained out of service for approximately two months because replacement transmissions were difficult to obtain. The transmission was ultimately replaced with a used transmission assembly at a total repair cost of approximately $7,220. After the transmission replacement, the unusual startup noise that I had previously reported completely disappeared,

I am filing this safety complaint regarding a known defect in my 2019 Toyota Highlander Hybrid related to the high-pressure fuel system. My vehicle triggered a Check Engine Light with Diagnostic Trouble Code P107B - Fuel Rail Pressure Sensor ‘B’ Circuit Range/Performance. This code appeared multiple times (3 stored faults). Toyota has formally acknowledged this defect by issuing Technical Service Bulletin T-SB-0050-20 specifically for 2018-2019 Highlander Hybrid vehicles. This is a fuel system pressure issue that directly affects the safe and reliable operation of the vehicle. A failure in the fuel rail pressure system can cause: •Sudden loss of engine power while driving •Unexpected stalling at highway speeds •Inability to accelerate when needed, creating a dangerous situation in traffic Despite Toyota acknowledging this defect through TSB T-SB-0050-20, Jim Coleman Toyota (10400 Auto Park Ave, Bethesda, MD 20817, Phone: 301-618-0480) quoted me nearly $3,000 to repair this issue rather than covering it under warranty. I believe Toyota should issue a formal recall to protect all owners of affected vehicles. I am requesting that NHTSA investigate this matter and pressure Toyota to issue a recall covering all 2018-2019 Toyota Highlander Hybrid vehicles affected by this known fuel system defect.

My 2019 Toyota Highlander has taken on water from a leaking Panoramic Sunroof. Both times the dealership ran it through a car wash and it did not leak after cleaning the sun roof drains. Took my car in on 5/4/2026 after a thunderstorm and they cleaned (Tom O’Brien Toyota) the roof drains. Then on the evening of [XXX], we had a heavy thunderstorm which resulted in 3 quarts of water that my husband cleaned off the liner. It was also dripping inside on the armrest. Now I have a sagging liner with water stains. We took the car in again on 5/22/2026 and they cleaned the drains again.We are expected to have rain for the next 3 days. If I leave the liner back it could result in water pouring in the cabin, shorting out the electrical heat warmers on my console. What about MOLD and discoloration? Talk about safety concerns.!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)